REAR TRAILING ARM INSTALLATION

Tech Tips


  • Use the same procedure for the RH side and LH side.

  • The procedure listed below is for the LH side.


  1. INSTALL REAR TRAILING ARM ASSEMBLY


    1. A01NG7QE01
      Text in Illustration
      *1 Jack
      *2 Wooden Block

      Using a jack and wooden block, jack up the rear No. 2 suspension arm assembly to replicate standard vehicle height conditions.

      CAUTION:

      Do not jack up the rear No. 2 suspension arm assembly too high as the vehicle may fall.

    2. A01NG0ZE01

      Install the rear trailing arm assembly to the rear axle carrier sub-assembly with the 2 bolts (A) and 2 washers.

      Torque:
      150 N*m  { 1530 kgf*cm, 111 ft.*lbf }

    3. Install the rear trailing arm assembly to the body with the 2 bolts (B).

      Torque:
      150 N*m  { 1530 kgf*cm, 111 ft.*lbf }

    4. Slowly lower the rear No. 2 suspension arm assembly.

    5. A01NFXT

      Install the No. 3 parking brake cable assembly to the rear trailing arm assembly with the 2 bolts.

      Torque:
      19 N*m  { 192 kgf*cm, 14 ft.*lbf }

      Note

      Do not twist the No. 3 parking brake cable assembly when installing it.

  2. INSTALL REAR SPEED SENSOR (for AWD)


    1. A01NGNW

      Install the rear speed sensor to the rear trailing arm assembly with the bolt.

      Torque:
      8.0 N*m  { 82 kgf*cm, 71 in.*lbf }

      Note

      Do not twist the rear speed sensor when installing it.

  3. CONNECT AIR TUBE (w/ Air Suspension)


    1. A01NCTW

      Install 2 new O-rings, a new plate and a new No. 2 connector, and then connect the air tube to the rear pneumatic cylinder assembly.

      Tech Tips

      For the installing and connecting procedure of the tube (type 2), refer to Precaution of the suspension control system Click here.

  4. INSTALL REAR WHEEL

    Torque:
    103 N*m  { 1050 kgf*cm, 76 ft.*lbf }

  5. INSPECT FOR AIR LEAK (w/ Air Suspension)


    1. Inspect for air leaks Click here.

  6. INSPECT AND ADJUST REAR WHEEL ALIGNMENT


    1. Inspect and adjust the rear wheel alignment Click here.