FRONT DOOR COMPONENTS
ILLUSTRATION
| *1 | NEGATIVE BATTERY TERMINAL | *2 | LUGGAGE COMPARTMENT MAT SUB-ASSEMBLY |
 |
Tightening torque for "Major areas involving basic vehicle performance such as moving/turning/stopping": N*m (kgf*cm, ft.*lbf) | - | - |
ILLUSTRATION
| *1 | FRONT DOOR ARMREST COVER LH | *2 | FRONT DOOR NO. 2 ARMREST COVER LH |
| *3 | FRONT DOOR TRIM BOARD SUB-ASSEMBLY LH | *4 | FRONT DOOR TRIM UPPER COVER LH |
ILLUSTRATION
| *A | for Driver Side | *B | for Front Passenger Side |
| *1 | COURTESY LIGHT ASSEMBLY | *2 | DOOR LOCK CONTROL KNOB BEZEL LH |
| *3 | FRONT DOOR INNER TRIM COVER LH | *4 | FRONT DOOR INSIDE HANDLE SUB-ASSEMBLY LH |
| *5 | FRONT DOOR LOCK CONTROL KNOB HOLDER LH | *6 | MULTIPLEX NETWORK MASTER SWITCH ASSEMBLY |
| *7 | NO. 2 SWITCH BEZEL | *8 | POWER WINDOW REGULATOR SWITCH ASSEMBLY |
| *9 | SEAT MEMORY SWITCH LH | - | - |
ILLUSTRATION
| *A | for 12 Speakers | *B | for 24 Speakers |
| *1 | FRONT DOOR GLASS INNER WEATHERSTRIP LH | *2 | FRONT DOOR PANEL PROTECTOR LH |
| *3 | FRONT DOOR SERVICE HOLE COVER LH | *4 | FRONT DOOR TRIM COVER LH |
| *5 | FRONT DOOR VENT SEAL LH | *6 | FRONT MULTIPLEX NETWORK DOOR ECU LH |
| *7 | FRONT NO. 1 SPEAKER ASSEMBLY | *8 | OUTER MIRROR INSTALL HOLE COVER LH |
| *9 | UPPER DOOR FRAME GARNISH LH | *10 | PLUG HOLE |
| *11 | SERVICE HOLE COVER CLIP | - | - |
| ● | Non-reusable part | - | - |
ILLUSTRATION
| *1 | DOOR SIDE AIR BAG SENSOR LH | *2 | FRONT DOOR ARMREST SET BRACKET LH |
| *3 | FRONT DOOR BELT MOULDING LH | *4 | FRONT DOOR FRONT WINDOW FRAME MOULDING LH |
| *5 | FRONT DOOR NO. 2 WEATHERSTRIP LH | *6 | FRONT DOOR NO. 3 WEATHERSTRIP LH |
| *7 | FRONT DOOR REAR BELT MOULDING END COVER LH | *8 | FRONT DOOR UPPER WINDOW FRAME MOULDING LH |
| *9 | FRONT DOOR WINDOW FRAME MOULDING LH(CENTER PILLAR SIDE) | *10 | OUTER REAR VIEW MIRROR ASSEMBLY LH |
| *11 | RIVET | *12 | SCREW GROMMET |
| |
Tightening torque for "Major areas involving basic vehicle performance such as moving/turning/stopping": N*m (kgf*cm, ft.*lbf) | ● | Non-reusable part |
 |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | DOOR GUIDE PROTECTOR | *2 | FRONT DOOR FRONT GLASS RUN LH |
| *3 | FRONT DOOR GLASS RUN LH | *4 | FRONT DOOR GLASS SUB-ASSEMBLY LH |
| *5 | FRONT DOOR NO. 2 GLASS RUN LH | *6 | FRONT DOOR REAR LOWER FRAME SUB-ASSEMBLY LH |
| *7 | FRONT DOOR REAR WINDOW FRAME LH | *8 | FRONT DOOR WINDOW REGULATOR ASSEMBLY LH |
| *9 | FRONT PILLAR UPPER COVER SUB-ASSEMBLY LH | *10 | RIVET |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
 |
MP grease | - | - |
ILLUSTRATION
| *A | for Driver Side | *B | for Front Passenger Side |
| *1 | FRONT DOOR FRONT OUTSIDE HANDLE PAD | *2 | FRONT DOOR LOCK CYLINDER ASSEMBLY LH |
| *3 | FRONT DOOR LOCK OPEN ROD LH | *4 | FRONT DOOR OUTSIDE HANDLE ASSEMBLY LH |
| *5 | FRONT DOOR OUTSIDE HANDLE COVER RH | *6 | FRONT DOOR OUTSIDE HANDLE FRAME SUB-ASSEMBLY LH |
| *7 | FRONT DOOR REAR OUTSIDE HANDLE PAD | *8 | PLUG HOLE |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | |
MP grease |
ILLUSTRATION
| *1 | FRONT DOOR CHECK ASSEMBLY LH | *2 | FRONT DOOR INSIDE LOCKING CABLE ASSEMBLY LH |
| *3 | FRONT DOOR LOCK COVER SUB-ASSEMBLY LH | *4 | FRONT DOOR LOCK REMOTE CONTROL CABLE ASSEMBLY LH |
| *5 | FRONT DOOR LOCK WITH MOTOR ASSEMBLY LH | *6 | FRONT DOOR NO. 4 WEATHERSTRIP LH |
| *7 | FRONT DOOR PANEL CUSHION | *8 | FRONT DOOR WEATHERSTRIP LH |
| *9 | DOOR LOCK WIRE HARNESS SEAL | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
| |
MP grease | ★ | Precoated part |
 |
Toyota Genuine Adhesive 1324, Three Bond 1324 or equivalent | - | - |