METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST

  1. DATA LIST

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    Note:

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    1. Warm up the engine.

    2. Turn the ignition switch off.

    3. Connect the GTS to the DLC3.

    4. Turn the ignition switch to ON.

    5. Turn the GTS on.

    6. Enter the following menus:

      • *1: Engine Type Gasoline

      • *2: Engine Type Diesel

      1. for Combination Meter: Body Electrical / Combination Meter / Data List / All Data.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List / All Data.

      3. for Engine and ECT*1: Powertrain / Engine and ECT / Data List / All Data.

      4. for Engine*2: Powertrain / Engine / Data List / All Data.

    7. According to the display on the GTS, read the Data List.

      Body Electrical > Combination Meter > Data List

      Tester Display

      Measurement Item

      Range

      Normal Condition

      Diagnostic Note

      Tail Relay SW

      Tail relay

      OFF or ON

      OFF: Headlight dimmer switch in neither tail nor head position

      ON: Headlight dimmer switch in tail or head position

      -

      Tail Cancel SW

      Tail cancel switch

      OFF or ON

      OFF: Tail cancel switch off

      ON: Tail cancel switch on

      -

      ODO/TRIP Change SW

      Steering pad switch (DISP)

      OFF or ON

      OFF: Steering pad switch (DISP) not pressed

      ON: Steering pad switch (DISP) pressed

      -

      P-Seatbelt Buckle SW

      Passenger side seat belt buckle switch

      OFF or ON

      OFF: Passenger side seat belt unfastened

      ON: Passenger side seat belt fastened

      -

      Vehicle Speed Meter

      Vehicle speed

      Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph)

      Almost same as actual vehicle speed

      -

      Engine Rpm

      Engine speed

      Min.: 0 rpm, Max.: 12750 rpm

      Actual engine speed

      -

      Coolant Temperature

      Engine coolant temperature

      0 to 127.5°C (0 to 261.5°F)

      After warming up: 75 to 100°C (167 to 212°F)

      -

      Washer Switch

      Washer switch

      OFF or ON

      OFF: Washer switch off

      ON: Washer switch on

      -

      Oil Level SW

      Engine oil level sensor

      OFF or ON

      OFF: Engine oil level not low

      ON: Engine oil level low

      for 2AD-FHV, 2AD-FTV

      Check Engine SW

      MIL (Malfunction Indicator Light)

      OFF or ON

      OFF: MIL (Malfunction Indicator Light) off

      ON: MIL (Malfunction Indicator Light) on

      -

      Water Level SW

      Fuel filter assembly (sedimenter switch)

      OFF or ON

      OFF: Sedimenter switch off

      ON: Sedimenter switch on

      Engine Type Diesel

      +B Voltage Value

      Battery voltage

      Min.: 0 V, Max.: 25.5 V

      11 to 14 V

      -

      Integrated value for Maintenance

      Oil maintenance mileage

      Min.: 0 mile, Max.: 25500 mile

      Almost same as oil maintenance mileage

      -

      Fuel Input

      Fuel input signal

      Min.: 0 L, Max. 127.5 L

      Current fuel level displayed

      -

      Ambient Temperature

      Outside temperature

      Min.: -40°C, Max.: 87.5°C

      Almost same as actual outside temperature

      -

      Rheostat value

      Light control rheostat value

      Min.: 0%, Max.: 100%

      0 to 100%

      -

      Multi Switch (Up)

      Steering pad switch (Up)

      OFF or ON

      OFF: Steering pad switch (Up) released

      ON: Steering pad switch (Up) pushed

      -

      Multi Switch (Down)

      Steering pad switch (Down)

      OFF or ON

      OFF: Steering pad switch (Down) released

      ON: Steering pad switch (Down) pushed

      -

      Multi Switch (Enter)

      Steering pad switch (Enter)

      OFF or ON

      OFF: Steering pad switch (Enter) released

      ON: Steering pad switch (Enter) pushed

      -

      Multi Switch (Right)

      Steering pad switch (Right)

      OFF or ON

      OFF: Steering pad switch (Right) released

      ON: Steering pad switch (Right) pushed

      -

      Multi Switch (Left)

      Steering pad switch (Left)

      OFF or ON

      OFF: Steering pad switch (Left) released

      ON: Steering pad switch (Left) pushed

      -

      2nd-Row Seatbelt Buckle (R)

      Rear seat belt buckle switch RH

      OFF or ON

      OFF: Rear seat belt RH fastened

      ON: Rear seat belt RH unfastened

      w/ Rear Seat Belt Warning

      2nd-Row Seatbelt Buckle (L)

      Rear seat belt buckle switch LH

      OFF or ON

      OFF: Rear seat belt LH fastened

      ON: Rear seat belt LH unfastened

      w/ Rear Seat Belt Warning

      2nd-Row Seatbelt Buckle (C)

      Rear seat belt buckle switch center

      OFF or ON

      OFF: Rear seat belt center fastened

      ON: Rear seat belt center unfastened

      w/ Rear Seat Belt Warning

      Oil Pressure Switch

      Engine oil pressure switch

      OFF or ON

      OFF: Engine oil pressure not low

      ON: Engine oil pressure low

      -

      Turn Signal Switch (Right)

      Turn signal switch (right)

      OFF or ON

      OFF: Turn signal switch (right) off

      ON: Turn signal switch (right) on

      -

      Turn Signal Switch (Left)

      Turn signal switch (left)

      OFF or ON

      OFF: Turn signal switch (left) off

      ON: Turn signal switch (left) on

      -

      Hazard Flasher Switch

      Hazard warning signal switch

      OFF or ON

      OFF: Hazard warning signal switch off

      ON: Hazard warning signal switch on

      -

      Headlight Auto Leveling Switch

      Headlight auto leveling switch

      OFF or ON

      OFF: Headlight auto leveling switch off

      ON: Headlight auto leveling switch on

      -

      Driver Side Seatbelt Buckle Switch

      Driver side seat belt buckle switch

      OFF or ON

      OFF: Driver seat belt fastened

      ON: Driver seat belt unfastened

      -

      Turn Switch Signal (Full Turn)

      Turn signal switch (full turn)

      OFF or ON

      OFF: Turn signal switch (full turn) off

      ON: Turn signal switch (full turn) on

      -

      Multi Switch (Back)

      Steering pad switch (Back)

      OFF or ON

      OFF: Steering pad switch (Back) released

      ON: Steering pad switch (Back) pushed

      -

      Brake Fluid Amount

      Brake master cylinder reservoir sub-assembly (brake fluid level warning switch)

      OFF or ON

      OFF: Brakefluid level warning switch off

      ON: Brakefluid level warning switch on

      -

      ECO Drive Indicator Zone

      The condition of the eco driving indicator zone display

      OFF or ON

      Customize setting displayed

      -

      ODO Display Time After IG OFF Setting

      Condition of the odo display time

      30 s, 60 s, 600 s or OFF

      Customize setting displayed

      -

      Lane Change Flashing Times Setting

      Condition of the lane change flashing time

      OFF, 3, 4, 5, 6 or 7

      Customize setting displayed

      -

      Flasher Sound Volume Adjustment

      Condition of the flasher sound volume adjustment

      Small, Medium or Large

      Customize setting displayed

      -

      TPMS System

      Existence of function

      With/Without

      With: w/ Tire pressure warning system

      Without: w/o Tire pressure warning system

      -

      LDA System

      Existence of function

      With/Without

      With: w/ Lane departure alert system

      Without: w/o Lane departure alert system

      -

      PCS System

      Existence of function

      With/Without

      With: w/ Pre-crash safety system

      Without: w/o Pre-crash safety system

      -

      Radar Cruise System

      Existence of function

      With/Without

      With: w/ Dynamic radar cruise control system

      Without: w/o Dynamic radar cruise control system

      -

      Clearance Sonar System

      Existence of function

      With/Without

      With: w/ Clearance sonar system

      Without: w/o Clearance sonar system

      -

      Back Door System

      Existence of function

      With/Without

      With: w/ Power back door system

      Without: w/o Power back door system

      -

      Road Sign Assist System

      Existence of function

      With/Without

      With: w/ Road sign assist system

      Without: w/o Road sign assist system

      -

      Number of Trouble Code

      The number of the DTC currently stored

      Min.: 0, Max.: 255

      0

      -

      Chassis > ABS/VSC/TRC > Data List

      Tester Display

      Measurement Item

      Range

      Normal Condition

      Diagnostic Note

      Vehicle Speed

      Vehicle speed

      Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)

      Almost same as actual vehicle speed measured using speedometer tester

      -

      Powertrain > Engine and ECT > Data List

      Tester Display

      Measurement Item

      Range

      Normal Condition

      Diagnostic Note

      Engine Speed

      Engine speed

      Min.: 0 rpm, Max.: 16383 rpm

      750 to 850 rpm: Idling with warm engine

      -

      Coolant Temp

      Engine coolant temperature

      Min.: -40°C (-40°F), Max: 215°C (419°F)

      60 to 90°C (140 to 194°F): After warming up engine

      -

      Powertrain > Engine

      Tester Display

      Measurement Item

      Range

      Normal Condition

      Diagnostic Note

      Engine Speed

      Engine speed

      Min.: 0 rpm, Max.: 16383 rpm

      750 to 850 rpm: Idling with warm engine

      -

      Coolant Temp

      Engine coolant temperature

      Min.: -40°C (-40°F), Max: 215°C (419°F)

      60 to 90°C (140 to 194°F): After warming up engine

      -

  2. ACTIVE TEST

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the GTS on.

    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    5. According to the display on the GTS, perform the Active Test.

      Body Electrical > Combination Meter > Active Test

      Tester Display

      Measurement Item

      Control Range

      Diagnostic Note

      Speed Meter Operation

      Speedometer

      OFF, 0, 40, 80, 120, 160 or 200 (km/h or mph)

      Acceptable range (km/h or mph): [Control range → Speedometer display]

      • for Australia

      • 40 → 40.6 to 45.1

      • 80 → 81.2 to 86.2

      • 120 → 121.8 to 126.8

      • 160 → 162.4 to 167.4

      • 200 → 203 to 208

      • except Australia (km/h)

      • 40 → 41.7 to 46.2

      • 80 → 83.4 to 88.4

      • 120 → 125.1 to 130.6

      • 160 → 166.2 to 173.2

      • 200 → 207.7 to 215.7

      • except Australia (MPH)

      • 40 → 42 to 44.5

      • 80 → 83.1 to 87.1

      • 120 → 124.7 to 129.6

      TachoMeter Operation

      Tachometer

      OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000 or 7000 (rpm)

      -

      Fuel Meter Operation

      Fuel receiver gauge

      OFF, Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full or Sender F

      -

      A/T Indicator Operation 1

      Shift position indicator (L, 2, 3, 4, D, N, R or P)

      OFF, L, 2, 3, 4, D, N, R or P

      except Manual Transaxle

      A/T Indicator Operation 2

      Shift position indicator (5, 6, 7, S, M or B)

      OFF, 8, 5, 6, 7, Es, M, S or B

      except Manual Transaxle

      A/T Indicator Operation 3

      Shift position indicator (D)

      OFF or D

      except Manual Transaxle

      Indicat. Lamp Airbag

      SRS warning light

      OFF or ON

      -

      Indicat. Lamp Doors All Open

      Open door warning light

      OFF or ON

      for Segment Display Type

      Driver Side Seat Belt

      Front seat belt warning light

      OFF or ON

      -

      Indicat. Lamp ABS

      ABS warning light

      OFF or ON

      -

      Indicat. Lamp Charge

      Charge warning light

      OFF or ON

      for Segment Display Type

      Indicat. Lamp Slip

      Slip indicator light

      OFF or ON

      -

      Indicat. Lamp Coolant Hot

      Engine coolant temperature warning light

      OFF or ON

      for Segment Display Type

      Indicat GLOW

      Glow indicator light

      OFF or ON

      Engine Type Diesel

      Indicat. Lamp Beam

      High beam indicator light

      OFF or ON

      for TFT Display Type

      Indicat. Lamp Tail

      Tail indicator light

      OFF or ON

      for TFT Display Type

      Indicat. Lamp Fr FOG

      Front fog indicator light

      OFF or ON

      for TFT Display Type

      Indicat. Lamp Rr FOG

      Rear fog indicator light

      OFF or ON

      for TFT Display Type, w/ Rear Fog Light

      Indicat. Lamp Fuel

      Fuel level warning light

      OFF or ON

      -

      VSC TRC Indicator

      TRC OFF indicator light

      OFF or ON

      for Segment Display Type, w/ VSC

      4WD Warning Indicator

      4WD/AWD warning light

      OFF or ON

      for 4WD/AWD

      Indicat. Tire Pressure Warning System

      Tire pressure warning light

      OFF or ON

      w/ Tire Pressure Warning System

      Indicat. Oil Pressure

      Engine oil pressure warning light

      OFF or ON

      for Segment Display Type

      Indicat. Lamp Water Level

      Washer level indicator light

      OFF or ON

      for Segment Display Type, w/ Wahser Fluid Warning System

      Indicat. ECONO

      Eco driving indicator light

      OFF or ON

      for Segment Display Type

      A/T Oil Temperature Operation

      A/T OIL TEMP warning light

      OFF or ON

      for Segment Display Type

      Indicat. Lamp Cruise

      Cruise control indicator light (green)

      OFF or ON

      for Segment Display Type, w/ Cruise Control System

      Indicat. Lamp Oil Level

      Oil level indicator light

      OFF or ON

      for Segment Display Type, for AD Series Engine

      Indicat. Lamp Brake

      Brake warning light

      OFF or ON

      -

      Indicat. EPS

      EPS warning light

      OFF or ON

      -

      Indicat. Over Speed

      Speed limit indicator light

      OFF or ON

      for Middle East, for Segment Display Type

      Maintenance Indicator

      Maintenance request indicator light

      OFF or ON

      for Segment Display Type, for AD Series Engine

      Master Warning

      Master warning light

      OFF or ON

      for TFT Display Type

      Indicat. Auto LSD

      AUTO LSD indicator light

      OFF or ON

      for 2WD, w/ VSC

      Indicat. Downhill Assist Control

      Downhill assist control indicator light

      OFF or ON

      w/ Downhill Assist Control

      Indicat. SET

      SET indicator light

      OFF or ON

      for Segment Display Type, w/ Cruise Control System

      Indicat. SIL (Up)

      Shift up indicator light

      OFF or ON

      for Segment Display Type, w/ Gear Shift Indicator

      Indicat. SIL (Down)

      Shift down indicator light

      OFF or ON

      for Segment Display Type, w/ Gear Shift Indicator

      Indicat. VSC OFF

      VSC OFF indicator light

      OFF or ON

      w/ VSC

      Indicat. ECO MODE

      ECO MODE indicator light

      OFF or ON

      for Segment Display Type

      Rear Seat Belt

      Rear seat belt warning light

      OFF or ON

      -

      Indicat. 4WD Lock

      4WD/AWD lock indicator light

      OFF or ON

      for 4WD/AWD, for Segment Display Type

      Automatic High Beam Indicator

      Automatic high beam indicator light

      OFF or ON

      for TFT Display Type, w/ Automatic High Beam System

      Cruise Indicator

      Cruise control indicator light (yellow)

      OFF or ON

      for Segment Display Type, w/ Cruise Control System

      LED Head Lamp Warning

      LED headlight indicator light

      OFF or ON

      for Segment Display Type, for LED Headlight

      Turn Signal (Left) Indicator

      Turn indicator light (LH)

      OFF or ON

      -

      Turn Signal (Right) Indicator

      Turn indicator light (RH)

      OFF or ON

      -

      Smart System Indicator

      Entry warning light

      OFF or ON

      for Segment Display Type, w/ Entry and Start System

      Smart System Warning

      Entry warning light

      OFF or ON

      for Segment Display Type, w/ Entry and Start System

      Check Engine Indicator

      MIL (Malfunction Indicator Light)

      OFF or ON

      for TFT Display Type

      Diesel Particulate Filter Warning

      DPF warning light

      OFF or ON

      for Segment Display Type, w/ DPF

      Stop and Start ON Indicator

      Stop and start indicator light

      OFF or ON

      for TFT Display Type, w/ Stop and Start System

      Stop and Start OFF Indicator

      Stop and start cancel indicator light

      OFF or ON

      for TFT Display Type, w/ Stop and Start System

      Water Temperature Meter Operation

      Engine coolant temperature receiver gauge

      OFF, LOW, NORMAL or HIGH

      for TFT Display Type

      Meter Display 1

      Multi-information display

      OFF, 6, 5, 4, 3, 2,1, 0 or All

      for TFT Display Type

      Meter Display 2

      Multi-information display

      OFF, 9, 8 or 7

      for TFT Display Type