METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST

  1. DATA LIST

    Note:

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    Tip:

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    1. Warm up the engine.

    2. Turn the ignition switch off.

    3. Connect the GTS to the DLC3.

    4. Turn the ignition switch to ON.

    5. Turn the GTS on.

    6. Enter the following menus:

      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for 1KR-FE:

        for Engine and ECT: Powertrain / Engine and ECT / Data List.

      4. for 1PP:

        for Engine: Powertrain / Engine / Data List.

    7. Read the Data List according to the display on the GTS.

      1. Combination Meter

        Body Electrical > Combination Meter > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Tail Relay SW

        Tail relay

        OFF or ON

        OFF: Tail relay off

        ON: Tail relay on

        -

        P-Seatbelt Buckle SW

        Front passenger seat belt buckle switch

        OFF or ON

        OFF: Front passenger seat belt fastened (seat belt warning light off)

        ON: Front passenger seat belt unfastened (seat belt warning light on)

        -

        Vehicle Speed Meter

        Vehicle speed

        Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph)

        Almost the same as actual vehicle speed

        -

        Engine Rpm

        Engine speed

        Min.: 0 rpm, Max.: 12750 rpm

        Almost the same as actual engine speed

        -

        Coolant Temperature

        Engine coolant temperature

        Min.: 0°C (32°F), Max.: 127.5°C (261.5°F)

        for 1KR-FE:

        75 to 100°C (167 to 212°F): After warming up engine

        for 1PP:

        84°C (183°F): After warming up engine

        -

        +B Voltage Value

        Battery voltage

        Min.: 0 V, Max.: 25.5 V

        11 to 14 V

        -

        Fuel Input

        Fuel input

        Min.: 0 L, Max.: 127.5 L

        6th segment comes on: 30.4 to 33.1

        5th segment comes on: 24.3 to 30.4

        4th segment comes on: 18.6 to 24.3

        3rd segment comes on: 12.3 to 18.6

        2nd segment comes on: 6.23 to 12.3

        1st segment comes on: 4.61 to 6.23

        Unit: Liter

        Ambient Temperature

        Outside temperature

        Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F)

        Almost the same as actual outside temperature

        The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F)

        Multi Switch (Right)

        DISP switch (Right)

        OFF or ON

        OFF: Switch released

        ON: Switch pushed

        -

        Multi Switch (Left)

        DISP switch (Left)

        OFF or ON

        OFF: Switch released

        ON: Switch pushed

        -

        2nd-Row Seatbelt Buckle (R)

        Rear seat belt buckle switch RH

        OFF or ON

        OFF: Rear seat belt RH fastened

        ON: Rear seat belt RH unfastened

        -

        2nd-Row Seatbelt Buckle (L)

        Rear seat belt buckle switch LH

        OFF or ON

        OFF: Rear seat belt LH fastened

        ON: Rear seat belt LH unfastened

        -

        Oil Pressure Switch

        Oil pressure switch

        OFF or ON

        OFF: Engine started

        ON: Engine not started

        -

        Turn Signal Switch (Right)

        RH turn signal switch

        OFF or ON

        OFF: RH turn signal switch off

        ON: RH turn signal switch on

        -

        Turn Signal Switch (Left)

        LH turn signal switch

        OFF or ON

        OFF: LH turn signal switch off

        ON: LH turn signal switch on

        -

        Hazard Flasher Switch

        Hazard warning signal switch

        OFF or ON

        OFF: Hazard warning signal switch off

        ON: Hazard warning signal switch on

        -

        Driver Side Seatbelt Buckle Switch

        Driver seat belt buckle switch

        OFF or ON

        OFF: Driver seat belt fastened

        ON: Driver seat belt unfastened

        -

        Parking Brake Switch

        Parking brake switch

        OFF or ON

        OFF: Parking brake released

        ON: Parking brake applied

        -

        Driver Side Door

        Driver door

        CLOSE or OPEN

        CLOSE: Driver door closed

        OPEN: Driver door open

        -

        Door All (Except for Driver Side Seat)

        Any door (except driver door)

        CLOSE or OPEN

        CLOSE: Any door (except driver door) closed

        OPEN: Any door (except driver door) open

        -

        Turn Switch Signal (Full Turn)

        Turn signal switch signal

        OFF or ON

        OFF: LH and RH turn signal switch off

        ON: LH or RH turn signal switch on

        -

        Driver Side Seatbelt Warning Buzzer

        Setting of the driver seat belt warning buzzer

        OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        Displays customize setting of Driver Side Seatbelt Warning Buzzer

        P-Seatbelt Warning Buzzer

        Setting of the front passenger seat belt warning buzzer

        OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        Displays customize setting of Front Passenger Side Seatbelt Warning Buzzer

        Rear Seatbelt Warning Buzzer

        Setting of the rear seat belt warning buzzer

        OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        Displays customize setting of Rear Seatbelt Warning Buzzer

        ODO Display Time After IG OFF Setting

        Setting of the ODO display time after the ignition switch is turned off

        30s, 60s, 600s, OFF

        Displays customize setting of ODO Display Time After IG OFF setting

        -

        Lane Change Flashing Times Setting

        Setting of the lane change flashing times

        OFF, 3, 5, 7

        Displays customize setting of Lane Change Flashing Times Setting

        -

        TPMS System

        Existence of function

        Without or With

        Without: w/o Tire pressure warning system

        With: w/ Tire pressure warning system

        -

        LDA System

        Existence of function

        With or Without

        With: w/ Lane departure alert system

        Without: w/o Lane departure alert system

        -

        VSC System

        Existence of function

        Without or With

        Without: w/o VSC

        With: w/ VSC

        -

        PCS System

        Existence of function

        With or Without

        With: w/ Pre-crash safety system

        Without: w/o Pre-crash safety system

        -

        Flasher Sound Tone Setting

        Setting of the flasher sound tone

        Tone 1, Tone 2, Tone 3

        Displays customize setting of Flasher Sound Tone Setting

        -

        Number of Trouble Code

        The number of the DTC currently stored

        Min.: 0, Max.: 255

        0

        -

      2. ABS/VSC/TRC

        Chassis > ABS/VSC/TRC > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Vehicle Speed

        Maximum wheel speed sensor reading

        Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)

        Vehicle stopped: 0 km/h (0 mph)

        When driving at constant speed: No large fluctuations

      3. Engine and ECT (for 1KR-FE)

        Powertrain > Engine and ECT > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Engine Speed

        Engine speed

        Min.: 0 rpm, Max.: 16383 rpm

        790 to 890 rpm: Idling

        When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed.

        Coolant Temp

        Engine coolant temperature

        Min.: -40°C (-40°F), Max.: 140°C (284°F)

        75 to 100°C (167 to 212°F): After warming up

        This is the engine coolant temperature.

        Tip:

        • After warming up the engine, the engine coolant temperature is 75 to 100°C (167 to 212°F).

        • After a long soak, the engine coolant temperature, intake air temperature and ambient air temperature are approximately equal.

        • If the value is -40°C (-40°F), or 140°C (284°F), the sensor circuit is open or shorted.

      4. Engine (for 1PP)

        Powertrain > Engine > Data List

        Tester Display

        Measurement Item

        Range

        Reference Value

        Engine Regime

        Engine speed

        Min.: 0 rpm, Max.: 8000 rpm

        846 rpm:

        Idle (warmed up)

        Water Temperature Not Corrected

        Water Temperature Not Corrected

        Min.: -50°C (-58°F), Max.: 150°C (302°F)

        84°C (183°F):

        Idle (warmed up)

  2. ACTIVE TEST

    Tip:

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the GTS on.

    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    5. Perform the Active Test according to the display on the GTS.

      Body Electrical > Combination Meter > Active Test

      Tester Display

      Measurement Item

      Control Range

      Diagnostic Note

      Speed Meter Operation

      Speedometer

      • OFF, 0, 40, 80 mph*7

      • OFF, 0, 40, 80, 120, 160 km/h*8

      There is a deviation in the values displayed on the speedometer (Control range → Speedometer display)

      • Reference mph*7:

      • 40 → 42 to 44.5

      • 80 → 83.1 to 87.1

      • Reference km/h*8:

      • 40 → 41.7 to 46.2

      • 80 → 83.4 to 88.4

      • 120 → 125.1 to 130.6

      • 160 → 166.2 to 173.2

      TachoMeter Operation

      Tachometer

      OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000, 7000

      *9

      Fuel Meter Operation

      Fuel receiver gauge

      OFF, Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full, Sender F

      -

      Indicat. Lamp Airbag

      SRS warning light

      OFF or ON

      -

      Indicat. Lamp Doors All Open

      Door open warning light

      OFF or ON

      -

      Front Passenger Side Seat Belt

      Driver or front passenger seat belt warning light

      OFF or ON

      -

      Driver Side Seat Belt

      Driver or front passenger seat belt warning light

      OFF or ON

      -

      Indicat. Lamp ABS

      ABS warning light

      OFF or ON

      -

      Indicat. Lamp Charge

      Charge warning light

      OFF or ON

      -

      Indicat. Lamp Slip

      Slip indicator light

      OFF or ON

      *1

      Indicat. Lamp Coolant Hot

      Engine coolant temperature hot warning light

      OFF or ON

      -

      Indicat. Precrash

      PCS OFF warning light

      OFF or ON

      *10

      Indicat. Lamp Fuel

      Fuel level warning light

      OFF or ON

      -

      VSC TRC Indicator

      TRC OFF indicator light

      OFF or ON

      *1

      Indicat. Tire Pressure Warning System

      Tire pressure warning light

      OFF or ON

      *2

      Indicat. Oil Pressure

      Engine oil pressure warning light

      OFF or ON

      -

      Indicat. Lamp Brake

      Brake warning light

      OFF or ON

      -

      Indicat. EPS

      EPS warning light

      OFF or ON

      -

      Indicat. MMT E Mode

      Multi-mode manual transaxle warning light

      OFF or ON

      *3

      Indicat. SIL (Up)

      Shift up indicator light

      OFF or ON

      -

      Indicat. SIL (Down)

      Shift down indicator light

      OFF or ON

      -

      Indicat. ASL

      Adjustable speed limiter indicator light (Green)

      OFF or ON

      *4

      Indicat. VSC OFF

      VSC OFF indicator light

      OFF or ON

      *1

      Turn Signal (Left) Indicator

      LH turn indicator light

      OFF or ON

      -

      Turn Signal (Right) Indicator

      RH turn indicator light

      OFF or ON

      -

      Smart System Indicator

      Smart key warning light (Green)

      OFF or ON

      *5

      Smart System Warning

      Smart key warning light (Amber)

      OFF or ON

      *5

      ASL Warning Indicator

      Adjustable speed limiter indicator light (Amber)

      OFF or ON

      *4

      Check Engine Indicator

      MIL (Check engine warning light)

      OFF or ON

      *11

      Stop and Start ON Indicator

      Stop and start indicator light

      OFF or ON

      *6

      Stop and Start OFF Indicator

      Stop and start off indicator light

      OFF or ON

      *6

      LDA Control Indicator

      Lane departure alert indicator light (Green)

      OFF or ON

      *10

      LDA Warning Indicator

      Lane departure alert indicator light (Amber)

      OFF or ON

      *10

      LDA Control Indicator (Left)

      Lane departure alert left line indicator light (Green)

      OFF or ON

      *10

      LDA Warning Indicator (Left)

      Lane departure alert left line indicator light (Amber)

      OFF or ON

      *10

      LDA Control Indicator (Right)

      Lane departure alert right line indicator light (Green)

      OFF or ON

      *10

      LDA Warning Indicator (Right)

      Lane departure alert right line indicator light (Amber)

      OFF or ON

      *10

      Vehicle Stop Indicator

      STOP indicator light

      OFF or ON

      -

      PCS Warning Indicator

      PCS warning light

      OFF or ON

      *10

      Meter Display 1

      Multi-information display

      OFF, 6, 5, 4, 3, 2, 1, 0, All

      -

      Meter Display 2

      Multi-information display

      OFF, 9, 8, 7

      -

      • *1: w/ VSC

      • *2: w/ Tire Pressure Warning System

      • *3: for Multi-mode Manual Transaxle

      • *4: w/ Adjustable Speed Limiter System

      • *5: w/ Entry and Start System

      • *6: w/ Stop and Start System

      • *7: for Speedometer with Imperial Units for Main Scale

      • *8: for Speedometer with Metric Units for Main Scale

      • *9: w/ Tachometer

      • *10: w/ Pre-crash Safety System

      • *11: for 1KR-FE