ENGINE ASSEMBLY COMPONENTS
ILLUSTRATION
*1 |
FRONT FLOOR COVER |
*2 |
FRONT FLOOR COVER RH |
*3 |
NO. 1 ENGINE COVER |
*4 |
NO. 1 ENGINE UNDER COVER |
*5 |
NO. 2 ENGINE UNDER COVER |
*6 |
REAR ENGINE UNDER COVER LH |
*7 |
REAR ENGINE UNDER COVER RH |
- |
- |
 |
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
AIR CLEANER CAP SUB-ASSEMBLY WITH AIR CLEANER HOSE ASSEMBLY |
*2 |
AIR CLEANER CASE SUB-ASSEMBLY |
*3 |
AIR CLEANER FILTER ELEMENT SUB-ASSEMBLY |
*4 |
VACUUM HOSE |
*5 |
VENTILATION HOSE |
*6 |
NO. 1 FUEL HOSE |
*7 |
NO. 2 FUEL HOSE |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
FRONT EXHAUST PIPE ASSEMBLY |
*2 |
TAILPIPE ASSEMBLY |
*3 |
COMPRESSION SPRING |
*4 |
GASKET |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
ILLUSTRATION
*1 |
FRONT LOWER BUMPER ABSORBER |
*2 |
FRONT BUMPER CENTER STAY SUB-ASSEMBLY |
*3 |
FRONT BUMPER UPPER REINFORCEMENT SUB-ASSEMBLY |
*4 |
FRONT RADIATOR SIDE AIR GUIDE PLATE LH |
*5 |
FRONT RADIATOR SIDE AIR GUIDE PLATE RH |
*6 |
LOWER RADIATOR AIR GUIDE PLATE |
*7 |
REAR RADIATOR SIDE AIR GUIDE PLATE LH |
*8 |
REAR RADIATOR SIDE AIR GUIDE PLATE RH |
*9 |
UPPER RADIATOR AIR GUIDE PLATE |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
BATTERY |
*2 |
BATTERY BRACKET REINFORCEMENT |
*3 |
BATTERY CARRIER ASSEMBLY |
*4 |
BATTERY CLAMP SUB-ASSEMBLY |
*5 |
BATTERY INSULATOR |
*6 |
BATTERY TRAY |
*7 |
ENGINE WIRE |
*8 |
ECM |
*9 |
ENGINE ROOM RELAY BLOCK AND JUNCTION BLOCK COVER |
*10 |
POSITIVE BATTERY TERMINAL |
*11 |
NEGATIVE BATTERY TERMINAL |
*12 |
GROUND WIRE |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
HOOD LOCK ASSEMBLY |
*2 |
NO. 1 RADIATOR SUPPORT |
*3 |
NO. 2 RADIATOR SUPPORT |
*4 |
WATER BY-PASS HOSE ASSEMBLY |
*5 |
UPPER RADIATOR SUPPORT |
*6 |
RADIATOR SUPPORT CUSHION |
*7 |
NO. 5 WATER BY-PASS HOSE |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*A |
w/ Air Conditioning System |
- |
- |
*1 |
DISCHARGE HOSE SUB-ASSEMBLY |
*2 |
RADIATOR ASSEMBLY |
*3 |
RADIATOR HOSE SUB-ASSEMBLY |
*4 |
SUCTION HOSE SUB-ASSEMBLY |
*5 |
COOLER CONDENSER ASSEMBLY |
*6 |
NO. 2 AIR HOSE |
*7 |
NO. 3 AIR HOSE |
*8 |
NO. 2 AIR TUBE |
*9 |
O-RING |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
 |
for HFC-134a(R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf(R1234yf): Compressor oil ND-OIL 12 or equivalent |
- |
- |
ILLUSTRATION
*A |
w/ Air Conditioning System |
- |
- |
*1 |
AIR CLEANER BRACKET |
*2 |
DISCHARGE HOSE SUB-ASSEMBLY |
*3 |
FUEL FILTER ASSEMBLY |
*4 |
FUEL FILTER SUPPORT |
*5 |
NO. 1 AIR TUBE ASSEMBLY |
*6 |
RADIATOR RESERVOIR ASSEMBLY |
*7 |
SUCTION HOSE SUB-ASSEMBLY |
*8 |
TRANSMISSION CONTROL CABLE ASSEMBLY |
*9 |
WATER BY-PASS HOSE ASSEMBLY |
*10 |
WATER HOSE SUB-ASSEMBLY |
*11 |
INLET HEATER WATER HOSE |
*12 |
AIR CONDITIONER TUBE AND ACCESSORY ASSEMBLY |
*13 |
SUCTION PIPE SUB-ASSEMBLY |
*14 |
NO. 4 WATER BY-PASS HOSE |
*15 |
COMPRESSOR OUTLET ELBOW |
*16 |
NO. 1 FUEL FILTER PROTECTOR |
*17 |
PIN |
*18 |
O-RING |
*19 |
RADIATOR HOSE SUB-ASSEMBLY |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
|
for HFC-134a(R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf(R1234yf): Compressor oil ND-OIL 12 or equivalent |
- |
- |
ILLUSTRATION
*1 |
CLUTCH RELEASE CYLINDER ASSEMBLY |
*2 |
FRONT ENGINE MOUNTING BRACKET LOWER REINFORCEMENT |
*3 |
FUEL HOSE |
*4 |
NO. 2 FUEL HOSE |
*5 |
GROUND CABLE |
*6 |
VACUUM HOSE |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
COLUMN HOLE COVER SILENCER SHEET |
*2 |
NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY |
*3 |
FRONT AXLE SHAFT NUT LH |
*4 |
FRONT STABILIZER LINK ASSEMBLY LH |
*5 |
FRONT SPEED SENSOR LH |
*6 |
TIE ROD END SUB-ASSEMBLY LH |
*7 |
FRONT SUSPENSION NO. 1 LOWER ARM SUB-ASSEMBLY LH |
*8 |
FRONT DRIVE SHAFT ASSEMBLY RH |
*9 |
FRONT DRIVE SHAFT ASSEMBLY LH |
*10 |
FRONT DRIVE SHAFT HOLE SNAP RING LH |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
|
MP grease |
 |
Do not apply lubricants to the threads |
ILLUSTRATION
*1 |
FRONT ENGINE MOUNTING INSULATOR |
*2 |
FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY |
*3 |
FRONT SUSPENSION MEMBER REAR BRACE LH |
*4 |
FRONT SUSPENSION MEMBER REAR BRACE RH |
*5 |
FRONT SUSPENSION MEMBER REINFORCEMENT LH |
*6 |
FRONT SUSPENSION MEMBER REINFORCEMENT RH |
*7 |
REAR ENGINE MOUNTING INSULATOR |
*8 |
FRONT CROSSMEMBER SUB-ASSEMBLY |
*9 |
ENGINE MOUNTING BRACKET LH |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
★ |
Precoated part |
ILLUSTRATION
*1 |
STARTER ASSEMBLY |
*2 |
FRONT ENGINE MOUNTING BRACKET |
*3 |
MANUAL TRANSAXLE ASSEMBLY |
*4 |
REAR ENGINE MOUNTING BRACKET |
*5 |
NO. 2 MANIFOLD STAY |
*6 |
NO. 1 CLUTCH HOUSING COVER |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*1 |
ENGINE MOUNTING INSULATOR LH |
*2 |
ENGINE MOUNTING INSULATOR SUB-ASSEMBLY RH |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |