CAUTION / NOTICE / HINT
Tech Tips
Use the same procedure for RHD and LHD vehicles.
The procedure listed below is for LHD vehicles.
PROCEDURE
INSTALL SEAT POSITION AIRBAG SENSOR
Positioning Pin | |
Positioning Hole |
Align the positioning pin of the seat position airbag sensor and the positioning hole of the bracket, insert a washer in between the parts and set the parts into place.
Using a T30 "TORX" socket wrench, install a new "TORX" bolt.
Note
Do not reuse the "TORX" bolt.
Install in this Direction |
Install the seat slide position sensor protector to the bracket.
Set the seat position airbag sensor together with the seat slide position sensor protector as shown in the illustration.
Note
Do not subject the seat position airbag sensor to any strong impact (such as dropping).
*a | Check Location |
Check that the bracket protrusion is in the positioning hole of the front seat assembly LH and temporarily install a new "TORX" bolt and washer.
Using a T30 "TORX" socket wrench, tighten the "TORX" bolt.
*a | Check Location |
Check that the bracket protrusion is in the positioning hole of the front seat assembly LH again.
*1 | Seat Position Airbag Sensor |
*a | 0.6 to 2 mm (0.024 to 0.079 in.) |
*b | Seat Rail |
*c | Adjustment Support |
Feeler Gauge |
Using a feeler gauge, measure the clearance between the seat position airbag sensor and seat rail.
Standard |
---|
0.6 to 2.0 mm (0.024 to 0.079 in.) |
Note
Do not reuse parts if dropped or subjected to any strong impact during operation.
Check that a 1.3 mm (0.052 in.)clearance is maintained between the seat position airbag sensor and seat rail.
If the result is not as specified, loosen the installation "TORX" bolt of the seat position airbag sensor and adjust the clearance.
Tech Tips
With the adjustment support as an axis, adjust the clearance by moving the seat position airbag sensor up or down.
Connect the connector.
Check that there is no looseness in the installed seat position airbag sensor.
INSTALL FRONT SEAT ASSEMBLY LH
PERFORM DIAGNOSTIC SYSTEM CHECK
CHECK SRS WARNING LIGHT