METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST


  1. DATA LIST

    Note

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    Tech Tips

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.


    1. Warm up the engine.

    2. Turn the ignition switch off.

    3. Connect the GTS to the DLC3.

    4. Turn the ignition switch to ON.

    5. Turn the GTS on.

    6. Enter the following menus:


      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for Engine and ECT: Powertrain / Engine and ECT / Data List.

      4. for Main Body: Body Electrical / Main Body / Data List.

    7. Read the Data List according to the display on the GTS.


      1. Combination Meter


        Body Electrical > Combination Meter > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Tail Relay SW Tail relay OFF or ON

        OFF: Tail relay off

        ON: Tail relay on

        *5
        ODO/TRIP Change SW ODO/TRIP switch OFF or ON

        OFF: Switch not pushed

        ON: Switch pushed

        *5
        P-Seatbelt Buckle SW Front passenger seat belt buckle switch OFF or ON

        OFF: Front passenger seat belt fastened (warning light off)

        ON: Front passenger seat belt unfastened (warning light on)

        -
        Vehicle Speed Meter Vehicle speed Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost the same as actual vehicle speed -
        Engine Rpm Engine speed Min.: 0 rpm, Max.: 12750 rpm Almost the same as actual engine speed -
        Coolant Temperature Engine coolant temperature Min.: 0°C (32°F), Max.: 127.5°C (261.5°F)

        except 1WW:

        75 to 100 °C (167 to 212°F): After warming up engine

        for 1WW:

        75 to 90°C (167 to 194°F): After warming up engine

        -
        Washer Switch Washer fluid level warning switch OFF or ON

        OFF: Washer fluid level not low

        ON: Washer fluid level low

        *7
        Oil Level SW Engine oil level sensor OFF or ON

        OFF: Engine oil level not low

        ON: Engine oil level low

        *8
        Water Level SW Water level switch OFF or ON

        OFF: Small amount of water in fuel

        ON: Large amount of water in fuel

        *1
        Multi Display Select Switch DISP switch OFF or ON

        OFF: DISP switch not pressed

        ON: DISP switch pressed

        *2, *5
        +B Voltage Value Battery voltage Min.: 0 V, Max.: 25.5 V 11 to 14 V -
        Fuel Input Fuel input Min.: 0 L, Max.: 127.5 L

        for Gasoline:


        • for Hatchback, Wagon


          • Fuel receiver gauge indicates F: 44.7 L

          • Fuel receiver gauge indicates 1/2: 25.0 L

          • Fuel receiver gauge indicates E: 5.0 L


        • for Sedan


          • Fuel receiver gauge indicates F: 49.1 L

          • Fuel receiver gauge indicates 1/2: 27.7 L

          • Fuel receiver gauge indicates E: 6.0 L

        for Diesel:


        • for Hatchback, Wagon


          • Fuel receiver gauge indicates F: 44.1 L

          • Fuel receiver gauge indicates 1/2: 25.0 L

          • Fuel receiver gauge indicates E: 5.0 L


        • for Sedan


          • Fuel receiver gauge indicates F: 48.3 L

          • Fuel receiver gauge indicates 1/2: 28.9 L

          • Fuel receiver gauge indicates E: 5.2 L

        -
        Ambient Temperature Outside temperature Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) Almost the same as actual outside temperature The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F)
        Multi Switch (Up) Steering pad switch (Up) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Multi Switch (Down) Steering pad switch (Down) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Multi Switch (Menu) Steering pad switch (TRIP) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Multi Switch (Enter) Steering pad switch (Enter) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Multi Switch (Right) Steering pad switch (Right) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Multi Switch (Left) Steering pad switch (Left) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        2nd-Row Seatbelt Buckle (R) Rear seat belt buckle switch RH OFF or ON

        OFF: Rear seat belt RH fastened

        ON: Rear seat belt RH unfastened

        *3
        2nd-Row Seatbelt Buckle (L) Rear seat belt buckle switch LH OFF or ON

        OFF: Rear seat belt LH fastened

        ON: Rear seat belt LH unfastened

        *3
        2nd-Row Seatbelt Buckle (C) Rear seat belt buckle switch center OFF or ON

        OFF: Rear seat belt center fastened

        ON: Rear seat belt center unfastened

        *3
        Oil Pressure Switch Oil pressure switch OFF or ON

        OFF: Engine started

        ON: Engine not started

        *4
        Turn Signal Switch (Right) RH turn signal switch OFF or ON

        OFF: RH turn signal switch off

        ON: RH turn signal switch on

        -
        Turn Signal Switch (Left) LH turn signal switch OFF or ON

        OFF: LH turn signal switch off

        ON: LH turn signal switch on

        -
        Hazard Flasher Switch Hazard warning switch OFF or ON

        OFF: Switch released

        ON: Switch pushed

        -
        Multi Switch (Back) Steering pad switch (Back) OFF or ON

        OFF: Switch released

        ON: Switch pushed

        *9
        Key Remind Sound Cycle of the key reminder warning buzzer Normal, Slow, Fast Displays customize setting of key remind sound -
        Driver Side Seatbelt Warning Buzzer Setting of the driver seat belt warning buzzer OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        Displays customize setting of driver side seat belt warning buzzer
        P-Seatbelt Warning Buzzer Setting of the front passenger seat belt warning buzzer OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        Displays customize setting of front passenger side seat belt warning buzzer
        Rear Seatbelt Warning Buzzer Setting of the rear seat belt warning buzzer OFF or ON

        OFF: Rear seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        ON: Rear seat belt warning displayed buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        Displays customize setting of rear seat belt warning buzzer*3
        Units By Region Unit of the cruise information display Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g Displays customize setting of units by region*5
        ECO Drive Indicator Zone Setting of the eco driving indicator zone OFF or ON

        OFF: Eco driving indicator zone not displayed

        ON: Eco driving indicator zone displayed

        Displays customize setting of ECO drive indicator zone*5, *6
        ODO Display Time After IG OFF Setting Setting of the ODO display time after the ignition switch is turned off 30s, 60s, 600s, OFF Displays customize setting of ODO display time after IG off setting -
        Lane Change Flashing Times Setting Setting of the lane change flashing times OFF, 3, 5, 7 Displays customize setting of lane change flashing times setting -
        TPMS System Existence of function With or Without

        With: w/ Tire pressure warning system

        Without: w/o Tire pressure warning system

        -
        LDA System Existence of function With or Without

        With: w/ Lane departure alert system

        Without: w/o Lane departure alert system

        -
        VSC System Existence of function With or Without

        With: w/ Vehicle stability control system

        Without: w/o Vehicle stability control system

        -
        PCS System Existence of function With or Without

        With: w/ Pre-crash safety system

        Without: w/o Pre-crash safety system

        -
        Clearance Sonar System Existence of function With or Without

        With: w/ TOYOTA parking assist sensor system

        Without: w/o TOYOTA parking assist sensor system

        -
        Road Sign Assist System Existence of function With or Without

        With: w/ Road sign assist system

        Without: w/o Road sign assist system

        -
        Number of Trouble Code The number of the DTCs currently stored Min.: 0, Max.: 255 0 -

        • *1: for Diesel

        • *2: w/ Steering Pad Switch

        • *3: w/ Rear Seat Belt Warning

        • *4: except 8NR-FTS, Diesel

        • *5: for Multi-information Display (Segment LCD Type)

        • *6: for CVT

        • *7: w/ Washer Fluid Level Warning

        • *8: for 8NR-FTS, 1ND-TV

        • *9: for Multi-information Display (Color Type)

      2. ABS/VSC/TRC


        Chassis > ABS/VSC/TRC > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Vehicle Speed Maximum wheel speed sensor reading Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Vehicle stopped: 0 km/h (0 mph) When driving at constant speed: No large fluctuations
      3. Engine and ECT (for Gasoline)


        Powertrain > Engine and ECT > Data List
        Tester Display Measurement Item Range Normal Condition Reference Value Diagnostic Note
        Engine Speed Engine speed Min.: 0 rpm, Max.: 16383 rpm

        for 2ZR-FE, 1ZR-FE:

        600 to 700 rpm: Idling

        for 1ZR-FAE:


        • 680 to 780 rpm: Idling (for CVT models)

        • 580 to 680 rpm: Idling (for manual transaxle models)

        for 8NR-FTS:


        • 680 to 780 rpm: Idling (shift lever in N, engine warmed up and A/C off) (CVT models)

        • 600 to 700 rpm: Idling (shift lever in neutral, engine warmed up and A/C off) (M/T models)

        for 1NR-FE

        600 to 700 rpm: Idling with warm engine, shift lever in neutral, A/C off

        for 1NR-FE, 2ZR-FE, 1ZR-FE:

        -

        for 1ZR-FAE:

        Idling (engine warmed up and A/C off): 747 rpm

        for 8NR-FTS:

        Idling (engine warmed up and A/C off): 710 rpm (CVT models)

        When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed.

        except 1ZR-FAE, 8NR-FTS:


        • Stored as Freeze Frame Data: Yes

        • When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed.

        Coolant Temp Engine coolant temperature Min.: -40°C (-40°F), Max.: 140°C (284°F) 75 to 100°C (167 to 212°F): After warming up engine -

        This is the engine coolant temperature.

        Tech Tips


        • After warming up the engine, the engine coolant temperature is 75 to 100°C (167 to 212°F).

        • After a long soak, the engine coolant temperature, intake air temperature and ambient temperature are approximately equal.

        • If the value is -40°C (-40°F), or 140°C (284°F), the sensor circuit is open or shorted. (for 1NR-FE, 2ZR-FE, 1ZR-FAE, 8NR-FTS)

        • Check if the engine overheats when the value indicates 140°C (284°F). (for 1NR-FE, 2ZR-FE, 1ZR-FAE, 8NR-FTS)

        • If the value is -40°C (-40°F), or higher than 135°C (275°F), the sensor circuit is open or shorted. (for 1ZR-FE)

        • Check if the engine overheats when the value indicates higher than 135°C (275°F). (for 1ZR-FE)

      4. Engine and ECT (for Diesel)


        Powertrain > Engine and ECT > Data List
        Tester Display Measurement Item Type Range Normal Condition Reference Value Diagnostic Note
        Engine Speed Engine speed

        for 1ND-TV:

        Sensor output (crankshaft position sensor)

        for 1WW:

        -

        Min.: 0 rpm, Max.: 16383 rpm

        for 1ND-TV:

        Idling with warm engine: 720 to 820 rpm

        for 1WW:

        -

        for 1ND-TV:

        Idling ("Coolant Temp" = 77°C [171°F]): 770 rpm

        for 1WW:

        Idling (warm up the engine): 830 rpm

        for 1ND-TV:

        When the crankshaft position sensor is malfunctioning, "Engine speed" is approximately 0 rpm or varies greatly from the actual engine speed.

        Cause of Out of Range:


        • Crankshaft position sensor

        • Crankshaft position sensor circuit

        for 1WW:

        -

        Coolant Temp Engine coolant temperature

        for 1ND-TV:

        Sensor output (engine coolant temperature sensor)

        for 1WW:

        -

        for 1ND-TV:

        Min.: -40°C, Max.: 140°C

        for 1WW:

        Min.: -40°C, Max.: 215°C

        for 1ND-TV:

        After warming up engine: 75 to 100°C (167 to 212°F)

        for 1WW:

        After warming up engine: 75 to 90°C (167 to 194°F)

        for 1ND-TV:

        After warming up engine: 75°C (167°F)

        for 1WW:

        -

        for 1ND-TV:


        • After a long soak, the coolant temperature, intake air temperature, and ambient air temperature are approximately equal.

        • If the value is -30°C (-22°F) or less, or 120°C (248°F) or higher, the sensor circuit is open or shorted.

        Cause of Out of Range:


        • Engine coolant temperature sensor

        Symptoms when out of range:

        Difficult starting when engine is cold, rough idle, black smoke, lack of power

        for 1WW:

        -

      5. Main Body


        Body Electrical > Main Body > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Illumination Rate Info Illumination rate information 0.00 ms. to 2162.65 ms. Value is output according to ambient light level -
  2. ACTIVE TEST

    Tech Tips

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the GTS on.

    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    5. Perform the Active Test according to the display on the GTS.


      Body Electrical > Combination Meter > Active Test
      Tester Display Measurement Item Control Range Diagnostic Note
      Speed Meter Operation Speedometer
      • OFF, 0, 40, 80, 120, 160, 200, 240 km/h*15

      • OFF, 0, 40, 80, 120, 160 mph*16

      -
      TachoMeter Operation Tachometer OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000*2, 7000*2 -
      Fuel Meter Operation Fuel receiver gauge OFF, Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full, Sender F -
      A/T Indicator Operation 1 Shift indicator OFF, L, 2, 3(M), 4(M), D, N, R, P -
      A/T Indicator Operation 2 Shift indicator OFF, 5, 6, 7, Es, M, S, B -
      A/T Indicator Operation 3 Shift indicator OFF, D *14
      Indicat. Lamp Airbag SRS warning light OFF or ON -
      Indicat. Lamp Doors All Open Door open warning light OFF or ON *4
      Front Passenger Side Seat Belt Driver or front passenger seat belt warning light OFF or ON -
      Driver Side Seat Belt Driver or front passenger seat belt warning light OFF or ON -
      Indicat. Lamp ABS ABS warning light OFF or ON -
      Indicat. Lamp Charge Charge warning light OFF or ON *4
      Indicat. Lamp Slip Slip indicator light OFF or ON *3
      Indicat. Lamp Coolant Hot Engine coolant temperature hot warning light OFF or ON *4
      Indicat GLOW Glow warning light OFF or ON *5
      Indicat. Lamp Beam High beam indicator light OFF or ON *23
      Indicat. Lamp Tail Tail indicator light OFF or ON *6
      Indicat. Lamp Fr FOG Front fog indicator light OFF or ON *21, *23
      Indicat. Lamp Rr FOG Rear fog indicator light OFF or ON *22, *23
      Indicat. Pre-Collision PCS OFF warning light OFF or ON *19
      Indicat. Headlamp Auto Leveling Headlight leveling warning light OFF or ON *4, *20
      Indicat. Lamp Fuel Fuel level warning light OFF or ON -
      VSC TRC Indicator TRC OFF indicator light OFF or ON *3, *4
      Indicat. Tire Pressure Warning System Tire pressure warning light OFF or ON *18
      Indicat. Oil Pressure Engine oil pressure warning light OFF or ON *4
      Indicat. Lamp Water Level Fuel sedimenter warning light OFF or ON *4, *5
      Indicat. ECONO Eco driving indicator light OFF or ON *4, *8
      Indicat. Lamp Cruise Cruise main indicator light (Green) OFF or ON *4, *9
      Indicat. Lamp Oil Level Engine oil level warning light OFF or ON *4, *5
      Indicat. Lamp Brake Brake warning light OFF or ON -
      Indicat. EPS EPS warning light OFF or ON -
      Maintenance Indicator Oil maintenance warning light OFF or ON *4, *5
      Indicat. MMT E Mode Multi-mode manual transaxle warning light OFF or ON *10
      Master Warning Master warning light OFF or ON *6
      Indicat. Clearance Sonar LCD Clearance sonar indicator light OFF or ON *17
      Indicat. SET Cruise SET indicator light OFF or ON *4, *9
      Indicat. SIL (Up) Shift up indicator light OFF or ON *4, *11
      Indicat. SIL (Down) Shift down indicator light OFF or ON *4, *11
      Indicat. ASL Adjustable speed limiter indicator light (Green) OFF or ON *4, *12
      Indicat. Sport(CVT Sport) Sport indicator light OFF or ON *4, *8
      Indicat. VSC OFF VSC OFF indicator light OFF or ON *3
      Rear Seat Belt Rear seat belt warning light OFF or ON *13
      Automatic High Beam Indicator Automatic high beam indicator light OFF or ON *20
      Cruise Indicator Cruise main indicator light (Amber) OFF or ON *4, *9
      LED Head Lamp Warning LED headlight warning light OFF or ON *4, *20
      Turn Signal (Left) Indicator LH turn indicator light OFF or ON -
      Turn Signal (Right) Indicator RH turn indicator light OFF or ON -
      Smart System Indicator Smart key warning light (Green) OFF or ON *1, *4
      Smart System Warning Smart key warning light (Amber) OFF or ON *1, *4
      ASL Warning Indicator Adjustable speed limiter indicator light (Amber) OFF or ON *4, *12
      Check Engine Indicator MIL (Check engine warning light) OFF or ON *6
      Diesel Particulate Filter Warning DPF warning light OFF or ON *4, *5
      Stop and Start ON Indicator Stop and start indicator light OFF or ON *4, *7
      Stop and Start OFF Indicator Stop and start off warning light OFF or ON *4, *7
      Water Temperature Meter Operation Engine coolant temperature receiver gauge OFF, LOW, NORMAL, HIGH -
      Meter Display 1 Multi-information display
      • Multi-information display (Color Type):

        OFF, All

      • Multi-information display (Segment LCD Type):

        OFF, 6, 5, 4, 3, 2, 1, 0, All

      -
      Meter Display 2 Multi-information display OFF, 9, 8, 7 *4

      • *1: w/ Entry and Start System

      • *2: for Gasoline

      • *3: w/ VSC

      • *4: for Multi-information Display (Segment LCD Type)

      • *5: for Diesel

      • *6: for Multi-information Display (Color Type)

      • *7: w/ Stop and Start System

      • *8: for CVT

      • *9: w/ Cruise Control System

      • *10: for Multi-mode Manual Transaxle

      • *11: w/ Shift Up or Down Indicator Light

      • *12: w/ Speed Limiter System

      • *13: w/ Rear Seat Belt Warning

      • *14: w/ Shift Paddle Switch

      • *15: for Speedometer with Metric Units for Main Scale

      • *16: for Speedometer with Imperial Units for Main Scale

      • *17: w/ TOYOTA Parking Assist-sensor System

      • *18: w/ Tire Pressure Warning System

      • *19: w/ Pre-crash Safety System

      • *20: for LED Headlight

      • *21: w/ Front Fog Light

      • *22: w/ Rear Fog Light

      • *23: for Sedan and Multi-information Display (Color Type)