TIRE PRESSURE WARNING SYSTEM Tire Pressure Warning Light Circuit

DESCRIPTION

If the tire pressure warning ECU and receiver detects a disconnected connector or an open circuit between the tire pressure warning ECU and receiver and combination meter assembly, the tire pressure warning light blinks for 1 minute, and then remains on after the ignition switch ON.

WIRING DIAGRAM

A004RF9E25

CAUTION / NOTICE / HINT

Note


  • When replacing the tire pressure warning ECU and receiver, read the transmitter IDs stored in the old ECU using the GTS and write them down before removal.

  • It is necessary to perform initialization (See page ) after registration Click here of the transmitter IDs into the tire pressure warning ECU and receiver if the ECU has been replaced.

PROCEDURE


  1. CHECK HARNESS AND CONNECTOR (COMBINATION METER ASSEMBLY - ECU)


    1. Disconnect the tire pressure warning ECU and receiver G61*1 or L1*2 connector.


      • *1: for Sedan

      • *2: for Wagon

    2. Disconnect the combination meter assembly D66 connector.

    3. Measure the resistance according to the value(s) in the table below.

      Standard Resistance
      for Sedan
      Tester Connection Condition Specified Condition
      G61-5 (IND) - D66-26 (TIRE) Always Below 1 Ω
      G61-5 (IND) or D66-26 (TIRE) - Body ground Always 10 kΩ or higher
      for Wagon
      Tester Connection Condition Specified Condition
      L1-5 (IND) - D66-26 (TIRE) Always Below 1 Ω
      L1-5 (IND) or D66-26 (TIRE) - Body ground Always 10 kΩ or higher

    NG
    OK
  2. CHECK OPERATION OF TIRE PRESSURE WARNING LIGHT (ACTIVE TEST)


    1. Turn the ignition switch off.

    2. Connect the GTS to the DLC3.

    3. Turn the ignition switch to ON.

    4. Turn the GTS on.

    5. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    6. Check the condition of the tire pressure warning light by using the GTS.

      Combination Meter
      Tester Display Test Part Control Range Diagnostic Note
      Indicat. Tire Pressure Warning System Tire pressure warning light OFF or ON Confirm that the vehicle is stopped with the engine idling.
      OK
      The tire pressure warning light turns on or off in accordance with the GTS operation.
      Result
      Result Proceed to
      OK (for Sedan) A
      OK (for Wagon) B
      NG C

    A
    B
    C