INSPECT SPIRAL WITH SENSOR CABLE SUB-ASSEMBLY (w/o Steering Heater)
Visually check for defects with the spiral cable removed from the vehicle.
The defects are as follows:
Scratches on the spiral cable
Small cracks on the spiral cable
Dents on the spiral cable
Chips on the spiral cable
Cracks or other damage to the connector
OK |
---|
No defects are found. |
Tech Tips
If any of the defects is found, replace the spiral cable with sensor sub-assembly new a one.
Inspect the spiral cable.
*a | Component without harness connected (Spiral Cable Sub-assembly) |
*b | Color: Orange |
*c | Color: Black | - | - |
Interlock | - | - |
Measure the resistance according to the value(s) in the table below.
Note
When rotating the spiral cable, make sure to push on the interlock indicated in the illustration to release the interlock mechanism.
To avoid breakage of the spiral cable, do not turn the spiral cable more than necessary.
Tester Connection | Condition | Specified Condition |
---|---|---|
N30-1 (D+) - z3-2 (D+) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-2 (D-) - z3-1 (D-) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-3 (D2-) - z2-1 (D2-) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-4 (D2+) - z2-2 (D2+) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-1 (CCS) - z8-3 (CCS) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-2 (ECC) - z8-4 (ECC) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-2 (ECC) - z4-7 (ECC) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-3 (EAU) - z4-8 (EAU) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-4 (GND1) - z4- 9 (GND1) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-5 (AU2) - z4-10 (AU2) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-6 (AU1) - z4-11 (AU1) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-7 (SDN) - z4-12 (SDN) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-8 (R/N) - z8-1 (R/N) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-9 (HO) - z4-1 (HO) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-10 (+DP) - z4-2 (+DP) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-11 (-DP) - z4-3 (-DP) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right |
If the value is not within the specified range, replace the spiral cable with sensor sub-assembly.
INSPECT SPIRAL CABLE SUB-ASSEMBLY (w/ Steering Heater)
Visually check for defects with the spiral cable removed from the vehicle.
The defects are as follows:
Scratches on the spiral cable
Small cracks on the spiral cable
Dents on the spiral cable
Chips on the spiral cable
Cracks or other damage to the connector
OK |
---|
No defects are found. |
Tech Tips
If any of the defects is found, replace the spiral cable with a new one.
Inspect the spiral cable.
*a | Component without harness connected (Spiral Cable Sub-assembly) |
*b | Color: Orange |
*c | Color: Black | - | - |
Interlock | - | - |
Measure the resistance according to the value(s) in the table below.
Note
When rotating the spiral cable, make sure to push on the interlock indicated in the illustration to release the interlock mechanism.
To avoid breakage of the spiral cable, do not turn the spiral cable more than necessary.
Tester Connection | Condition | Specified Condition |
---|---|---|
N30-1 (D+) - z3-2 (D+) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-2 (D-) - z3-1 (D-) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-3 (D2-) - z2-1 (D2-) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N30-4 (D2+) - z2-2 (D2+) | Center | Less than 1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-1 (CCS) - z8-3 (CCS) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-2 (ECC) - z8-4 (ECC) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-2 (ECC) - z4-7 (ECC) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-3 (EAU) - z4-8 (EAU) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-4 (GND1) - z4- 9 (GND1) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-5 (AU2) - z4-10 (AU2) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-6 (AU1) - z4-11 (AU1) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-7 (SDN) - z4-12 (SDN) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-8 (R/N) - z8-1 (R/N) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-9 (HO) - z4-1 (HO) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-10 (+DP) - z4-2 (+DP) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-11 (-DP) - z4-3 (-DP) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-12 (DIST) - z4- 4 (DIST) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-13 (IL+2) - z4-5 (IL+2) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N31-14 (SUP) - z4-6 (SUP) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N32-2 (EHT) - z5-3 (EHT) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N32-4 (BHT) - z5-4 (BHT) | Center | Below 3 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N32-1 (BTM) - z5-1 (BTM) | Center | Less than 0.1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right | ||
N32-3 (ETM) - z5-2 (ETM) | Center | Less than 0.1 Ω |
2.5 rotations to the left | ||
2.5 rotations to the right |
If the value is not within the specified range, replace the spiral cable with sensor sub-assembly.