METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST

  1. DATA LIST

    Tip:

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    Note:

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    1. Warm up the engine.

    2. Turn the ignition switch off.

    3. Connect the GTS to the DLC3.

    4. Turn the ignition switch to ON.

    5. Turn the GTS on.

    6. Enter the following menus:

      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for Engine and ECT: Powertrain / Engine and ECT / Data List.

      4. for Main Body: Body Electrical / Main Body / Data List.

    7. Check the values by referring to the table below.

      1. Combination Meter

        Body Electrical > Combination Meter > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Tail Relay SW

        Tail relay

        OFF or ON

        OFF: Tail relay off

        ON: Tail relay on

        -

        ODO/TRIP Change SW

        ODO/TRIP switch

        OFF or ON

        OFF: Switch not pushed

        ON: Switch pushed

        -

        P-Seatbelt Buckle SW

        Front passenger seat belt buckle switch

        OFF or ON

        OFF: Front passenger seat belt fastened (warning light off)

        ON: Front passenger seat belt unfastened (warning light on)

        -

        Vehicle Speed Meter

        Vehicle speed

        Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph)

        Almost the same as actual vehicle speed

        -

        Engine Rpm

        Engine speed

        Min.: 0 rpm, Max.: 12750 rpm

        1NR-FE, 2ZR-FE, 1ZR-FE:

        600 to 700 rpm (Idling)

        1ZR-FAE:

        • 600 to 700 rpm (Idling (for CVT))

        • 580 to 680 rpm (Idling (for Multi-mode manual transaxle))

        1AD-FTV, 1ND-TV:

        • 720 to 820 rpm (Idling)

        -

        Coolant Temperature

        Engine coolant temperature

        Min.: 0°C (32°F), Max.: 127.5°C (261.5°F)

        1NR-FE, 1ZR-FAE, 2ZR-FE, 1ZR-FE:

        75 to 100°C (167 to 212°F) (After warming up engine)

        1AD-FTV:

        60 to 90°C (140 to 194°F) (After warming up engine)

        1ND-TV:

        75 to 100°C (167 to 212°F) (After warming up engine)

        -

        Washer Switch

        Washer fluid level warning switch

        OFF or ON

        OFF: Washer fluid level not low

        ON: Washer fluid level low

        *2, *7

        Oil Level SW

        Engine oil level sensor

        OFF or ON

        OFF: Oil level not low

        ON: Oil level low

        *1

        Water Level SW

        Water level switch

        OFF or ON

        OFF: Small amount of water in fuel

        ON: Large amount of water in fuel

        *1

        Multi Display Select Switch

        DISP switch

        OFF or ON

        OFF: DISP switch not pressed

        ON: DISP switch pressed

        *2

        +B Voltage Value

        Battery voltage

        Min.: 0 V, Max.: 25.5 V

        11 to 14 V

        -

        Fuel Input

        Fuel input

        Min.: 0 L, Max.: 127.5 L

        Fuel receiver gauge indicates F: 44.7 L (for Gasoline)

        Fuel receiver gauge indicates F: 44.1 L (for Diesel)

        Fuel receiver gauge indicates 3/4: 35.0 L

        Fuel receiver gauge indicates 1/2: 25.0 L

        Fuel receiver gauge indicates 1/4: 15.0 L

        Fuel receiver gauge indicates E: 5.0 L

        -

        Ambient Temperature

        Outside temperature

        Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F)

        Almost the same as actual outside temperature

        The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F)

        2nd-Row Seatbelt Buckle (R)

        Rear seat belt buckle switch RH

        OFF or ON

        ON: Rear seat belt buckle switch RH unfastened

        OFF: Rear seat belt buckle switch RH fastened

        *3

        2nd-Row Seatbelt Buckle (L)

        Rear seat belt buckle switch LH

        OFF or ON

        ON: Rear seat belt buckle switch LH unfastened

        OFF: Rear seat belt buckle switch LH fastened

        *3

        2nd-Row Seatbelt Buckle (C)

        Rear seat belt buckle switch center

        OFF or ON

        ON: Rear seat belt buckle switch center unfastened

        OFF: Rear seat belt buckle switch center fastened

        *3

        Oil Pressure Switch

        Oil pressure switch

        OFF or ON

        OFF: Engine started

        ON: Engine not started

        *4

        Turn Signal Switch (Right)

        RH turn signal switch

        OFF or ON

        OFF: RH turn signal switch off

        ON: RH turn signal switch on

        -

        Turn Signal Switch (Left)

        LH turn signal switch

        OFF or ON

        OFF: LH turn signal switch off

        ON: LH turn signal switch on

        -

        Hazard Flasher Switch

        Hazard warning switch

        OFF or ON

        OFF: Hazard warning switch off

        ON: Hazard warning switch on

        -

        Key Remind Sound

        Cycle of the key reminder warning buzzer

        Normal, Slow, Fast

        Normal, Slow, Fast

        Displays customize setting of key remind sound

        Driver Side Seatbelt Warning Buzzer

        Condition of the driver seat belt warning buzzer

        OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        Displays customize setting of driver side seat belt warning buzzer

        P-Seatbelt Warning Buzzer

        Condition of the front passenger seat belt warning buzzer

        OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        Displays customize setting of front passenger side seat belt warning buzzer

        Rear Seatbelt Warning Buzzer

        Condition of the rear seat belt warning buzzer

        OFF or ON

        OFF: Rear seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        ON: Rear seat belt warning displayed buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        Displays customize setting of rear seat belt warning buzzer*3

        Units By Region

        Unit of the cruise information display

        Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g

        Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g

        Displays customize setting of units by region*5

        ECO Drive Indicator Zone

        Condition of the eco driving indicator zone

        OFF or ON

        OFF: Eco driving indicator zone not displayed

        ON: Eco driving indicator zone displayed

        Displays customize setting of ECO drive indicator zone*6

        ODO Display Time After IG OFF Setting

        Condition of the ODO display time after the ignition switch is turned off

        30s, 60s, 600s, OFF

        30s, 60s, 600s, OFF

        Displays customize setting of ODO display time after IG off setting

        Lane Change Flashing Times Setting

        Condition of the lane change flashing times

        OFF, 3, 5, 7

        OFF, 3, 5, 7

        Displays customize setting of lane change flashing times setting

        Number of Trouble Code

        The number of the DTCs currently stored

        Min.: 0, Max.: 255

        0

        -

        • *1: for Diesel

        • *2: for Multi-information display (Dot LCD type)

        • *3: w/ Rear seat belt warning

        • *4: for Gasoline

        • *5: for Multi-information display (Segment LCD type)

        • *6: for CVT

        • *7: w/ Washer fluid level warning

      2. ABS/VSC/TRC

        Chassis > ABS/VSC/TRC > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Vehicle Speed

        Maximum wheel speed sensor reading

        Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)

        Vehicle stopped: 0 km/h (0 mph)

        When driving at constant speed: No large fluctuations

      3. Engine and ECT (for Gasoline)

        Powertrain > Engine and ECT > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Reference Value

        Diagnostic Note

        Engine Speed

        Engine speed

        Min.: 0 rpm, Max.: 16383 rpm

        1NR-FE, 2ZR-FE, 1ZR-FE:

        600 to 700 rpm: Idling

        1ZR-FAE:

        • 600 to 700 rpm: Idling (for CVT)

        • 580 to 680 rpm: Idling (for Manual transaxle)

        1NR-FE, 2ZR-FE, 1ZR-FE:

        -

        1ZR-FAE:

        Idling (engine warmed up and A/C off): 650 rpm

        • Stored as freeze frame data: Yes

        • When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed.

        Coolant Temp

        Coolant temperature

        Min.: -40°C (-40°F), Max.: 140°C (284°F)

        75 to 100°C (167 to 212°F): After warming up engine

        -

        • Stored as freeze frame data: Yes

        • This is the engine coolant temperature.

        Tip:

        • After warming up the engine, the engine coolant temperature is 75 to 100°C (167 to 212°F).

        • After a long soak, the engine coolant temperature, intake air temperature and ambient temperature are approximately equal.

        • If the value is -40°C (-40°F), or 140°C (284°F), the sensor circuit is open or shorted.

        • Check if the engine overheats when the value indicates 140°C (284°F).

      4. Engine and ECT (for Diesel)

        Powertrain > Engine and ECT > Data List

        Tester Display

        Measurement Item

        Type

        Range

        Normal Condition

        Reference Value

        Diagnostic Note

        Engine Speed

        Engine speed

        Sensor output (crankshaft position sensor)

        Min.: 0 rpm, Max.: 16383 rpm

        1AD-FTV:

        • 50 to 400 rpm: Cranking

        • 720 to 820 rpm: Idling with warmed up engine

        1ND-TV:

        Idling: 720 to 820 rpm

        1AD-FTV:

        -

        1ND-TV:

        Idling ("Coolant Temp" is 75°C (167°F)): 770 rpm

        When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 or varies greatly from the actual engine speed.

        Cause of out of range:

        • Crankshaft position sensor

        • Crankshaft position sensor circuit

        Coolant Temp

        Engine coolant temperature

        Sensor output (engine coolant temperature sensor)

        Min.: -40°C, Max.: 140°C

        1AD-FTV:

        After warming up engine: 60 to 90°C (140 to 194°F)

        1ND-TV:

        After warming up engine: 75 to 100°C (167 to 212°F)

        1AD-FTV:

        -

        1ND-TV:

        After warming up engine: 75°C (167°F)

        • 1AD-FTV: If the value is -40°C (-40°F) or 140°C (284°F), the sensor circuit is open or shorted.

        • 1ND-TV: If the value is 30°C (-22°F) or less or 120°C (248°F) or more, the sensor circuit is open or shorted.

        • After a long soak, the coolant temperature, intake air temperature and ambient temperature are approximately equal.

        Cause of out of range:

        • Engine coolant temperature sensor

        • Thermostat

        Symptoms when out of range:

        Difficult to start when engine is cold, rough idle, black smoke, lack of power

      5. Main Body

        Body Electrical > Main Body > Data List

        Tester Display

        Measurement Item

        Range

        Normal Condition

        Diagnostic Note

        Illumination Rate Info

        Illumination rate information

        0.00 ms. to 2162.65 ms.

        Value output according to ambient light levels

        -

  2. ACTIVE TEST

    Tip:

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the GTS on.

    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    5. Check the operation by referring to the table below.

      Body Electrical > Combination Meter > Active Test

      Tester Display

      Measurement Item

      Control Range

      Diagnostic Note

      Speed Meter Operation

      Speedometer

      • OFF, 0, 40, 80, 120, 160, 200, 240 km/h*15

      • OFF, 0, 40, 80, 120, 160 mph*16

      -

      TachoMeter Operation

      Tachometer

      OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000*1, 7000*1

      -

      Fuel Meter Operation

      Fuel receiver gauge

      OFF, Empty, 1/2, Full

      -

      Water Temperature Meter Operation

      Engine coolant temperature receiver gauge

      OFF, Low, Normal, High

      *2

      A/T Indicator Operation 1

      Shift indicator

      OFF, L, 2, 3(M), 4(M), D, N, R, P

      -

      A/T Indicator Operation 2

      Shift indicator

      OFF, 5, 6, 7, Es, M, S, B

      -

      A/T Indicator Operation 3

      Shift indicator

      OFF, D

      -

      Indicat. Lamp Airbag

      SRS warning light

      OFF or ON

      -

      Indicat. Lamp Doors All Open

      Door open warning light

      OFF or ON

      *4

      Front Passenger Side Seat Belt

      Driver or front passenger seat belt warning light

      OFF or ON

      -

      Driver Side Seat Belt

      Driver or front passenger seat belt warning light

      OFF or ON

      -

      Indicat. Lamp ABS

      ABS warning light

      OFF or ON

      *4

      Indicat. Lamp Charge

      Charge warning light

      OFF or ON

      *4

      Indicat. Lamp Slip

      Slip indicator light

      OFF or ON

      *3

      Indicat. Lamp Coolant Hot

      Engine coolant temperature hot warning light

      OFF or ON

      *4

      Indicat GLOW

      Glow warning light

      OFF or ON

      *5

      Indicat. AFS

      AFS OFF warning light

      OFF or ON

      *6

      Indicat. Lamp Fuel

      Fuel level warning light

      OFF or ON

      -

      VSC TRC Indicator

      TRC OFF warning light

      OFF or ON

      *3

      Indicat. Tire Pressure Warning System

      Tire pressure warning light

      OFF or ON

      *18

      Indicat. Oil Pressure

      Engine oil pressure warning light

      OFF or ON

      *4

      Indicat. Lamp Water Level

      Fuel sedimenter warning light

      OFF or ON

      *4, *5

      Indicat. ECONO

      Eco driving indicator light

      OFF or ON

      *4, *8

      Indicat. Lamp Cruise

      Cruise main indicator light (Green)

      OFF or ON

      *4, *9

      Indicat. Lamp Oil Level

      Engine oil level warning light

      OFF or ON

      *4, *5

      Indicat. Lamp Brake

      Brake warning light

      OFF or ON

      -

      Indicat. EPS

      EPS warning light

      OFF or ON

      -

      Indicat. Over Speed

      Speed warning light

      OFF or ON

      *4, *17

      Maintenance Indicator

      Oil maintenance warning light

      OFF or ON

      *4, *5

      Indicat. MMT E Mode

      Multi-mode manual transaxle warning light

      OFF or ON

      *10

      Master Warning

      Master warning light

      OFF or ON

      *2

      Indicat. SET

      Cruise SET indicator light

      OFF or ON

      *4, *9

      Indicat. SIL (Up)

      Shift up indicator light

      OFF or ON

      *4, *11

      Indicat. SIL (Down)

      Shift down indicator light

      OFF or ON

      *4, *11

      Indicat. ASL

      Adjustable speed limiter indicator light (Green)

      OFF or ON

      *4, *12

      Indicat. Sport(CVT Sport)

      Sport indicator light

      OFF or ON

      *8

      Indicat. VSC OFF

      VSC OFF indicator light

      OFF or ON

      *3

      Rear Seat Belt

      Rear seat belt indicator light

      OFF or ON

      *13

      Automatic High Beam Indicator

      Automatic high beam indicator light (Green)

      OFF or ON

      *14

      Cruise Indicator

      Cruise main indicator light (Amber)

      OFF or ON

      *4, *9

      Turn Signal (Left) Indicator

      LH turn indicator light

      OFF or ON

      -

      Turn Signal (Right) Indicator

      RH turn indicator light

      OFF or ON

      -

      Smart System Indicator

      Smart key warning light (Green)

      OFF or ON

      *1, *4

      Smart System Warning

      Smart key warning light (Amber)

      OFF or ON

      *1, *4

      ASL Warning Indicator

      Adjustable speed limiter indicator light (Amber)

      OFF or ON

      *12

      Automatic High Beam Indicator

      Automatic high beam indicator light (Amber)

      OFF or ON

      *14

      Diesel Particulate Filter Warning

      DPF warning light

      OFF or ON

      *4, *5

      Stop and Start ON Indicator

      Stop and start indicator light

      OFF or ON

      *4, *7

      Stop and Start OFF Indicator

      Stop and start off warning light

      OFF or ON

      *4, *7

      Water Temperature Meter Operation

      Engine coolant temperature receiver gauge

      OFF, LOW, NORMAL, HIGH

      *4

      Meter Display 1

      Multi-information display

      • Multi-information display (Dot LCD type):

        OFF, All

      • Multi-information display (Segment LCD type):

        OFF, 6, 5, 4, 3, 2, 1, 0, All

      -

      Meter Display 2

      Multi-information display (Segment LCD type)

      OFF, 9, 8, 7

      *4

      • *1: w/ Entry and start system

      • *2: for Multi-information display (Dot LCD type)

      • *3: w/ VSC

      • *4: for Multi-information display (Segment LCD type)

      • *5: for Diesel

      • *6: w/ AFS (Adaptive Front-lighting System)

      • *7: w/ Stop and start system

      • *8: for CVT

      • *9: w/ Cruise control system

      • *10: for Multi-mode manual transaxle

      • *11: for Manual transaxle or multi-mode manual transaxle

      • *12: w/ Speed limiter system

      • *13: w/ Rear seat belt warning

      • *14: w/ Automatic high beam system

      • *15: for Speedometer with Metric units

      • *16: for Speedometer with Imperial units

      • *17: w/ Speed warning

      • *18: w/ Tire pressure warning system