AIR CONDITIONING SYSTEM(for Manual Air Conditioning System) PRECAUTION

  1. PRECAUTION FOR DISCONNECTING CABLE FROM NEGATIVE BATTERY TERMINAL

    Note:

    When disconnecting the cable from the negative (-) battery terminal, initialize the following system after the cable is reconnected.

    System Name

    See Procedure

    Simple Intelligent Parking Assist System

    Click hereClick hereClick hereClick hereClick here

    Stop and Start System

  2. IGNITION SWITCH EXPRESSIONS

    1. The type of ignition switch used on this model differs according to the specifications of the vehicle. The expressions listed in the table below are used in this section.

      Expression

      Ignition Switch (Position)

      Engine Switch (Condition)

      Ignition Switch off

      LOCK

      Off (Lock)

      Ignition Switch ACC

      ACC

      On (ACC)

      Ignition Switch ON

      ON

      On (IG)

      Engine Start

      START

      On (Start)

  3. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME

    E268519C03

    *a

    Charging Cylinder

  4. ALWAYS WEAR EYE PROTECTION

  5. BE CAREFUL NOT TO GET LIQUID REFRIGERANT IN YOUR EYES OR ON YOUR SKIN

    E268520

    If liquid refrigerant gets in your eyes or on your skin.

    1. Wash the area with lots of cold water.

      CAUTION:

      Do not rub your eyes or skin.

    2. Apply clean petroleum jelly to the skin.

    3. Go immediately to a hospital or see a physician for professional treatment.

  6. NEVER HEAT CONTAINER OR EXPOSE CONTAINER TO AN OPEN FLAME

  7. BE CAREFUL NOT TO DROP CONTAINER OR APPLY PHYSICAL SHOCKS TO IT

  8. DO NOT OPERATE COMPRESSOR WITHOUT ENOUGH REFRIGERANT IN REFRIGERANT SYSTEM

    If there is not enough refrigerant in the A/C system, oil lubrication will be insufficient and the compressor may be damaged.

    Necessary care should be taken to avoid this.

  9. DO NOT OPEN HIGH PRESSURE MANIFOLD VALVE WHILE COMPRESSOR IS OPERATING

    E268521C03

    *a

    Wrong

    *b

    Okay

    1. Open and close only the low pressure valve.

      If the high pressure valve is opened, refrigerant flows in the reverse direction causing the charging cylinder to rupture.

  10. BE CAREFUL NOT TO OVERCHARGE SYSTEM WITH REFRIGERANT

    If the system is overcharged with refrigerant, it causes problems such as insufficient cooling, poor fuel economy, engine overheating, etc.

  11. DO NOT OPERATE ENGINE AND COMPRESSOR WITH NO REFRIGERANT

    CAUTION:

    Doing so may damage the inside of the compressor because the compressor parts always move regardless of whether the A/C system is turned on or off.

  12. SUPPLEMENTAL RESTRAINT SYSTEM (SRS)

    1. This vehicle is equipped with a Supplemental Restraint System (SRS) such as the driver, front passenger, side, and curtain shield airbags. Failure to carry out service operations in the correct sequence could cause the SRS to unexpectedly deploy during servicing, possibly leading to a serious accident. Before servicing (including removal or installation of parts, inspection or replacement), be sure to read the precautionary notices.

      Click here

  13. GENERAL PRECAUTION

    1. While using the battery during inspection, do not bring the positive (+) and negative (-) tester probes too close to each other as a short circuit may occur.