AFS (ADAPTIVE FRONT-LIGHTING SYSTEM), Diagnostic DTC:B2412,B2413,B2417 and B2418

DTC Code DTC Name
B2412 Headlight Swivel Motor LH Malfunction
B2413 Headlight Swivel Motor RH Malfunction
B2417 Headlight Beam Level Control Motor LH Malfunction
B2418 Headlight Beam Level Control Motor RH Malfunction

DESCRIPTION

Each swivel motor receives operation signals from the AFS ECU (headlight swivel ECU assembly) and sends signals indicating the direction of the headlight and condition of the headlight swivel motor to the AFS ECU (headlight swivel ECU assembly).

DTC No.

Detection Item

DTC Detection Condition

Trouble Area

B2412

Headlight Swivel Motor LH Malfunction

  • Malfunction in headlight swivel motor LH

  • Open or short in headlight swivel motor LH circuit

  • Headlight unit LH (Headlight swivel motor LH)

  • Harness or connector

  • AFS ECU (headlight swivel ECU assembly)

B2413

Headlight Swivel Motor RH Malfunction

  • Malfunction in headlight swivel motor RH

  • Open or short in headlight swivel motor RH circuit

  • Headlight unit RH (Headlight swivel motor RH)

  • Harness or connector

  • AFS ECU (headlight swivel ECU assembly)

B2417

Headlight Beam Level Control Motor LH Malfunction

  • Malfunction in headlight swivel motor LH

  • Open or short in headlight swivel motor LH circuit

  • Headlight unit LH (Headlight swivel motor LH)

  • Harness or connector

  • AFS ECU (headlight swivel ECU assembly)

B2418

Headlight Beam Level Control Motor RH Malfunction

  • Malfunction in headlight swivel motor RH

  • Open or short in headlight swivel motor RH circuit

  • Headlight unit RH (Headlight swivel motor RH)

  • Harness or connector

  • AFS ECU (headlight swivel ECU assembly)

WIRING DIAGRAM

E261802E03

CAUTION / NOTICE / HINT

Note:

If the AFS ECU (headlight swivel ECU assembly) has been replaced, it is necessary to synchronize the vehicle information and initialize the AFS ECU (headlight swivel ECU assembly).

Click here

PROCEDURE

  1. CHECK FOR DTC

    1. Clear the DTCs.

      Click here

      Body Electrical > AFS > Clear DTCs

    2. Check for DTCs.

      Click here

      Body Electrical > AFS > Trouble Codes

      OK

      DTC B2412, B2413, B2417 and B2418 are not output.

    Result

    Result

    Proceed to

    None of the following DTCs are not output.

    • B2412

    • B2413

    • B2417

    • B2418

    A

    Any of the following DTCs are output.

    • B2412

    • B2413

    • B2417

    • B2418

    B

    Both of the following DTCs are output.

    • B2412

    • B2417

    C

    Both of the following DTCs are output.

    • B2413

    • B2418
    A

    USE SIMULATION METHOD TO CHECK

    Click hereClick hereClick here

    C

    CHECK HARNESS AND CONNECTOR (AFS ECU (HEADLIGHT SWIVEL ECU ASSEMBLY) - HEADLIGHT UNIT)Click here

    B

  2. CHECK HEADLIGHT UNIT (HEADLIGHT SWIVEL MOTOR)

    1. Replace the headlight unit with a new or known good one.

      Click here

    2. Check for DTCs.

      Click here

      Body Electrical > AFS > Trouble Codes

      OK

      DTC B2412, B2413, B2417 and B2418 are not output.

    Result

    Proceed to

    OK

    NG
    OK

    END (HEADLIGHT SWIVEL MOTOR WAS DEFECTIVE)

    NG

    REPLACE AFS ECU (HEADLIGHT SWIVEL ECU ASSEMBLY)

    Click here

  3. CHECK HARNESS AND CONNECTOR (AFS ECU (HEADLIGHT SWIVEL ECU ASSEMBLY) - HEADLIGHT UNIT)

    1. Disconnect the A93 AFS ECU (headlight swivel ECU assembly) connector.

    2. Disconnect the A90 headlight unit LH connector and A123 headlight unit RH connector.

    3. Measure the resistance according to the value(s) in the table below.

      Standard Resistance

      LH Side (B2412 and B2417)

      Tester Connection

      Condition

      Specified Condition

      A93-1 (SMBL) - A90-10 (LHB1)

      Always

      Below 1 Ω

      A93-27 (LL1-) - A90-5 (LH E)

      Always

      Below 1 Ω

      A93-1 (SMBL) - Body ground

      Always

      10 kΩ or higher

      A93-27 (LL1-) - Body ground

      Always

      10 kΩ or higher

      Standard Resistance

      RH Side (B2413 and B2418)

      Tester Connection

      Condition

      Specified Condition

      A93-2 (SMBR) - A123-10 (RHB1)

      Always

      Below 1 Ω

      A93-28 (LR1-) - A123-5 (RH E)

      Always

      Below 1 Ω

      A93-2 (SMBR) - Body ground

      Always

      10 kΩ or higher

      A93-28 (LR1-) - Body ground

      Always

      10 kΩ or higher

    Result

    Proceed to

    OK

    NG
    NG

    REPAIR OR REPLACE HARNESS OR CONNECTOR

    OK

  4. CHECK HEADLIGHT UNIT (HEADLIGHT SWIVEL MOTOR)

    1. Replace the headlight unit with a new or known good one.

      Click here

    2. Check for DTCs.

      Click here

      Body Electrical > AFS > Trouble Codes

      OK

      DTC B2412, B2413, B2417 and B2418 are not output.

    Result

    Proceed to

    OK

    NG
    OK

    END (HEADLIGHT SWIVEL MOTOR WAS DEFECTIVE)

    NG

    REPLACE AFS ECU (HEADLIGHT SWIVEL ECU ASSEMBLY)

    Click here