WORK NOTICES AND PRECAUTIONS PRECAUTIONS FOR SRS AIRBAG SYSTEM


  1. HANDLING OF A VEHICLE THAT HAS BEEN DAMAGED IN A COLLISION


    1. Refer to the TOYOTA Repair Manual for the SRS airbag system inspection procedures.

    2. If impacts are likely to occur to the front airbag sensors, door side airbag sensors, rear airbag sensors or center airbag sensor assembly remove each sensor as necessary beforehand.

    3. Do not allow the front airbag sensors, door side airbag sensors, rear airbag sensors or center airbag sensor assembly to become heated to high temperatures.

    4. Check the wire harnesses and connectors for damage and/or melting, as some areas of the airbags and seat belt pretensioners may heat up to several hundred degrees when they operate.

  2. PRECAUTIONS FOR USING ELECTRIC WELDER


    1. Check the Diagnostic Trouble Codes (DTCs).


      1. If one or more DTCs are displayed:


        • Disconnect the negative (-) terminal cable from the battery.

        • Disconnect all the malfunctioning circuit connectors.

        • Disconnect the center airbag sensor assembly connector.

      2. If DTCs are NOT displayed:


        • Inspect for damage to the electric wiring harnesses and connectors.

        • Disconnect the negative (-) terminal cable from the battery.

        • Disconnect the center airbag sensor assembly connector.

  3. PARTS LOCATION (w/ Occupant Classification System)

    A00YIKTE02
    *1 FRONT SEAT OUTER BELT ASSEMBLY LH *2 FRONT AIRBAG SENSOR RH
    *3 DOOR SIDE AIRBAG SENSOR LH *4 DOOR SIDE AIRBAG SENSOR RH
    *5 REAR AIRBAG SENSOR LH *6 REAR AIRBAG SENSOR RH
    *7 FRONT SEAT AIRBAG ASSEMBLY LH *8 FRONT SEAT AIRBAG ASSEMBLY RH
    *9 CURTAIN SHIELD AIRBAG ASSEMBLY LH *10 CURTAIN SHIELD AIRBAG ASSEMBLY RH
    *11 FRONT AIRBAG SENSOR LH *12 FRONT SEAT OUTER BELT ASSEMBLY RH
    *13 NO. 1 ENGINE ROOM RELAY BLOCK AND JUNCTION BLOCK ASSEMBLY *14 ECU-B NO.1 FUSE
    *15 ECU-B NO.2 FUSE *16 ECM
    A00YIJBE01
    *1 FRONT SEAT INNER BELT ASSEMBLY LH *2 TELLTALE LIGHT ASSEMBLY
    *3 INSTRUMENT PANEL PASSENGER AIRBAG ASSEMBLY *4 FRONT SEAT AIRBAG SUB-ASSEMBLY
    *5 OCCUPANT DETECTION SENSOR *6 AIRBAG SENSOR ASSEMBLY
    *7 COMBINATION METER ASSEMBLY *8 SEAT POSITION AIRBAG SENSOR
    *9 HORN BUTTON ASSEMBLY *10 SPIRAL WITH SENSOR CABLE SUB-ASSEMBLY
    *11 LOWER NO. 1 INSTRUMENT PANEL AIRBAG ASSEMBLY *12 DLC3
    *13 INSTRUMENT PANEL JUNCTION BLOCK ASSEMBLY *14 MAIN BODY ECU (MULTIPLEX NETWORK BODY ECU)
    *15 METER FUSE *16 A/B FUSE
    *a SRS WARNING LIGHT *b PASSENGER AIRBAG ON/OFF INDICATOR

  4. PARTS LOCATION (w/o Occupant Classification System)

    A00YIKTE01
    *A w/ Side Airbag *B w/ Curtain Shield Airbag Assembly
    *1 FRONT SEAT OUTER BELT ASSEMBLY LH *2 FRONT AIRBAG SENSOR RH
    *3 DOOR SIDE AIRBAG SENSOR LH *4 DOOR SIDE AIRBAG SENSOR RH
    *5 REAR AIRBAG SENSOR LH *6 REAR AIRBAG SENSOR RH
    *7 FRONT SEAT AIRBAG ASSEMBLY LH *8 FRONT SEAT AIRBAG ASSEMBLY RH
    *9 CURTAIN SHIELD AIRBAG ASSEMBLY LH *10 CURTAIN SHIELD AIRBAG ASSEMBLY RH
    *11 FRONT SEAT OUTER BELT ASSEMBLY LH *12 FRONT SEAT OUTER BELT ASSEMBLY RH
    *13 NO. 1 ENGINE ROOM RELAY BLOCK AND JUNCTION BLOCK ASSEMBLY *14 ECU-B NO.1 FUSE
    *15 ECU-B NO.2 FUSE *16 ECM
    A00YIL8E01
    *A for LHD *B w/ Airbag Cutoff Switch
    *C w/ Lower No. 1 Instrument Panel Airbag Assembly - -
    *1 CENTER AIRBAG SENSOR ASSEMBLY *2 HORN BUTTON ASSEMBLY
    *3 SPIRAL WITH SENSOR CABLE SUB-ASSEMBLY *4 INSTRUMENT PANEL PASSENGER AIRBAG ASSEMBLY
    *5 LOWER NO. 1 INSTRUMENT PANEL AIRBAG ASSEMBLY *6 COMBINATION METER ASSEMBLY
    *7 TELLTALE LIGHT ASSEMBLY *8 INSTRUMENT PANEL JUNCTION BLOCK ASSEMBLY
    *9 METER FUSE *10 A/B FUSE
    *11 DLC3 *12 AIRBAG CUTOFF SWITCH CYLINDER SUB-ASSEMBLY
    *13 MAIN BODY ECU (MULTIPLEX NETWORK BODY ECU) *a SRS WARNING LIGHT
    *b PASSENGER AIRBAG ON/OFF INDICATOR - -
    A00YIJFE01
    *A for RHD *B w/ Airbag Cutoff Switch
    *C w/ Lower No. 1 Instrument Panel Airbag Assembly - -
    *1 CENTER AIRBAG SENSOR ASSEMBLY *2 HORN BUTTON ASSEMBLY
    *3 SPIRAL WITH SENSOR CABLE SUB-ASSEMBLY *4 INSTRUMENT PANEL PASSENGER AIRBAG ASSEMBLY
    *5 LOWER NO. 1 INSTRUMENT PANEL AIRBAG ASSEMBLY *6 COMBINATION METER ASSEMBLY
    *7 TELLTALE LIGHT ASSEMBLY *8 INSTRUMENT PANEL JUNCTION BLOCK ASSEMBLY
    *9 METER FUSE *10 A/B FUSE
    *11 DLC3 *12 AIRBAG CUTOFF SWITCH CYLINDER SUB-ASSEMBLY
    *13 MAIN BODY ECU (MULTIPLEX NETWORK BODY ECU) *a SRS WARNING LIGHT
    *b PASSENGER AIRBAG ON/OFF INDICATOR - -