SFI SYSTEM, Diagnostic DTC:P0116

DTC Code DTC Name
P0116 Engine Coolant Temperature Circuit Range / Performance Problem

DESCRIPTION

Refer to DTC P0115 Click here.

DTC No. DTC Detection Condition Trouble Area
P0116

When either of following conditions met (2 trip detection logic):


  • During engine warming up after cold engine start, change in Engine Coolant Temperature (ECT) sensor output below threshold

  • In duration between warmed engine stopped and next cold engine start, change in ECT sensor output below threshold

  • Thermostat (Water inlet)


  • Engine coolant temperature sensor

INSPECTION PROCEDURE

Tech Tips


  • If any of DTCs P0115, P0117 or P0118 are set simultaneously with DTC P0116, the engine coolant temperature sensor may have an open or a short circuit. Troubleshoot those DTCs first.


  • Read freeze frame data using an intelligent tester. The ECM records vehicle and driving condition information as freeze frame data the moment a DTC is stored. When troubleshooting, freeze frame data can help determine if the vehicle was moving or stationary, if the engine was warmed up or not, if the air-fuel ratio was lean or rich, and other data from the time the malfunction occurred.

PROCEDURE


  1. CHECK ANY OTHER DTCS OUTPUT (IN ADDITION TO DTC P0116)


    1. Connect an intelligent tester to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the tester on.

    4. Enter the following menus: Powertrain / Engine and ECT / DTC.

    5. Read DTCs.

      Result
      Result Proceed to
      P0116 A
      P0116 and other DTCs B

      Tech Tips

      If any DTCs other than P0116 are output, troubleshoot those DTCs first.


    B

    GO TO DTC CHART Click here

    A

  2. INSPECT THERMOSTAT


    1. Remove the thermostat Click here.

    2. Measure the valve opening temperature of the thermostat.

      Standard temperature
      80°C to 84°C (176°F to 183°F)

      Tech Tips

      In addition to the above check, confirm that the valve is completely closed when the temperature is below the standard.

    3. Reinstall the thermostat Click here.


    NG

    REPLACE THERMOSTAT Click here

    OK

    REPLACE ENGINE COOLANT TEMPERATURE SENSOR Click here