VEHICLE STABILITY CONTROL SYSTEM DATA LIST / ACTIVE TEST


  1. DATA LIST

    Tech Tips

    Using the intelligent tester to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    Note

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.


    1. Turn the ignition switch off.

    2. Connect the intelligent tester to the DLC3.

    3. Turn the ignition switch to ON.

    4. Turn the intelligent tester on.

    5. Enter the following menus: Chassis / ABS/VSC/TRC / Data List.

    6. According to the display on the tester, read the Data List.

      ABS/VSC/TRC
      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      ABS Warning Light ABS warning light/ ON or OFF

      ON: Warning light on

      OFF: Warning light off

      		 -
      VSC Warning Light VSC warning indicator (multi-information display)/ ON or OFF

      ON: Warning indicator on

      OFF: Warning indicator off

      		 -
      Brake Warning Light Brake system warning light (red indicator)/ ON or OFF

      ON: Warning light on

      OFF: Warning light off

      		 -
      Slip Indicator Light Slip indicator light/ ON or OFF

      ON: Indicator light on

      OFF: Indicator light off

      		 -
      Buzzer Skid control buzzer/ ON or OFF

      ON: Buzzer on

      OFF: Buzzer off

      		 -
      Stop Light SW Stop light switch/ ON or OFF

      ON: Brake pedal depressed

      OFF: Brake pedal released

      		 -
      Parking Brake SW Parking brake switch/ ON or OFF

      ON: Parking brake applied

      OFF: Parking brake released

      		 -
      Gear Position Gear position information/ FAIL, 1st-8th, P,N, R or NOT R Actual gear position -
      Shift Lever Position Shift lever position information/ FAIL, 1st-6th/B, D/M, P,N, or R Actual shift lever position -
      Shift Information Shift information/ ON or OFF

      ON: During gear change

      OFF: Not during gear change

      		 -
      Inspection Mode Inspection mode/ OTHER or INSPECT

      OTHER: Normal mode

      INSPECT: Inspection mode

      		 -
      Number of IG ON (Inspection) Number of times ignition switch turned to ON after entering inspection mode/ min.: 0, max.: 255 - -
      Pre Crash Brake OFF Switch*

      Pre-crash brake cancel switch/

      ON or OFF

      ON: Pre-crash brake cancel switch on

      OFF: Pre-crash brake cancel switch off

      		 -
      Master Cylinder Sensor Master cylinder pressure sensor reading/ min.: 0 V, max.: 5 V Brake pedal released: 0.3 to 0.9 V Reading increases when brake pedal is depressed
      Deceleration Sensor

      Acceleration sensor reading/ min.: -18.52 m/s2, max.: 18.39 m/s2

      		During deceleration/acceleration: Changes continuously -
      Deceleration Sensor2

      Acceleration sensor 2 reading/ min.: -18.52 m/s2, max.: 18.39 m/s2

      		During deceleration/acceleration: Changes continuously -
      Yaw Rate Sensor Yaw rate sensor/ min.: -128 deg/s, max.: 127 deg/s

      Vehicle stopped: 0 deg/s

      Turning right: -128 to 0 deg/s

      Turning left: 0 to 127 deg/s

      		 -
      Steering Angle Sensor Steering angle sensor/ min.: -3276.8 deg, max.: 3276.7 deg

      Left turn: Increases

      Right turn: Decreases

      		 -
      Zero Point of Steering Angle Memorized zero value/ min.: -3276.8 deg, max.: 3276.7 deg After steering angle sensor zero point calibration: 0 deg -
      Lateral G

      Lateral acceleration/ min.: -25.11 m/s2, max.: 24.91 m/s2

      		During Turning: Charges in proportion to acceleration -
      Forward and Rearward G

      Forward and backward acceleration/ min.: -25.11 m/s2, max.: 24.91 m/s2

      		During acceleration/deceleration: Charges in proportion to acceleration -
      Yaw Rate Value Yaw rate value/ min.: -128 deg/s, max.: 127 deg/s During Turning: Charges in proportion to yaw -
      Steering Angle Value Steering angle value/ min.: -3276.8 deg, max.: 3276.7 deg During steering operation: Charges in proportion to steering wheel rotation -
      Stop Light Relay Stop light control relay/ ON or OFF

      ON: Brake pedal depressed

      OFF: Brake pedal released

      		 -
      Brakelamp System Indicator Light Brake light system warning indicator (multi-information display)/ ON or OFF

      ON: Brake light system warning indicator on

      OFF: Brake light system warning indicator off

      		 -
      FR Wheel Speed Front speed sensor RH reading/ min.: 0 km/h (0 mph), max.: 326.4 km/h (202 mph) Actual wheel speed Driving at constant speed: No large fluctuations
      FL Wheel Speed Front speed sensor LH reading/ min.: 0 km/h (0 mph), max.: 326.4 km/h (202 mph) Actual wheel speed Driving at constant speed: No large fluctuations
      RR Wheel Speed Rear speed sensor RH reading/ min.: 0 km/h (0 mph), max.: 326.4 km/h (202 mph) Actual wheel speed Driving at constant speed: No large fluctuations
      RL Wheel Speed Rear speed sensor LH reading/ min.: 0 km/h (0 mph), max.: 326.4 km/h (202 mph) Actual wheel speed Driving at constant speed: No large fluctuations
      Vehicle Speed Maximum speed sensor reading/ min.: 0 km/h (0 mph), max.: 326.4 km/h (202 mph) Actual vehicle speed Driving at constant speed: No large fluctuations
      FR Wheel Acceleration

      Front wheel RH acceleration/ min.: -200.84 m/s2, max.: 199.27 m/s2

      		During deceleration/acceleration: Changes continuously -
      FL Wheel Acceleration

      Front wheel LH acceleration/ min.: -200.84 m/s2, max.: 199.27 m/s2

      		During deceleration/acceleration: Changes continuously -
      RR Wheel Acceleration

      Rear wheel RH acceleration/ min.: -200.84 m/s2, max.: 199.27 m/s2

      		During deceleration/acceleration: Changes continuously -
      RL Wheel Acceleration

      Rear wheel LH acceleration/ min.: -200.84 m/s2, max.: 199.27 m/s2

      		During deceleration/acceleration: Changes continuously -
      Stop Light Relay Output* Stop light control relay output/ ON or OFF

      ON: Relay output on

      OFF: Relay output off

      		 -
      EBS Relay Emergency stop light signal/ ON or OFF

      ON: Emergency stop light signal output

      OFF: Emergency stop light signal not output

      		 -
      FR Wheel ABS Ctrl Status Front wheel RH ABS control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      FL Wheel ABS Ctrl Status Front wheel LH ABS control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RR Wheel ABS Ctrl Status Rear wheel RH ABS control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RL Wheel ABS Ctrl Status Rear wheel LH ABS control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      FR Wheel EBD Ctrl Status Front wheel RH EBD control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      FL Wheel EBD Ctrl Status Front wheel LH EBD control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RR Wheel EBD Ctrl Status Rear wheel RH EBD control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RL Wheel EBD Ctrl Status Rear wheel LH EBD control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      BA Ctrl Status BA control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      PBA Ctrl Status* Pre-crash brake assist control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      TRC (TRAC) Ctrl Status TRC control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      TRC (TRAC) Engine Ctrl Status TRC engine control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      TRC (TRAC) Brake Ctrl Status TRC brake control status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      FR Wheel VSC Ctrl Status Front wheel RH VSC status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      FL Wheel VSC Ctrl Status Front wheel LH VSC status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RR Wheel VSC Ctrl Status Rear wheel RH VSC status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      RL Wheel VSC Ctrl Status Rear wheel LH VSC status/ ON or OFF

      ON: During control

      OFF: Not during control

      		 -
      Engine Revolutions Engine speed/ min.: 0 r/min, max.: 65535 r/min Actual engine speed -
      Real Engine Torque Actual engine torque/ min.: -1024 Nm, max.: 1023 Nm - -
      Accelerator Opening Angle % Throttle valve opening amount/ min.: 0%, max.: 128% During acceleration pedal operation: Changes in proportion to pedal movement -
      Solenoid Relay Solenoid relay/ ON or OFF

      ON: Solenoid relay on

      OFF: Solenoid relay off

      		 -
      Electronically Controlled Brake Motor Relay Motor relay/ ON or OFF

      ON: Motor relay on

      OFF: Motor relay off

      		 -
      TR(A)C/VSC Solenoid (SRM2) Master cut solenoid (SRM2)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      TR(A)C/VSC Solenoid (SRM1) Master cut solenoid (SRM1)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      TR(A)C/VSC Solenoid (SRC2) Master cut solenoid (SRC2)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      TR(A)C/VSC Solenoid (SRC1) Master cut solenoid (SRC1)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SFRH) ABS solenoid (SFRH)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SFRR) ABS solenoid (SFRR)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SFLH) ABS solenoid (SFLH)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SFLR) ABS solenoid (SFLR)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SRRH) ABS solenoid (SRRH)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SRRR) ABS solenoid (SRRR)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SRLH) ABS solenoid (SRLH)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      ABS Solenoid (SRLR) ABS solenoid (SRLR)/ ON or OFF

      ON: Operating

      OFF: Not operating

      		 -
      EFI Communication Open EFI communication open detection/ ERROR or NORMAL NORMAL -
      Yaw Rate Open Yaw rate sensor open detection/ ERROR or NORMAL NORMAL -
      Deceleration Open Acceleration sensor open detection/ ERROR or NORMAL NORMAL -
      Steering Open Steering angle sensor open detection/ ERROR or NORMAL NORMAL -
      TRC/VSC Off Mode TRC/VSC off mode/ NORMAL, TRC OFF or VSC OFF

      NORMAL: Normal mode

      TRC OFF: TRC OFF mode

      VSC OFF: VSC OFF mode

      		 -
      Number of DTC Number of DTCs stored/ min.: 0, max.: 255 - -
      IG Voltage Value Decreased IG voltage value decrease detection/ ERROR or NORMAL NORMAL -
      FR Speed Sensor Voltage Open Front speed sensor RH voltage open detection/ ERROR or NORMAL NORMAL -
      FL Speed Sensor Voltage Open Front speed sensor LH voltage open detection/ ERROR or NORMAL NORMAL -
      RR Speed Sensor Voltage Open Rear speed sensor RH voltage open detection/ ERROR or NORMAL NORMAL -
      RL Speed Sensor Voltage Open Rear speed sensor LH voltage open detection/ ERROR or NORMAL NORMAL -

      *: w/ Pre-crash Safety System

  2. ACTIVE TEST

    Tech Tips

    Using the intelligent tester to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Turn the ignition switch off.

    2. Connect the intelligent tester to the DLC3.

    3. Turn the ignition switch to ON.

    4. Turn the intelligent tester on.

    5. Enter the following menus: Chassis / ABS/VSC/TRC / Active Test.

    6. According to the display on the tester, perform the Active Test.

      ABS/VSC/TRC
      Tester Display Test Part Control Range Diagnostic Note
      ABS Warning Light ABS warning light Warning light ON / OFF Observe combination meter.
      VSC Warning Light VSC warning indicator (multi-information display) Warning indicator ON / OFF Observe combination meter.
      Brake Warning Light Brake system warning light (red indicator) Warning light ON / OFF Observe combination meter.
      Slip Indicator Light Slip indicator light Indicator light ON / OFF Observe combination meter.
      Buzzer Skid control buzzer Buzzer ON / OFF Buzzer can be heard.
      Motor Relay Motor relay Relay ON / OFF Operating sound of motor relay can be heard.
      Stop Light Relay* Stop light control relay Relay ON / OFF Observe stop light.
      ABS Solenoid (SRLR) Solenoid (SRLR) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SRLH) Solenoid (SRLH) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SRRR) Solenoid (SRRR) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SRRH) Solenoid (SRRH) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SFLR) Solenoid (SFLR) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SFLH) Solenoid (SFLH) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SFRR) Solenoid (SFRR) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      ABS Solenoid (SFRH) Solenoid (SFRH) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      VSC/TRC Solenoid (SRMR) Master cut solenoid (SRM2) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      VSC/TRC Solenoid (SRMF) Master cut solenoid (SRM1) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      VSC/TRC Solenoid (SRCR) Master cut solenoid (SRC2) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      VSC/TRC Solenoid (SRCF) Master cut solenoid (SRC1) Solenoid ON / OFF Operating sound of solenoid (clicking sound) can be heard.
      EBS Relay Emergency stop light ON / OFF Observe stop light.
      Brakelamp System Indicator Light Brake light system indicator (multi-information display) ON / OFF Observe combination meter.

      *: w/ Pre-crash Safety System