METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST
-
DATA LIST
Using the intelligent tester to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
Note
In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.
-
Warm up the engine.
-
Turn the ignition switch to off.
-
Connect the intelligent tester to the DLC3.
-
Turn the ignition switch to ON.
-
Turn the tester on.
-
Enter the following menus:
-
for Combination Meter: Body Electrical / Combination Meter / Data List.
-
for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.
-
for Engine and ECT: Powertrain / Engine and ECT / Data List.
-
for D-SEAT SW: Body Electrical / D-SEAT SW / Data List.
-
-
Check the values by referring to the table below.
Combination Meter Tester Display Measurement Item/Range Normal Condition Diagnostic Note ODO/TRIP Change SW ODO/TRIP switch/OFF or ON OFF: Switch released - ON: Switch pushed - Tail Cancel SW*1, *6 Tail Cancel switch/OFF or ON OFF: Tail Cancel switch off - ON: Tail Cancel switch on P-Seatbelt Buckle SW Front passenger side seat belt buckle switch/OFF or ON OFF: Front passenger side seat belt unfastened - ON: Front passenger side seat belt fastened Reverse Range Switch (6MT)*2 Reverse Range switch/OFF or ON OFF: Reverse Range switch off - ON: Reverse Range switch on Oil Level SW*3, *4 Oil level switch/OFF or ON OFF: Engine oil level low - ON: Engine oil level except above Water Level SW*3, *5 Level warning switch/OFF or ON OFF: Water level switch off - ON: Water level switch on Oil Pressure Switch Oil pressure switch/OFF or ON OFF: Engine oil pressure low - ON: Engine oil pressure except above +B Voltage Value Battery voltage/Min.: 0 V, Max.: 25.5 V 11 to 14 V - Vehicle Speed Meter Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost the same as actual vehicle speed (Speedometer tester) - Engine Rpm Engine speed/Min.: 0 rpm, Max.: 12750 rpm 650 to 750 rpm (When idling) - Coolant Temperature Engine coolant temperature/0 to 127.5°C (0 to 261.5°F) After warming up: 80 to 95°C (176 to 203°F) - Fuel Input Fuel input signal/Min.: 0, Max. 127.5 Current fuel level displayed Unit: Liter Sub Fuel Input*8 Fuel input signal/Min.: 0, Max. 127.5 Current fuel level displayed Unit: Liter Integrated value for Timing belt*3, *5 T-belt indicator integrated value/Min.: 0, Max.: 6553500 0 to 6553500 - Ambient Temperature Outside temperature/Min.: -40°C, Max.: 87.5°C Almost the same as actual outside temperature The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F) Rheostat value Light control rheostat switch input/Min.: 0, Max.: 100 Light control rheostat switch is fully turned right (0) → fully turned left (100) Unit: % Units By Region*9, *10 Unit of display setting/Km/l JP, Km/l, Ml/g US or Ml/g UK Displays unit setting - Language*9, *10 Eng US / Eng UK / French / German / Spanish / Italian / Japanes / CHN Sim / CHN Trd / Russian Displays language setting - Driver Side Seatbelt Warning Buzzer The condition of the driver side seat belt warning buzzer/OFF or ON ON: The driver side seat belt warning buzzer sounds at the vehicle speed of 20 km/h (12 mph) or more when the driver side seat belt unfastened The customized setting of the driver side seat belt warning buzzer displayed OFF: The driver side seat belt warning buzzer does not sound at the vehicle speed of 20 km/h (12 mph) or more when the driver side seat belt unfastened P-Seatbelt Warning Buzzer The condition of the front passenger side seat belt warning buzzer/OFF or ON ON: The front passenger side seat belt warning buzzer sounds at the vehicle speed of 20 km/h (12 mph) or more when the front passenger side seat belt unfastened The customized setting of the front passenger side seat belt warning buzzer displayed OFF: The front passenger side seat belt warning buzzer does not sound at the vehicle speed of 20 km/h (12 mph) or more when the front passenger side seat belt unfastened ECO Drive Indicator Light*7 Condition of eco driving indicator light/OFF or ON OFF: Eco driving indicator light is off Check also the customized setting of the eco driving indicator light. ON: Eco driving indicator light comes on according to driving conditions ECO Drive Indicator*7 The condition of the Eco driving indicator zone in the multi-information display/OFF or ON OFF: Eco driving indicator zone display in the multi-information display is off. Check also the customized setting of the eco driving indicator zone display. OFF: Eco driving indicator zone display in the multi-information display is on. Number of Trouble Code The number of the DTC which is currently output 0 -
-
*1: w/ TAIL Cancel Switch
-
*2: for Manual Transmission
-
*3: for 1KD-FTV
-
*4: for Europe, 1GR-FE
-
*5: for 5L-E
-
*6: for Double Tank Type
-
*7: for Automatic Transmission
-
*8: for Sub Tank Type
-
*9: for Analog Meter
-
*10: except 5L-E
ABS/VSC/TRC Tester Display Measurement Item/Range Normal Condition Diagnostic Note FR Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed (Speedometer tester) - FL Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed (Speedometer tester) - RR Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed (Speedometer tester) - RL Wheel Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed (Speedometer tester) - Vehicle Speed Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost the same as actual vehicle speed (Speedometer tester) - Engine and ECT Tester Display Measurement Item/Range Normal Condition Diagnostic Note Engine Speed Vehicle speed/Min.: 0 rpm, Max.: 16383 rpm 650 to 750 rpm (When idling with warm up engine)*1 - 600 to 700 rpm (When idling with warm up engine)*2 610 to 710 rpm (When idling with warm up engine)*3, *4 650 to 750 rpm (When idling with warm up engine)*3, *5 720 to 820 rpm (When idling with warm up engine)*6 Coolant Temp Engine coolant temperature/Min.: -40°C (-40°F), Max: 140°C (284°F) 80 to 100°C (176 to 212°F): After warming up
-
If -40°C (-40°F): sensor circuit open
-
If 140°C (284°F) or more: sensor circuit shorted
-
*1: for 1GR-FE
-
*2: for 2TR-FE
-
*3: for 1KD-FTV
-
*4: for Manual Transmission
-
*5: for Automatic Transmission
-
*6: for 5L-E
D-SEAT SW (w/ Multi-function Switch) Tester Display Measurement Item/Range Normal Condition Diagnostic Note Steering Wheel Menu Switch MENU switch/OFF or ON OFF: MENU switch off - ON: MENU switch on - Steering Wheel Enter Switch ENTER switch/OFF or ON OFF: ENTER switch off - ON: ENTER switch on - Steering Wheel Up Switch UP/DOWN UP switch/OFF or ON OFF: UP/DOWN UP switch off - ON: UP/DOWN UP switch on Steering Wheel Down Switch UP/DOWN DOWN switch/OFF or ON OFF: UP/DOWN DOWN switch off - ON: UP/DOWN DOWN switch on -
-
-
ACTIVE TEST
Using the intelligent tester to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.
-
Connect the intelligent tester to the DLC3.
-
Turn the ignition switch to on.
-
Turn the tester on.
-
Enter the following menus: Body Electrical / Combination Meter / Active Test.
-
Check the operation by referring to the table below.
Combination Meter Tester Display Test Part Control Range Diagnostic Note Speed Meter Operation Speedometer 0, 40, 80, 120*1 (mph) Confirm that the vehicle is stopped with the engine idling. 0, 40, 80, 120, 160, 200*1 (km/h) Tacho Meter Operation Tachometer 0, 1000, 2000, 3000, 4000, 5000, 6000, 7000*1, *2 (rpm) Confirm that the vehicle is stopped with the engine idling. Fuel Meter Operation Fuel receiver gauge EMPTY, EMPTY, INDIC, 1/4, 1/2, 3/4, FULL, FULL Confirm that the vehicle is stopped with the engine idling. A/T Indicator Operation 1*3 A/T shift indicator light (D, P, N. R, 4, 3, 2, L) P, R, N, D, 4 (M/S)*8, *21, 3 (M/S), 2, L Confirm that the vehicle is stopped with the engine idling. A/T Indicator Operation 2*3, *8, *21 A/T gear range indicator light (S, 6, 5) 5, 6, Es Confirm that the vehicle is stopped with the engine idling. Meter Display 1*22 Multi-information display ALL, 0, 1, 2, 3, 4, 5 or 6 Confirm that the vehicle is stopped with the engine idling. Meter Display 2*22 Multi-information display 7, 8 or 9 Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Beam High beam indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Tail Tail indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Fr FOG*4 Front fog indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Rr FOG*5 Rear fog indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Airbag SRS warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Precrash*6 Pre-crash warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Driver Side Seat Belt Driver side seat belt warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Front Passenger Side Seat Belt Front passenger side seat belt warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Doors All Open Door indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. AFS*7 AFS OFF indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Fuel Fuel level warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Charge Charge warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp ABS ABS warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Slip*1 Slip indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. VSC TRC Indicator*1, *22 VSC TRC indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Brake Brake warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Oil Pressure Oil pressure warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Oil Level*8, *22, *23 Oil level warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. GLOW*8, *9 GLOW indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Water Level*9, *22, *24 Water level warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. ECONO*3 Eco driving indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. A/T OIL Temperature Operation*3, *22 A/T oil temperature warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Lamp Cruise*10 Cruise main indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. KEY*11, *22 Key Warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Oil Maintenance*8, *12, *22 Oil Maintenance indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Timing Belt*8, *9, *22 Timing belt interval indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Over Speed*13 Over speed warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Master Warning*25 Master warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Clearance Sonar*14 Clearance sonar indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Downhill Assist Control*15 Downhill assist control indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. 2nd START*3 2nd START indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Ctr DIFF LOCK Center differential lock indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. Rr DIFF LOCK Rear differential lock indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. 4LO 4LO indicator light ON or OFF Confirm that the vehicle is stopped with the engine idling. Indicat. CRAWL*16 CRAWL indicator light ON or OFF Confirm that the vehicle is stopped with the engine idling. Indicat. SIL (Up)*8, *12, *17 SIL (Up) indicator light ON or OFF Confirm that the vehicle is stopped with the engine idling. Indicat. SIL (Down)*8, *12, *17 SIL (Down) indicator light ON or OFF Confirm that the vehicle is stopped with the engine idling. Indicat. SET*10 SET indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. VSC OFF*1 VSC OFF indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Fuel Filter Indicator*8, *18, *22 Fuel filter indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. KDSS Indicator*19 Kinetic dynamic suspension system indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Multi-terrain Select Indicator*20 Multi-terrain select indicator light OFF or ON Confirm that the vehicle is stopped with the engine idling. Indicat. PPS*1 PPS warning light OFF or ON Confirm that the vehicle is stopped with the engine idling. Water Temperature Meter Operation Engine coolant temperature receiver gauge LOW, 60, 70, 80, Normal, 110, 120, HIGH Confirm that the vehicle is stopped with the engine idling.
-
*1: except 5L-E
-
*2: except 1KD-FTV
-
*3: for Automatic Transmission
-
*4: w/ Front Fog Light
-
*5: w/ Rear Fog Light
-
*6: w/ Pre-crash Safety System
-
*7: w/ AFS
-
*8: for 1KD-FTV
-
*9: for 5L-E
-
*10: w/ Cruise Control
-
*11: w/ Entry and Start System
-
*12: for Europe
-
*13: for Middle East
-
*14: w/ TOYOTA Parking Assist-sensor System
-
*15: w/ Downhill Assist Control
-
*16: w/ Crawl Control
-
*17: for Manual Transmission
-
*18: except Europe
-
*19: w/ Kinetic Dynamic Suspension System
-
*20: w/ Multi Function Switch
-
*21: for 1GR-FE
-
*22: for Analog Meter
-
*23: for Europe, 1GR-FE
-
*24: for Europe, 1KD-FTV
-
*25: for Optitron Meter
-
-