3ZR-FAE ENGINE CONTROL SERVICE DATA

SPARK PLUG
Standard Insulation Resistance Spark plug (terminal part) - Body ground 10 MΩ or higher
Spark Plug Type DENSO made SC16HR11
Maximum Electrode Gap for Used Spark Plug 1.3 mm (0.0512 in.)
Standard Electrode Gap for New Spark Plug 1.0 to 1.1 mm (0.0394 to 0.0433 in.)
CAMSHAFT TIMING OIL CONTROL VALVE
Standard Resistance 20°C (68°F) 6.9 to 7.9 Ω
CONTINUOUSLY VARIABLE VALVE LIFT CONTROLLER
Standard Protrusion Length - 34.57 to 34.73 mm (1.36 to 1.37 in.)
THROTTLE BODY
Standard Throttle Valve Opening Percentage Shift lever in N 60% or higher
Standard Resistance 1 (M-) - 2 (M+) 20°C (68°F) 0.3 to 100 Ω
ACCELERATOR PEDAL SENSOR ASSEMBLY
Standard Voltage (Accele Sensor Out No. 1) Accelerator pedal is fully released 0.5 to 1.1 V
Accelerator pedal is fully depressed 2.6 to 4.5 V
Standard Voltage (Accele Sensor Out No. 2) Accelerator pedal is fully released 1.2 to 2.0 V
Accelerator pedal is fully depressed 3.4 to 4.75 V
MASS AIR FLOW METER
MAF Idling 4.0 to 7.0 gm/sec
2000 rpm 12.0 to 16.0 gm/sec
3000 rpm 17.0 to 23.0 gm/sec
Standard Resistance 4 (THA) - 2 (E2G) -20°C (-4°F) 13.6 to 18.4 kΩ
20°C (68°F) 2.21 to 2.69 kΩ
60°C (140°F) 0.49 to 0.67 kΩ
CRANKSHAFT POSITION SENSOR
Standard Resistance

Cold

(-10 to 50°C (14 to 122°F))

 1630 to 2740 Ω

Hot

(50 to 100°C (122 to 212°F))

 2065 to 3225 Ω
ENGINE COOLANT TEMPERATURE SENSOR
Standard Resistance 20°C (68°F) 2.32 to 2.59 kΩ
80°C (176°F) 0.310 to 0.326 kΩ
ENGINE OIL TEMPERATURE SENSOR
Standard Resistance 30°C (86°F) 2.647 to 3.021 kΩ
KNOCK SENSOR
Standard Resistance 25°C (77°F) 120 to 280 kΩ
VACUUM SENSOR ASSEMBLY (MANIFOLD ABSOLUTE PRESSURE SENSOR)
Standard Voltage C2-3 (VC) - C2-1 (E2) Ignition switch ON 4.75 to 5.25 V
C2-2 (PIM) - C2-1 (E2) Ignition switch ON 3.0 to 5.25 V
Intake Manifold Pressure Vacuum of 67 kPa(abs) [503 mmHg(abs)] applied to vacuum sensor assembly (manifold absolute pressure sensor) 23 to 38 kPa(abs) [173 to 285 mmHg(abs)]
AIR FUEL RATIO SENSOR
Standard Resistance 1 (HA1A) - 2 (+B) 20°C (68°F) 1.6 to 3.2 Ω
1 (HA1A) - 4 (A1A-) Always 10 kΩ or higher
HEATED OXYGEN SENSOR
Standard Resistance 1 (HT1B) - 2 (+B) 20°C (68°F) 5 to 10 Ω
1 (HT1B) - 4 (E2) Always 10 kΩ or higher