Click here

METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST

Click here
Click here
Click here

  1. DATA LIST

    Note:

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    Tip:

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.


    1. Turn the ignition switch off.

    2. Connect the GTS to the DLC3.

    3. Turn the ignition switch to ON.

    4. Turn the GTS on.

    5. Enter the following menus:


      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for Engine and ECT: Powertrain / Engine / Data List.

    6. Check the values by referring to the table below.


      1. Combination Meter.


        1. Body Electrical > Combination Meter > Data List
          Tester Display Measurement Item Normal Condition Reference Value Diagnostic Note
          Tail Relay SW Tail relay OFF or ON

          OFF: Headlight dimmer switch in neither tail nor head position

          ON: Headlight dimmer switch in tail or head position

          		 -
          ODO/TRIP Change SW Trip switch OFF or ON

          OFF: Trip switch released

          ON: Trip switch pushed

          		 -
          P-Seatbelt Buckle SW Front passenger side seat belt buckle switch OFF or ON

          OFF: Front passenger side seat belt fastened

          ON: Front passenger side seat belt unfastened

          		 Perform the inspection while sitting in the front passenger side seat.
          Vehicle Speed Meter Vehicle speed Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed -
          Engine Rpm Engine speed Min.: 0 rpm, Max.: 12750 rpm Actual engine speed -
          Coolant Temperature Engine coolant temperature Min.: 0°C (0°F), Max.: 127.5°C (261.5°F) 75 to 100°C (167 to 212°F): After warming up the engine -
          Washer Switch Level warning switch assembly OFF or ON

          OFF: Washer fluid level not low

          ON: Washer fluid level low

          		 w/ Washer Fluid Level Warning System
          Reverse Range Switch (6MT) Shift position R OFF or ON

          OFF: Shift position except R

          ON: Shift position R

          		 for Manual transmission system (RC60/RC61)
          Oil Level SW Engine oil level sensor OFF or ON

          OFF: Engine oil level not low

          ON: Engine oil level low

          		 for 1GD-FTV, 2GD-FTV
          Water Level SW Level warning switch OFF or ON

          OFF: Level warning switch off

          ON: Level warning switch on

          		 for Diesel Engine
          Multi Display Select Switch Steering pad switch (DISP) OFF or ON

          OFF: Steering pad switch (DISP) released

          ON: Steering pad switch (DISP) pushed

          		 for Dot Display Type
          +B Voltage Value Battery voltage Min.: 0 V, Max.: 25.5 V 11 to 14 V -
          Integrated value for Maintenance Oil maintenance indicator integrated value Min.: 0 mile, Max.: 25500 mile 0 to 25500 mile for 1GD-FTV, 2GD-FTV
          Fuel Input Fuel input Min.: 0, Max. 127.5 Current fuel level displayed Unit: Liter
          Integrated value for Timing belt T-belt indicator integrated value Min.: 0 km, Max.: 6553500 km 0 to 6553500 km for 2KD-FTV, 5L-E
          Ambient Temperature Outside temperature Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) Almost the same as actual outside temperature for Automatic Air Conditioning System
          Multi Switch (Up) Steering pad switch (Up) OFF or ON

          OFF: Steering pad switch (Up) released

          ON: Steering pad switch (Up) pushed

          		 for TFT Display Type
          Multi Switch (Down) Steering pad switch (Down) OFF or ON

          OFF: Steering pad switch (Down) released

          ON: Steering pad switch (Down) pushed

          		 for TFT Display Type
          Multi Switch (Menu) Steering pad switch (Top) OFF or ON

          OFF: Steering pad switch (Top) released

          ON: Steering pad switch (Top) pushed

          		 for TFT Display Type
          Multi Switch (Enter) Steering pad switch (Enter) OFF or ON

          OFF: Steering pad switch (Enter) released

          ON: Steering pad switch (Enter) pushed

          		 for TFT Display Type
          Multi Switch (Right) Steering pad switch (Right) OFF or ON

          OFF: Steering pad switch (Right) released

          ON: Steering pad switch (Right) pushed

          		 for TFT Display Type
          Multi Switch (Left) Steering pad switch (Left) OFF or ON

          OFF: Steering pad switch (Left) released

          ON: Steering pad switch (Left) pushed

          		 for TFT Display Type
          2nd-Row Seatbelt Buckle (R) Buckle switch (rear RH side) OFF or ON

          OFF: Tongue plate (for Rear RH side) not inserted

          ON: Tongue plate (for Rear RH side) inserted

          		 w/ Rear Seat Belt Warning System
          2nd-Row Seatbelt Buckle (L) Buckle switch (rear LH side) OFF or ON

          OFF: Tongue plate (for Rear LH side) not inserted

          ON: Tongue plate (for Rear LH side) inserted

          		 w/ Rear Seat Belt Warning System
          2nd-Row Seatbelt Buckle (C) Buckle switch (rear center side) OFF or ON

          OFF: Tongue plate (for Rear center) not inserted

          ON: Tongue plate (for Rear center) inserted

          		 w/ Rear Seat Belt Warning System
          Oil Pressure Switch Engine oil pressure switch OFF or ON

          OFF: Engine oil pressure not low

          ON: Engine oil pressure low

          		 -
          Fuel Filter Switch Fuel filter assembly (clogging switch) OFF or ON

          OFF: Fuel filter assembly (clogging switch) off

          ON: Fuel filter assembly (clogging switch) on

          		 for KD Series Engine, 5L-E
          Turn Signal Switch (Right) Turn signal switch (right) OFF or ON

          OFF: Turn signal switch (right) off

          ON: Turn signal switch (right) on

          		 -
          Turn Signal Switch (Left) Turn signal switch (left) OFF or ON

          OFF: Turn signal switch (left) off

          ON: Turn signal switch (left) on

          		 -
          Hazard Flasher Switch Hazard warning switch OFF or ON

          OFF: Hazard warning switch off

          ON: Hazard warning switch on

          		 -
          Driver Side Seatbelt Buckle Switch Driver side seat belt buckle switch OFF or ON

          OFF: Driver side seat belt fastened

          ON: Driver side seat belt unfastened

          		 -
          Parking Brake Switch Parking brake switch assembly OFF or ON

          OFF: Parking brake switch assembly off

          ON: Parking brake switch assembly on

          		 -
          Driver Side Door Driver side door CLOSE or OPEN

          CLOSE: Driver side door close

          OPEN: Driver side door open

          		 -
          Passenger Side Door Front passenger side door CLOSE or OPEN

          CLOSE: Front passenger side door close

          OPEN: Front passenger side door open

          		 -
          Rear Left Side Door Rear left side door CLOSE or OPEN

          CLOSE: Rear left side door close

          OPEN: Rear left side door open

          		 except Single Cab
          Rear Right Side Door Rear right side door CLOSE or OPEN

          CLOSE: Rear right side door close

          OPEN: Rear right side door open

          		 except Single Cab
          Turn Switch Signal (Full Turn) Turn signal switch status OFF or ON

          OFF: Turn signal switch off

          ON: Turn signal switch on (Full Turn)

          		 Displays for both right and left turns.
          Multi Switch (Back) Steering pad switch (Back) OFF or ON

          OFF: Steering pad switch (Back) released

          ON: Steering pad switch (Back) pushed

          		 except Segment Display Type
          Key Insert Unlock warning switch OFF or ON

          OFF: No key in ignition key cylinder

          ON: Key inserted

          		 w/o Entry and Start System
          Key Remind Sound Condition of the key reminder sound adjustment Normal, Slow, Fast Customized value displayed w/o Entry and Start System
          Key Remind Volume Condition of the key reminder volume adjustment Large, Medium, Small Customized value displayed w/o Entry and Start System
          Driver Side Seatbelt Warning Buzzer Driver seat belt warning buzzer OFF or ON Customized value displayed -
          P-Seatbelt Warning Buzzer Front passenger seat belt warning buzzer OFF or ON Customized value displayed -
          Rear Seatbelt Warning Buzzer Rear seat belt warning buzzer OFF or ON Customized value displayed w/ Rear Seat Belt Warning System
          ECO Drive Indicator Zone Condition of the eco drive indicator zone OFF or ON Customized value displayed except Segment Display Type
          ODO Display Time After IG OFF Setting Condition of the ODO display time after the ignition switch is turned off 30s, 60s, 600s, OFF Customized value displayed -
          Lane Change Flashing Times Setting Condition of the lane change flashing times setting OFF, 3, 4, 5, 6, 7 Customized value displayed -
          Flasher Sound Volume Adjustment Condition of the flasher sound volume adjustment Small, Medium, Large Customized value displayed -
          LDA System Existence of function With/Without

          With: w/ Lane Departure Alert System

          Without: w/o Lane Departure Alert System

          		 -
          VSC System Existence of function With/Without

          With: w/ Vehicle Stability Control System

          Without: w/o Vehicle Stability Control System

          		 -
          PCS System Existence of function With/Without

          With: w/ Pre-collision System

          Without: w/o Pre-collision System

          		 -
          Flasher Sound Tone Setting Condition of the flasher sound tone adjustment OFF, 3, 4, 5, 6, 7 Customized setting displayed -
          Number of Trouble Code The number of the DTC currently stored Min.: 0, Max.: 255 0 -






















































      2. ABS/VSC/TRC


        1. Chassis > ABS/VSC/TRC > Data List
          Tester Display Measurement Item Range Normal Condition Diagnostic Note
          Vehicle Speed Vehicle speed Min.: 0 km/h (0 mph), Max.: 326 km/h (203 mph) Almost same as actual vehicle speed -


      3. Engine


        1. Powertrain > Engine > Data List
          Tester Display Measurement Item Normal Condition Reference Value Diagnostic Note
          Engine Speed Engine speed Min.: 0 rpm, Max.: 16383.75 rpm Actual engine speed -
          Coolant Temp Engine coolant temperature Min.: -40°C (-40°F), Max: 215°C (419°F) 75 to 100°C (167 to 212°F): After warming up the engine -



  2. ACTIVE TEST

    Tip:

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    4. Check the operation by referring to the table below.


      1. Body Electrical > Combination Meter > Active Test
        Tester Display Measurement Item Control Range Diagnostic Note
        Speed Meter Operation Speedometer

        • OFF, 0, 40, 80, 120, 160 or 200 (km/h) (for km/h)

        • OFF, 0, 40, 80 or 100 (mph) (for mph)

        There is a deviation in the values displayed on the speedometer display (Control range → Speedometer)


        • for km/h (Type A)

        • 40 → 41.7 to 46.2

        • 80 → 83.4 to 88.4

        • 120 → 125.1 to 130.6

        • 160 → 166.2 to 173.2

        • 180 → 186.9 to 194.5


        • for km/h (Type B)

        • 40 → 41.4 to 45.9

        • 80 → 82.7 to 87.7

        • 120 → 124.1 to 129.1

        • 160 → 165.4 to 170.4


        • for km/h (Type C)

        • 40 → 41.0 to 45.5

        • 80 → 82 to 87

        • 120 → 123.1 to 128.1

        • 160 → 164.1 to 169.1


        • for km/h (Type D)

        • 40 → 40.5 to 45

        • 80 → 81 to 86

        • 120 → 121.4 to 126.4

        • 160 → 161.9 to 166.9


        • for km/h (Type E)

        • 40 → 40.6 to 45.1

        • 80 → 81.3 to 86.3

        • 120 → 121.9 to 126.9

        • 160 → 162.5 to 167.5


        • for mph

        • 40 → 42 to 44.5

        • 80 → 83.1 to 87.1
        TachoMeter Operation Tachometer

        • for 1TR-FE:

          OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000 or 7000 (rpm)

        • for 2TR-FE, 1GR-FE:

          OFF, 0, 1000, 2000, 3000, 4000, 5000 or 6000 (rpm)

        • for Diesel Engine:

          OFF, 0, 1000, 2000, 3000, 4000 or 5000 (rpm)

        		 -
        Fuel Meter Operation Fuel receiver gauge OFF, Sender, Empty, Warning, 1/4, 1/2, 3/4, Full or Sender F -
        A/T Indicator Operation 1 Shift indicator OFF, L, 2, 3, 4, D, N, R or P for Automatic Transmission
        A/T Indicator Operation 2 Shift indicator OFF, 5, 6 or S for Automatic Transmission
        A/T Indicator Operation 3 Shift indicator OFF or D for Automatic Transmission
        Indicat. Lamp Airbag SRS warning light OFF or ON w/ Airbag System
        Indicat. Lamp Doors All Open Open door indicator light OFF or ON -
        Driver Side Seat Belt Seat belt warning light OFF or ON -
        Indicat. Lamp ABS ABS warning light OFF or ON -
        Indicat. Lamp Charge Charge system warning light OFF or ON -
        Indicat. Lamp Slip Slip indicator light OFF or ON w/ VSC
        Indicat GLOW GLOW indicator light OFF or ON for Diesel Engine
        Indicat. Lamp Beam High beam indicator light OFF or ON -
        Indicat. Lamp Tail Tail indicator light OFF or ON -
        Indicat. Lamp Fr FOG Front fog indicator light OFF or ON w/ Front Fog Light
        Indicat. Precrash PCS indicator light OFF or ON w/ Pre-collision System
        Indicat. Headlamp Auto Leveling Headlight leveling indicator light OFF or ON for LED Headlight
        Indicat. Lamp Fuel Fuel level warning light OFF or ON -
        VSC TRC Indicator TRC OFF warning light OFF or ON w/ VSC
        Indicat. Tire Pressure Warning System Tire pressure warning light OFF or ON w/ Tire Pressure Warning System
        Indicat. Oil Pressure Low engine oil pressure warning light OFF or ON -
        Indicat. ECONO Eco driving indicator light OFF or ON w/ ECO MODE Indicator Light
        Indicat. Lamp ECT PWR POWER MODE indicator light OFF or ON w/ ECO MODE Indicator Light
        A/T Oil Temperature Operation A/T OIL TEMP warning light OFF or ON for 4WD, Automatic Transmission
        Indicat. 4WD (Yellow) Four-wheel drive indicator light (Yellow) OFF or ON for 4WD
        Indicat. Lamp Cruise Cruise indicator light (Green) OFF or ON w/ Cruise Control System
        Indicat. Lamp Oil Level Low engine oil level warning light OFF or ON for 1GD-FTV, 2GD-FTV
        Indicat. Lamp Brake Brake warning light OFF or ON -
        Indicat. Over Speed Speed warning light OFF or ON for Middle East
        Indicat. Timing Belt T-BELT indicator light OFF or ON for KD Series Engine, 5L-E
        Master Warning Master warning light OFF or ON except Segment Display Type
        Indicat. Downhill Assist Control Downhill assist control indicator light OFF or ON w/ Downhill Assist Control
        Indicat. Park Parking brake warning light OFF or ON -
        Indicat. Rr DIFF LOCK Rear differential lock indicator light OFF or ON for 4WD
        Indicat. 4LO Low speed four-wheel drive indicator light OFF or ON for 4WD
        Indicat. SET SET indicator light OFF or ON w/ Cruise Control System
        Indicat. VSC OFF VSC OFF warning light OFF or ON w/ VSC
        Indicat. ECO MODE ECO MODE indicator light OFF or ON w/ ECO MODE Indicator Light
        Fuel Filter Indicator Fuel system warning light OFF or ON for Diesel Engine
        Cruise Indicator Cruise indicator light (Yellow) OFF or ON w/ Cruise Control System
        Turn Signal (Left) Indicator Turn indicator light (LH) OFF or ON -
        Turn Signal (Right) Indicator Turn indicator light (RH) OFF or ON -
        Smart System Indicator Entry and Start System indicator light OFF or ON w/ Entry and Start System
        Smart System Warning Entry and Start System indicator light OFF or ON w/ Entry and Start System
        4WD Indicator (Green) Four-wheel drive indicator light (Green) OFF or ON for 4WD
        Check Engine Indicator MIL (Malfunction indicator lamp) OFF or ON -
        Diesel Particulate Filter Warning DPF system warning light OFF or ON w/ DPF
        LDA Control Indicator LDA indicator light OFF or ON w/ Lane Departure Alert System
        Brake Override Indicator Brake override system warning light OFF or ON -
        Go to Service Warning Go to service warning light OFF or ON for Segment Display Type
        Reductant Warning Indicator Urea SCR indicator light OFF or ON w/ Urea SCR System
        iMT Indicator (Green) iMT indicator light OFF or ON for Intelligent Manual Transmission
        iMT Indicator (Yellow) iMT indicator light OFF or ON for Intelligent Manual Transmission
        Water Temperature Meter Operation Engine coolant temperature receiver gauge OFF, LOW, NORMAL or HIGH -
        Meter Display 1 Multi-information display OFF or All -
        Meter Display 2 Multi-information display OFF, 9, 8 or 7 -