METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST


  1. DATA LIST

    Note

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

    Tech Tips

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.


    1. Turn the ignition switch off.

    2. Connect the GTS to the DLC3.

    3. Turn the ignition switch to ON.

    4. Turn the GTS on.

    5. Enter the following menus:


      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for Engine and ECT: Powertrain / Engine / Data List.

    6. Check the values by referring to the table below.


      1. Combination Meter.


        Body Electrical > Combination Meter > Data List
        Tester Display Measurement Item Normal Condition Reference Value Diagnostic Note
        Tail Relay SW Tail relay OFF or ON

        OFF: Headlight dimmer switch in neither tail nor head position

        ON: Headlight dimmer switch in tail or head position

        		 -
        ODO/TRIP Change SW Trip switch OFF or ON

        OFF: Trip switch released

        ON: Trip switch pushed

        		 -
        P-Seatbelt Buckle SW Front passenger side seat belt buckle switch OFF or ON

        OFF: Front passenger side seat belt fastened

        ON: Front passenger side seat belt unfastened

        		 Perform the inspection while sitting in the front passenger side seat.
        Vehicle Speed Meter Vehicle speed Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed -
        Engine Rpm Engine speed Min.: 0 rpm, Max.: 12750 rpm Actual engine speed -
        Coolant Temperature Engine coolant temperature Min.: 0°C (0°F), Max.: 127.5°C (261.5°F) 75 to 100°C (167 to 212°F): After warming up the engine -
        Washer Switch Level warning switch assembly OFF or ON

        OFF: Washer fluid level not low

        ON: Washer fluid level low

        		 w/ Washer Fluid Level Warning System
        Reverse Range Switch (6MT) Shift position R OFF or ON

        OFF: Shift position except R

        ON: Shift position R

        		 for Manual transmission system (RC60/RC61)
        Oil Level SW Engine oil level sensor OFF or ON

        OFF: Engine oil level not low

        ON: Engine oil level low

        		 for 1GD-FTV, 2GD-FTV
        Water Level SW Level warning switch OFF or ON

        OFF: Level warning switch off

        ON: Level warning switch on

        		 for Diesel Engine
        Multi Display Select Switch Steering pad switch (DISP) OFF or ON

        OFF: Steering pad switch (DISP) released

        ON: Steering pad switch (DISP) pushed

        		 for Dot Display Type
        +B Voltage Value Battery voltage Min.: 0 V, Max.: 25.5 V 11 to 14 V -
        Integrated value for Maintenance Oil maintenance indicator integrated value Min.: 0 mile, Max.: 25500 mile 0 to 25500 mile for 1GD-FTV, 2GD-FTV
        Fuel Input Fuel input Min.: 0, Max. 127.5 Current fuel level displayed Unit: Liter
        Integrated value for Timing belt T-belt indicator integrated value Min.: 0 km, Max.: 6553500 km 0 to 6553500 km for 1KD-FTV, 2KD-FTV, 5L-E
        Ambient Temperature Outside temperature Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) Almost the same as actual outside temperature for Automatic Air Conditioning System
        Multi Switch (Up) Steering pad switch (Up) OFF or ON

        OFF: Steering pad switch (Up) released

        ON: Steering pad switch (Up) pushed

        		 for TFT Display Type
        Multi Switch (Down) Steering pad switch (Down) OFF or ON

        OFF: Steering pad switch (Down) released

        ON: Steering pad switch (Down) pushed

        		 for TFT Display Type
        Multi Switch (Menu) Steering pad switch (Top) OFF or ON

        OFF: Steering pad switch (Top) released

        ON: Steering pad switch (Top) pushed

        		 for TFT Display Type
        Multi Switch (Enter) Steering pad switch (Enter) OFF or ON

        OFF: Steering pad switch (Enter) released

        ON: Steering pad switch (Enter) pushed

        		 for TFT Display Type
        Multi Switch (Right) Steering pad switch (Right) OFF or ON

        OFF: Steering pad switch (Right) released

        ON: Steering pad switch (Right) pushed

        		 for TFT Display Type
        Multi Switch (Left) Steering pad switch (Left) OFF or ON

        OFF: Steering pad switch (Left) released

        ON: Steering pad switch (Left) pushed

        		 for TFT Display Type
        2nd-Row Seatbelt Buckle (R) Buckle switch (rear RH side) OFF or ON

        OFF: Tongue plate (for Rear RH side) not inserted

        ON: Tongue plate (for Rear RH side) inserted

        		 w/ Rear Seat Belt Warning System
        2nd-Row Seatbelt Buckle (L) Buckle switch (rear LH side) OFF or ON

        OFF: Tongue plate (for Rear LH side) not inserted

        ON: Tongue plate (for Rear LH side) inserted

        		 w/ Rear Seat Belt Warning System
        2nd-Row Seatbelt Buckle (C) Buckle switch (rear center side) OFF or ON

        OFF: Tongue plate (for Rear center) not inserted

        ON: Tongue plate (for Rear center) inserted

        		 w/ Rear Seat Belt Warning System
        Oil Pressure Switch Engine oil pressure switch OFF or ON

        OFF: Engine oil pressure not low

        ON: Engine oil pressure low

        		 -
        Fuel Filter Switch Fuel filter assembly (clogging switch) OFF or ON

        OFF: Fuel filter assembly (clogging switch) off

        ON: Fuel filter assembly (clogging switch) on

        		 for KD Series Engine, 5L-E
        Turn Signal Switch (Right) Turn signal switch (right) OFF or ON

        OFF: Turn signal switch (right) off

        ON: Turn signal switch (right) on

        		 -
        Turn Signal Switch (Left) Turn signal switch (left) OFF or ON

        OFF: Turn signal switch (left) off

        ON: Turn signal switch (left) on

        		 -
        Hazard Flasher Switch Hazard warning switch OFF or ON

        OFF: Hazard warning switch off

        ON: Hazard warning switch on

        		 -
        Driver Side Seatbelt Buckle Switch Driver side seat belt buckle switch OFF or ON

        OFF: Driver side seat belt fastened

        ON: Driver side seat belt unfastened

        		 -
        Parking Brake Switch Parking brake switch assembly OFF or ON

        OFF: Parking brake switch assembly off

        ON: Parking brake switch assembly on

        		 -
        Driver Side Door Driver side door CLOSE or OPEN

        CLOSE: Driver side door close

        OPEN: Driver side door open

        		 -
        Passenger Side Door Front passenger side door CLOSE or OPEN

        CLOSE: Front passenger side door close

        OPEN: Front passenger side door open

        		 -
        Rear Left Side Door Rear left side door CLOSE or OPEN

        CLOSE: Rear left side door close

        OPEN: Rear left side door open

        		 except Single Cab
        Rear Right Side Door Rear right side door CLOSE or OPEN

        CLOSE: Rear right side door close

        OPEN: Rear right side door open

        		 except Single Cab
        Turn Switch Signal (Full Turn) Turn signal switch status OFF or ON

        OFF: Turn signal switch off

        ON: Turn signal switch on (Full Turn)

        		 Displays for both right and left turns.
        Multi Switch (Back) Steering pad switch (Back) OFF or ON

        OFF: Steering pad switch (Back) released

        ON: Steering pad switch (Back) pushed

        		 except Segment Display Type
        Key Insert Unlock warning switch OFF or ON

        OFF: No key in ignition key cylinder

        ON: Key inserted

        		 w/o Entry and Start System
        Key Remind Sound Condition of the key reminder sound adjustment Normal, Slow, Fast Customized value displayed w/o Entry and Start System
        Key Remind Volume Condition of the key reminder volume adjustment Large, Medium, Small Customized value displayed w/o Entry and Start System
        Driver Side Seatbelt Warning Buzzer Driver seat belt warning buzzer OFF or ON Customized value displayed -
        P-Seatbelt Warning Buzzer Front passenger seat belt warning buzzer OFF or ON Customized value displayed -
        Rear Seatbelt Warning Buzzer Rear seat belt warning buzzer OFF or ON Customized value displayed w/ Rear Seat Belt Warning System
        ECO Drive Indicator Zone Condition of the eco drive indicator zone OFF or ON Customized value displayed except Segment Display Type
        ODO Display Time After IG OFF Setting Condition of the ODO display time after the ignition switch is turned off 30s, 60s, 600s, OFF Customized value displayed -
        Lane Change Flashing Times Setting Condition of the lane change flashing times setting OFF, 3, 4, 5, 6, 7 Customized value displayed -
        Flasher Sound Volume Adjustment Condition of the flasher sound volume adjustment Small, Medium, Large Customized value displayed -
        LDA System Existence of function With/Without

        With: w/ Lane Departure Alert System

        Without: w/o Lane Departure Alert System

        		 -
        VSC System Existence of function With/Without

        With: w/ Vehicle Stability Control System

        Without: w/o Vehicle Stability Control System

        		 -
        PCS System Existence of function With/Without

        With: w/ Pre-crash Safety System

        Without: w/o Pre-crash Safety System

        		 -
        Flasher Sound Tone Setting Condition of the flasher sound tone adjustment OFF, 3, 4, 5, 6, 7 Customized setting displayed -
        Number of Trouble Code The number of the DTC currently stored Min.: 0, Max.: 255 0 -

      2. ABS/VSC/TRC


        Chassis > ABS/VSC/TRC > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Vehicle Speed Vehicle speed Min.: 0 km/h (0 mph), Max.: 326 km/h (203 mph) Almost same as actual vehicle speed -

      3. Engine


        Powertrain > Engine > Data List
        Tester Display Measurement Item Normal Condition Reference Value Diagnostic Note
        Engine Speed Engine speed Min.: 0 rpm, Max.: 16383.75 rpm Actual engine speed -
        Coolant Temp Engine coolant temperature Min.: -40°C (-40°F), Max: 215°C (419°F) 75 to 100°C (167 to 212°F): After warming up the engine -

  2. ACTIVE TEST

    Tech Tips

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    4. Check the operation by referring to the table below.


      Body Electrical > Combination Meter > Active Test
      Tester Display Measurement Item Control Range Diagnostic Note
      Speed Meter Operation Speedometer

      • OFF, 0, 40, 80, 120, 160 or 200 (km/h) (for km/h)

      • OFF, 0, 40, 80 or 100 (mph) (for mph)

      There is a deviation in the values displayed on the speedometer display (Control range → Speedometer)


        for km/h (Type A)

      • 40 → 41.7 to 46.2

      • 80 → 83.4 to 88.4

      • 120 → 125.1 to 130.6

      • 160 → 166.2 to 173.2

      • 180 → 186.9 to 194.5


        for km/h (Type B)

      • 40 → 41.4 to 45.9

      • 80 → 82.7 to 87.7

      • 120 → 124.1 to 129.1

      • 160 → 165.4 to 170.4


        for km/h (Type C)

      • 40 → 41.0 to 45.5

      • 80 → 82 to 87

      • 120 → 123.1 to 128.1

      • 160 → 164.1 to 169.1


        for km/h (Type D)

      • 40 → 40.5 to 45

      • 80 → 81 to 86

      • 120 → 121.4 to 126.4

      • 160 → 161.9 to 166.9


        for km/h (Type E)

      • 40 → 40.6 to 45.1

      • 80 → 81.3 to 86.3

      • 120 → 121.9 to 126.9

      • 160 → 162.5 to 167.5


        for mph

      • 40 → 42 to 44.5

      • 80 → 83.1 to 87.1
      TachoMeter Operation Tachometer

      • for 1TR-FE:

        OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000 or 7000 (rpm)

      • for 2TR-FE, 1GR-FE:

        OFF, 0, 1000, 2000, 3000, 4000, 5000 or 6000 (rpm)

      • for Diesel Engine:

        OFF, 0, 1000, 2000, 3000, 4000 or 5000 (rpm)

      		 -
      Fuel Meter Operation Fuel receiver gauge OFF, Sender, Empty, Warning, 1/4, 1/2, 3/4, Full or Sender F -
      A/T Indicator Operation 1 Shift indicator OFF, L, 2, 3, 4, D, N, R or P for Automatic Transmission
      A/T Indicator Operation 2 Shift indicator OFF, 5, 6 or S for Automatic Transmission
      A/T Indicator Operation 3 Shift indicator OFF or D for Automatic Transmission
      Indicat. Lamp Airbag SRS warning light OFF or ON w/ Airbag System
      Indicat. Lamp Doors All Open Open door indicator light OFF or ON -
      Driver Side Seat Belt Seat belt warning light OFF or ON -
      Indicat. Lamp ABS ABS warning light OFF or ON -
      Indicat. Lamp Charge Charge system warning light OFF or ON -
      Indicat. Lamp Slip Slip indicator light OFF or ON w/ VSC
      Indicat GLOW GLOW indicator light OFF or ON for Diesel Engine
      Indicat. Lamp Beam High beam indicator light OFF or ON -
      Indicat. Lamp Tail Tail indicator light OFF or ON -
      Indicat. Lamp Fr FOG Front fog indicator light OFF or ON w/ Front Fog Light
      Indicat. Precrash PCS indicator light OFF or ON w/ Pre-crash Safety System
      Indicat. Headlamp Auto Leveling Headlight leveling indicator light OFF or ON for LED Headlight
      Indicat. Lamp Fuel Fuel level warning light OFF or ON -
      VSC TRC Indicator TRC OFF warning light OFF or ON w/ VSC
      Indicat. Oil Pressure Low engine oil pressure warning light OFF or ON -
      Indicat. ECONO Eco driving indicator light OFF or ON w/ ECO MODE Indicator Light
      Indicat. Lamp ECT PWR POWER MODE indicator light OFF or ON w/ ECO MODE Indicator Light
      A/T Oil Temperature Operation A/T OIL TEMP warning light OFF or ON for 4WD, Automatic Transmission
      Indicat. 4WD (Yellow) Four-wheel drive indicator light (Yellow) OFF or ON for 4WD
      Indicat. Lamp Cruise Cruise indicator light (Green) OFF or ON w/ Cruise Control System
      Indicat. Lamp Oil Level Low engine oil level warning light OFF or ON for 1GD-FTV, 2GD-FTV
      Indicat. Lamp Brake Brake warning light OFF or ON -
      Indicat. Over Speed Speed warning light OFF or ON for Middle East
      Indicat. Timing Belt T-BELT indicator light OFF or ON for KD Series Engine, 5L-E
      Master Warning Master warning light OFF or ON except Segment Display Type
      Indicat. Downhill Assist Control Downhill assist control indicator light OFF or ON w/ Downhill Assist Control
      Indicat. Park Parking brake warning light OFF or ON -
      Indicat. Rr DIFF LOCK Rear differential lock indicator light OFF or ON for 4WD
      Indicat. 4LO Low speed four-wheel drive indicator light OFF or ON for 4WD
      Indicat. SET SET indicator light OFF or ON w/ Cruise Control System
      Indicat. VSC OFF VSC OFF warning light OFF or ON w/ VSC
      Indicat. ECO MODE ECO MODE indicator light OFF or ON w/ ECO MODE Indicator Light
      Fuel Filter Indicator Fuel system warning light OFF or ON for Diesel Engine
      Cruise Indicator Cruise indicator light (Yellow) OFF or ON w/ Cruise Control System
      Turn Signal (Left) Indicator Turn indicator light (LH) OFF or ON -
      Turn Signal (Right) Indicator Turn indicator light (RH) OFF or ON -
      Smart System Indicator Entry and Start System indicator light OFF or ON w/ Entry and Start System
      Smart System Warning Entry and Start System indicator light OFF or ON w/ Entry and Start System
      4WD Indicator (Green) Four-wheel drive indicator light (Green) OFF or ON for 4WD
      Check Engine Indicator MIL (Malfunction indicator lamp) OFF or ON -
      Diesel Particulate Filter Warning DPF system warning light OFF or ON w/ DPF
      LDA Control Indicator LDA indicator light OFF or ON w/ Lane Departure Alert System
      Brake Override Indicator Brake override system warning light OFF or ON -
      Go to Service Warning Go to service warning light OFF or ON for Segment Display Type
      Reductant Warning Indicator Urea SCR indicator light OFF or ON w/ Urea SCR System
      iMT Indicator (Green) iMT indicator light OFF or ON for Intelligent Manual Transmission
      iMT Indicator (Yellow) iMT indicator light OFF or ON for Intelligent Manual Transmission
      Water Temperature Meter Operation Engine coolant temperature receiver gauge OFF, LOW, NORMAL or HIGH -
      Meter Display 1 Multi-information display OFF or All -
      Meter Display 2 Multi-information display OFF, 9, 8 or 7 -