AIR CONDITIONING SYSTEM PRECAUTION


  1. PRECAUTION FOR DISCONNECTING CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL

    Note

    When disconnecting the cable from the negative (-) auxiliary battery terminal, initialize the following systems after the cable is reconnected.

    System Name See Procedure
    Lane Departure Alert System (w/ Steering Control)

    Click here

    Parking Assist Monitor System
    Intelligent Clearance Sonar System
    Simple Intelligent Parking Assist System
    Power Door Lock Control System
    Pre-crash Safety System

  2. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME

    A01VBVTC08
    *a Charging Cylinder

  3. ALWAYS WEAR EYE PROTECTION

  4. BE CAREFUL NOT TO GET LIQUID REFRIGERANT IN YOUR EYES OR ON YOUR SKIN

    A01VCLU

    If liquid refrigerant gets in your eyes or on your skin.


    1. Wash the area with lots of cold water.

      CAUTION:

      Do not rub your eyes or skin.

    2. Apply clean petroleum jelly to the skin.

    3. Go immediately to a hospital or see a physician for professional treatment.

  5. NEVER HEAT CONTAINER OR EXPOSE CONTAINER TO AN OPEN FLAME

  6. BE CAREFUL NOT TO DROP CONTAINER OR APPLY PHYSICAL SHOCKS TO IT

  7. DO NOT OPERATE COMPRESSOR WITHOUT ENOUGH REFRIGERANT IN REFRIGERANT SYSTEM

    If there is not enough refrigerant in the air conditioning system, oil lubrication will be insufficient and the compressor may be damaged.

    Necessary care should be taken to avoid this.

  8. DO NOT OPEN HIGH PRESSURE MANIFOLD VALVE WHILE COMPRESSOR IS OPERATING

    A01VBSAC06
    *a Wrong
    *b Okay

    Open and close only the low pressure valve.

    If the high pressure valve is opened, refrigerant will flow in the reverse direction causing the charging cylinder to rupture.

  9. BE CAREFUL NOT TO OVERCHARGE SYSTEM WITH REFRIGERANT

    If the system is overcharged with refrigerant, it causes problems such as insufficient cooling, poor fuel economy, engine overheating, etc.

  10. DO NOT OPERATE ENGINE AND COMPRESSOR WITH NO REFRIGERANT

    CAUTION:

    Doing so may damage the inside of the compressor because the compressor parts always move regardless of whether the air conditioning system is turned on or off.

  11. SUPPLEMENTAL RESTRAINT SYSTEM (SRS)

    This vehicle is equipped with a Supplemental Restraint System (SRS). Failure to carry out service operations in the correct sequence could cause the SRS to unexpectedly deploy during servicing, possibly leading to a serious accident. Before servicing (including removal or installation of parts, inspection or replacement), be sure to read the precautionary notices.

    Click here

  12. GENERAL PRECAUTION

    While using the auxiliary battery during inspection, do not bring the positive (+) and negative (-) tester probes too close to each other as a short circuit may occur.