MOTOR GENERATOR CONTROL SYSTEM VEHICLE BEHAVIOR CHART


  1. VEHICLE BEHAVIOR CHART


    1. Vehicle behavior categorized by DTC

      If a DTC is output, the vehicle behaves as follows.

      DTC No. Detection Item Vehicle Behavior when DTC is Output
      P033500 Crankshaft Position Sensor "A" Normal driving
      P033531 Crankshaft Position Sensor "A" No Signal Normal driving
      P034000 Camshaft Position Sensor "A" Circuit Bank 1 or Single Sensor Normal driving
      P034031 Camshaft Position Sensor "A" Circuit Bank 1 or Single Sensor No Signal Normal driving
      P062F44 Internal Control Module EEPROM Data Memory Failure Normal driving
      P062F46 Generator Control Module (EEPROM Learning Value) Calibration / Parameter Memory Failure Reduced output power
      P06B01C Generator Control Module Position Sensor REF Power Source Circuit Voltage Out of Range Hybrid system stopped
      P06D61C Generator Control Module Offset Power Circuit Voltage Out of Range Hybrid system stopped
      P0A0011 Motor Electronics Coolant Temperature Sensor Circuit Short to Ground Normal driving
      P0A0015 Motor Electronics Coolant Temperature Sensor Circuit Short to Battery or Open Normal driving
      P0A001C Motor Electronics Coolant Temperature Sensor Circuit Voltage Out of Range Normal driving
      P0A0812 DC/DC Converter Status Circuit Short to Battery Normal driving
      P0A0814 DC/DC Converter Status Circuit Short to Ground or Open Normal driving
      P0A1112 DC/DC Converter Enable Circuit Short to Battery Normal driving
      P0A1114 DC/DC Converter Enable Circuit Short to Ground or Open Normal driving
      P0A1A47 Generator Control Module Watchdog / Safety μC Failure

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P0A1A49 Generator Control Module Internal Electronic Failure

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P0A1B1F Generator Control Module Circuit Intermittent Hybrid system stopped
      P0A3F16 Drive Motor "A" Position Sensor Circuit Voltage Below Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A3F1F Drive Motor "A" Position Sensor Circuit Intermittent -
      P0A3F21 Drive Motor "A" Position Sensor Signal Amplitude < Minimum

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A3F22 Drive Motor "A" Position Sensor Signal Amplitude > Maximum

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A4B16 Generator Position Sensor Circuit Voltage Below Threshold

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0A4B1F Generator Position Sensor Circuit Intermittent -
      P0A4B21 Generator Position Sensor Signal Amplitude < Minimum

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0A4B22 Generator Position Sensor Signal Amplitude > Maximum

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0A6012 Drive Motor "A" Phase V Current (High Resolution) Circuit Short to Battery Normal driving
      P0A6014 Drive Motor "A" Phase V Current (High Resolution) Circuit Short to Ground or Open Normal driving
      P0A601C Drive Motor "A" Phase V Current (High Resolution) Circuit Voltage Out of Range Normal driving
      P0A601F Drive Motor "A" Phase V Current (High Resolution) Circuit Intermittent -
      P0A6312 Drive Motor "A" Phase W Current (High Resolution) Circuit Short to Battery Normal driving
      P0A6314 Drive Motor "A" Phase W Current (High Resolution) Circuit Short to Ground or Open Normal driving
      P0A631C Drive Motor "A" Phase W Current (High Resolution) Circuit Voltage Out of Range Normal driving
      P0A631F Drive Motor "A" Phase W Current (High Resolution) Circuit Intermittent -
      P0A7873 Drive Motor "A" Inverter Actuator Stuck Closed

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A789E Drive Motor "A" Inverter Stuck On

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A7A73 Generator Inverter Actuator Stuck Closed

      1. Normal driving

      2. Malfunction continues


        • Reduced output power

        • A driving range is limited

        • Engine always stopped

      3. Hybrid system stopped when malfunction continues
      P0A7A9E Generator Inverter Stuck On

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0A9000 Drive Motor "A" Performance

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0A9200 Hybrid Generator Performance

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0A949E DC/DC Converter Stuck On

      • Reduced output power

      • A driving range is limited

      • Engine not stopped
      P0AED11 Drive Motor Inverter Temperature Sensor "A" Circuit Short to Ground Normal driving
      P0AED15 Drive Motor Inverter Temperature Sensor "A" Circuit Short to Battery or Open Normal driving
      P0AED1C Drive Motor Inverter Temperature Sensor "A" Circuit Voltage Out of Range Normal driving
      P0BE512 Drive Motor "A" Phase U Current Sensor Circuit Short to Battery

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BE514 Drive Motor "A" Phase U Current Sensor Circuit Short to Ground or Open

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BE51F Drive Motor "A" Phase U Current Sensor Circuit Intermittent -
      P0BE528 Drive Motor "A" Phase U Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BE912 Drive Motor "A" Phase V Current Sensor Circuit Short to Battery

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BE914 Drive Motor "A" Phase V Current Sensor Circuit Short to Ground or Open

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BE91F Drive Motor "A" Phase V Current Sensor Circuit Intermittent -
      P0BE928 Drive Motor "A" Phase V Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BED12 Drive Motor "A" Phase W Current Sensor Circuit Short to Battery

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BED14 Drive Motor "A" Phase W Current Sensor Circuit Short to Ground or Open

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BED1F Drive Motor "A" Phase W Current Sensor Circuit Intermittent -
      P0BED28 Drive Motor "A" Phase W Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BFD62 Drive Motor "A" Phase U-V-W Current Sensor Signal Compare Failure

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0BFF1D Drive Motor "A" Circuit Current Out of Range

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C1900 Drive Motor "A" Execution Torque Performance

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C3811 DC/DC Converter Temperature Sensor "A" Circuit Short to Ground Normal driving
      P0C3815 DC/DC Converter Temperature Sensor "A" Circuit Short to Battery or Open Normal driving
      P0C381C DC/DC Converter Temperature Sensor "A" Circuit Voltage Out of Range Normal driving
      P0C3D11 DC/DC Converter Temperature Sensor "B" Circuit Short to Ground Normal driving
      P0C3D15 DC/DC Converter Temperature Sensor "B" Circuit Short to Battery or Open Normal driving
      P0C3D1C DC/DC Converter Temperature Sensor "B" Circuit Voltage Out of Range Normal driving
      P0C5013 Drive Motor "A" Position Sensor Circuit "A" Circuit Open

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C5016 Drive Motor "A" Position Sensor Circuit "A" Circuit Voltage Below Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C5017 Drive Motor "A" Position Sensor Circuit "A" Circuit Voltage Above Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C501F Drive Motor "A" Position Sensor Circuit "A" Circuit Intermittent -
      P0C5A13 Drive Motor "A" Position Sensor Circuit "B" Circuit Open

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C5A16 Drive Motor "A" Position Sensor Circuit "B" Circuit Voltage Below Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C5A17 Drive Motor "A" Position Sensor Circuit "B" Circuit Voltage Above Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P0C5A1F Drive Motor "A" Position Sensor Circuit "B" Circuit Intermittent -
      P0C6413 Generator Position Sensor Circuit "A" Circuit Open

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C6416 Generator Position Sensor Circuit "A" Circuit Voltage Below Threshold

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C6417 Generator Position Sensor Circuit "A" Circuit Voltage Above Threshold

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C641F Generator Position Sensor Circuit "A" Circuit Intermittent -
      P0C6913 Generator Position Sensor Circuit "B" Circuit Open

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C6916 Generator Position Sensor Circuit "B" Circuit Voltage Below Threshold

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C6917 Generator Position Sensor Circuit "B" Circuit Voltage Above Threshold

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0C691F Generator Position Sensor Circuit "B" Circuit Intermittent -
      P0C7917 Drive Motor "A" Inverter Voltage Sensor (VH) Circuit Voltage Above Threshold

      1. Normal driving

      2. Hybrid system stopped when malfunction continues
      P0CA300 DC/DC Converter Step Up Voltage Performance

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P0D2D16 Drive Motor "A" Inverter Voltage Sensor (VH) Circuit Voltage Below Threshold Reduced output power
      P0D2D17 Drive Motor "A" Inverter Voltage Sensor (VH) Circuit Voltage Above Threshold Reduced output power
      P0D2D1F Drive Motor "A" Inverter Voltage Sensor (VH) Circuit Intermittent -
      P0D3319 DC/DC Converter Circuit Current Above Threshold

      • Reduced output power

      • A driving range is limited

      • Engine not stopped
      P0DFA62 Generator Phase U-V-W Current Sensor Signal Compare Failure

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P0E0012 Generator Phase U Current Sensor Circuit Short to Battery

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E0014 Generator Phase U Current Sensor Circuit Short to Ground or Open

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E001F Generator Phase U Current Sensor Circuit Intermittent -
      P0E0028 Generator Phase U Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E0412 Generator Phase V Current Sensor Circuit Short to Battery

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E0414 Generator Phase V Current Sensor Circuit Short to Ground or Open

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E041F Generator Phase V Current Sensor Circuit Intermittent -
      P0E0428 Generator Phase V Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E0812 Generator Phase W Current Sensor Circuit Short to Battery

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E0814 Generator Phase W Current Sensor Circuit Short to Ground or Open

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E081F Generator Phase W Current Sensor Circuit Intermittent -
      P0E0828 Generator Phase W Current Sensor Signal Bias Level Out of Range / Zero Adjustment Failure

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E3116 DC/DC Converter Voltage Sensor "A" (VL) Circuit Voltage Below Threshold Reduced output power
      P0E3117 DC/DC Converter Voltage Sensor "A" (VL) Circuit Voltage Above Threshold Reduced output power
      P0E311F DC/DC Converter Voltage Sensor "A" (VL) Circuit Intermittent -
      P0E5111 DC/DC Converter Current Sensor Circuit Short to Ground Reduced output power
      P0E5115 DC/DC Converter Current Sensor Circuit Short to Battery or Open Reduced output power
      P0E511C DC/DC Converter Current Sensor Circuit Voltage Out of Range Reduced output power
      P0E511F DC/DC Converter Current Sensor Circuit Intermittent -
      P0E512A DC/DC Converter Current Sensor Signal Stuck In Range Reduced output power
      P0E5717 DC/DC Converter Voltage Sensor "A" (VL) Circuit Voltage Above Threshold

      • Reduced output power

      • A driving range is limited

      • Engine always stopped
      P0E7100 Generator Execution Torque Performance

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P1C2A1C Generator A/D Converter Circuit Circuit Voltage Out of Range

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P1C2A49 Generator A/D Converter Circuit Internal Electronic Failure

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P1C2B1C Drive Motor "A" Control Module A/D Converter Circuit Voltage Out of Range Hybrid system stopped
      P1C2B49 Drive Motor "A" Control Module A/D Converter Circuit Internal Electronic Failure Hybrid system stopped
      P1C2E46 Motor Generator ECU (EEPROM) Calibration / Parameter Memory Failure -
      P1C5D19 Drive Motor "A" Inverter Circuit Current Above Threshold

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P1C5F19 Generator Inverter Circuit Current Above Threshold

      1. Normal driving

      2. Malfunction continues


        • Reduced output power

        • A driving range is limited

        • Engine always stopped

      3. Hybrid system stopped when malfunction continues
      P1C601F Generator Control Module Position Sensor REF Power Source Circuit Intermittent -
      P1C621F Generator Control Module Offset Power Circuit Intermittent -
      P1C641F Generator Control Module Circuit Intermittent -
      P1C651F Generator Control Module Circuit Intermittent -
      P1C671F Drive Motor "A" Phase U-V-W Current Sensor Circuit Intermittent -
      P1C691F Generator Phase U-V-W Current Sensor Circuit Intermittent -
      P1CA51D Hybrid Generator Circuit Current Out of Range

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P1CAC49 Generator Position Sensor Internal Electronic Failure

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P1CAD49 Drive Motor "A" Position Sensor Internal Electronic Failure

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P1CAF38 Generator Position Sensor REF Signal Cycle Malfunction Signal Frequency Incorrect

      • Reduced output power

      • Engine used while driving and engine speed becomes high

      • Driving range is limited when driving with engine stopped
      P1CB038 Drive Motor "A" Position Sensor REF Signal Frequency Incorrect

      • Greatly reduced output power

      • Driving in reverse not possible

      • A driving range is limited

      • Engine used while driving and engine speed becomes high
      P1CB59E DC/DC Converter Voltage Sensor "A" (VL) Stuck On

      • Reduced output power

      • A driving range is limited

      • Engine not stopped
      P1CB69E Drive Motor "A" Inverter Voltage Sensor (VH) Stuck On Reduced output power
      P1CB746 Generator Control Module (EEPRM Backup Power) Calibration / Parameter Memory Failure -
      P1CB7A2 Motor Generator System Voltage Low -
      P1CCC96 DC/DC Converter Enable Component Internal Failure Normal driving
      P31241F Lost Communication between Drive Motor "A" and HV ECU Circuit Intermittent -
      P312487 Lost Communication between Drive Motor "A" and HV ECU Missing Message Hybrid system stopped
      P313383 Communication Error from Generator to Drive Motor "A" Value of Signal Protection Calculation Incorrect

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P313386 Communication Error from Generator to Drive Motor "A" Signal Invalid

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P313387 Communication Error from Generator to Drive Motor "A" Missing Message

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P313483 Communication Error from Drive Motor "A" to Generator Value of Signal Protection Calculation Incorrect

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P313486 Communication Error from Drive Motor "A" to Generator Signal Invalid

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P313487 Communication Error from Drive Motor "A" to Generator Missing Message

      • Greatly reduced output power

      • A driving range is limited

      • Engine always stopped
      P314F1F DC/DC Converter Voltage Sensor "A" (VL) Circuit Intermittent Reduced output power
      P31531D DC/DC Converter Current Sensor Circuit Current Out of Range Hybrid system stopped
      U010087 Lost Communication With ECM/PCM "A" Missing Message Normal driving
      U029387 Lost Communication With Hybrid Powertrain Control Module Missing Message Normal driving
      U117087 Lost Communication With Brake System Control Module(ch2) Missing Message Normal driving

    2. Relationship between the above and the multi-information display

      Multi-information Display Vehicle Behavior

        Driving:

      • Hybrid System Stopped Stop in a Safe Place


        Stop:

      • Shift to [P] See Owner's Manual

      		 Hybrid system stopped

        Driving:

      • Hybrid System Stopped Stop in a Safe Place


        Stop:

      • Shift to [P] See Owner's Manual

      1. Normal driving

      2. When malfunction continues


        • Hybrid system stopped


      • Normal driving

        (N position control used for the malfunctioning shift position)

        Driving:

      • Stop in a safe place See owner's manual

      • Stop in a safe place within "○" km


        Stop:

      • Shift to [P] See Owner's Manual

      		 A driving range is limited
      Reduced Output Power Visit Your Dealer Reduced output power
      Greatly Reduced Output Power Visit Your Dealer Greatly reduced output power

        Driving:

      • Reduced Output Power Avoid Shifting to [N]


        Stop:

      • Avoid Shifting to [N] Visit Your Dealer

      • Reduced output power

      • Engine not stopped

      "○": Varies depending on the remaining driving range.