FRONT SEAT SIDE AIRBAG ASSEMBLY(for Power Seat) REMOVAL

CAUTION / NOTICE / HINT

CAUTION:


  • Wear protective gloves. Sharp areas on the parts may injure your hands.

  • If the front seat side airbag was deployed, replace the parts indicated in the chart below according to the specification.

    for L-Sport for F-Sport

    Front seat airbag assembly

    Separate type front seatback spring assembly

    Seatback felt

    Separate type front seatback pad

    Separate type front seatback cover

    Front seat airbag assembly

    Separate type front seatback spring assembly

    Seatback felt

    Front seatback with cover pad

  • Replace any other damaged parts as necessary.

Tech Tips


  • Use the same procedure for RHD and LHD vehicles.

  • The procedures listed below are for LHD vehicles.

  • Use the same procedure for the RH and LH sides.

  • The procedure listed below is for the LH side.

PROCEDURE


  1. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY (w/ Spare Tire)

    Click here

  2. REMOVE REAR DECK FLOOR BOX (w/ Spare Tire)

    Click here

  3. REMOVE DECK FLOOR BOX LH (w/ Spare Tire)

    Click here

  4. PRECAUTION

    CAUTION:

    Be sure to read Precaution thoroughly before servicing.

    Click here

    Note

    After turning the power switch off, waiting time may be required before disconnecting the cable from the auxiliary battery negative (-) terminal. Therefore, make sure to read the disconnecting the cable from the auxiliary battery negative (-) terminal notice before proceeding with work.

    Click here

  5. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL

    CAUTION:

    Wait at least 90 seconds after disconnecting the cable from the auxiliary battery negative (-) terminal to disable the SRS system.

    Note

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected.

    Click here


    1. B002JPC

      w/o Spare Tire:

      Detach the 2 claws and remove the battery service cover.

    2. Loosen the nut and disconnect the auxiliary battery negative (-) terminal.

  6. REMOVE FRONT SEAT ASSEMBLY LH

    Click here

  7. REMOVE FRONT SEAT LOWER CUSHION SHIELD

    Click here

  8. REMOVE FRONT SEAT CUSHION SHIELD LH

    Click here

  9. REMOVE FRONT SEAT INNER CUSHION SHIELD LH

    Click here

  10. REMOVE FRONT SEAT HEADREST SUPPORT

    Click here

  11. REMOVE SEPARATE TYPE FRONT SEATBACK COVER WITH PAD (for L-Sport)

    Click here

  12. REMOVE FRONT SEATBACK WITH COVER PAD LH (for F-Sport)

    Click here

  13. REMOVE SEATBACK FELT

    Click here

  14. REMOVE FRONT SEAT AIRBAG ASSEMBLY LH


    1. B002KES

      for Driver Side:


      1. Detach the 3 wire harness clamps.

      2. Detach the claw and disconnect the airbag connector.

    2. B002KVW

      for Front Passenger Side:


      1. Detach the 3 wire harness clamps.

      2. Detach the claw and disconnect the airbag connector.

    3. B002JEQC01
      *1 Fastener

      Detach the fastener and 2 wire harness clamps.

    4. B002L1L

      Remove the 2 nuts and front seat airbag assembly LH.

      CAUTION:


      • The nuts must not be reused.

      • When storing the front seat airbag assembly LH, keep the airbag deployment side facing upward.

      • Make sure that the front seatback spring sub-assembly is not deformed. If it is, replace it with a new one.