MAYDAY BATTERY REMOVAL

PROCEDURE


  1. REMOVE DECK BOARD ASSEMBLY

    Click here

  2. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY

    Click here

  3. REMOVE REAR DECK FLOOR BOX (w/ Spare Tire)

    Click here

  4. REMOVE DECK FLOOR BOX LH (w/ Spare Tire)

    Click here

  5. PRECAUTION

    Note

    After turning the power switch off, waiting time may be required before disconnecting the cable from the negative (-) auxiliary battery terminal. Therefore, make sure to read the disconnecting the cable from the negative (-) auxiliary battery terminal notice before proceeding with work.

    Click here

  6. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL

    Note

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected.

    Click here

  7. REMOVE DOOR SCUFF PLATE ASSEMBLY RH (for RHD)

    Click here

  8. REMOVE COWL SIDE TRIM BOARD RH (for RHD)

    Click here

  9. REMOVE CONSOLE ARMREST ASSEMBLY

    Click here

  10. REMOVE UPPER REAR CONSOLE PANEL

    Click here

  11. REMOVE UPPER NO. 1 CONSOLE PANEL GARNISH

    Click here

  12. REMOVE UPPER NO. 2 CONSOLE PANEL GARNISH

    Click here

  13. REMOVE INSTRUMENT SIDE PANEL RH

    Click here

  14. REMOVE INSTRUMENT SIDE PANEL LH

    Click here

  15. REMOVE NO. 1 INSTRUMENT PANEL SAFETY PAD SUB-ASSEMBLY

    Click here

  16. REMOVE NO. 1 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY

    Click here

  17. REMOVE LOWER NO. 1 INSTRUMENT PANEL FINISH PANEL

    Click here

  18. REMOVE NO. 1 SWITCH HOLE BASE

    Click here

  19. REMOVE NO. 2 INSTRUMENT PANEL SAFETY PAD SUB-ASSEMBLY

    Click here

  20. REMOVE CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY

    Click here

  21. REMOVE AIR CONDITIONING CONTROL ASSEMBLY

    Click here

  22. REMOVE NO. 3 TELEPHONE BRACKET (w/ Telematics Transceiver for G-BOOK, w/o Telematics Transceiver for G-BOOK)


    1. B002K2G

      Remove the nut.

    2. B002H4D

      Detach the 2 claws and remove the No. 3 telephone bracket shown in the illustration.

  23. REMOVE TELEMATICS TRANSCEIVER (w/ Telematics Transceiver except G-BOOK)

    Click here

  24. REMOVE MAYDAY BATTERY

    CAUTION:


    • Do not reuse dropped or damaged parts.

    • Wear gloves when contacting parts that have been dropped from a height of 1 m or higher.

    • There may be an internal short or the temperature may increase to 100°C or higher due to the shock from being dropped.

    • f an internal short has occurred, gas may be discharged. Therefore, if there is even a small amount of heat, maintain a distance of 3 m or more from the vehicle and wait for 1 minute or longer.


    1. B002IHD

      w/ Telematics Transceiver for G-BOOK


      1. Disconnect the connector and remove the mayday battery.

    2. w/ Telematics Transceiver except G-BOOK


      1. B002JD3C01
        B002IB3 Remove in this Direction (1)
        B002JX0 Remove in this Direction (2)

        Remove the 2 screws.

        Tech Tips

        Remove the 2 screws together with the battery cover.

      2. Detach the 2 claws and 3 guides and remove the battery cover as shown in the illustration

      3. Disconnect the connector and remove the mobilephone battery as shown in the illustration.

        B002JSKC01
        B002IB3 Remove in this Direction (1) B002JX0 Remove in this Direction (2)