ENGINE ASSEMBLY COMPONENTS
ILLUSTRATION
| *1 | FRONT FLOOR COVER | *2 | FRONT FLOOR COVER RH |
| *3 | NO. 1 ENGINE COVER | *4 | NO. 1 ENGINE UNDER COVER |
| *5 | NO. 2 ENGINE UNDER COVER | *6 | REAR ENGINE UNDER COVER LH |
| *7 | REAR ENGINE UNDER COVER RH | - | - |
 |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | AIR CLEANER CAP SUB-ASSEMBLY WITH AIR CLEANER HOSE ASSEMBLY | *2 | AIR CLEANER CASE SUB-ASSEMBLY |
| *3 | AIR CLEANER FILTER ELEMENT SUB-ASSEMBLY | *4 | VACUUM HOSE |
| *5 | VENTILATION HOSE | *6 | NO. 1 FUEL HOSE |
| *7 | NO. 2 FUEL HOSE | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | FRONT EXHAUST PIPE ASSEMBLY | *2 | TAILPIPE ASSEMBLY |
| *3 | COMPRESSION SPRING | *4 | GASKET |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
ILLUSTRATION
| *1 | FRONT LOWER BUMPER ABSORBER | *2 | FRONT BUMPER CENTER STAY SUB-ASSEMBLY |
| *3 | FRONT BUMPER UPPER REINFORCEMENT SUB-ASSEMBLY | *4 | FRONT RADIATOR SIDE AIR GUIDE PLATE LH |
| *5 | FRONT RADIATOR SIDE AIR GUIDE PLATE RH | *6 | LOWER RADIATOR AIR GUIDE PLATE |
| *7 | REAR RADIATOR SIDE AIR GUIDE PLATE LH | *8 | REAR RADIATOR SIDE AIR GUIDE PLATE RH |
| *9 | UPPER RADIATOR AIR GUIDE PLATE | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | BATTERY | *2 | BATTERY BRACKET REINFORCEMENT |
| *3 | BATTERY CARRIER ASSEMBLY | *4 | BATTERY CLAMP SUB-ASSEMBLY |
| *5 | BATTERY INSULATOR | *6 | BATTERY TRAY |
| *7 | ENGINE WIRE | *8 | ECM |
| *9 | ENGINE ROOM RELAY BLOCK AND JUNCTION BLOCK COVER | *10 | POSITIVE BATTERY TERMINAL |
| *11 | NEGATIVE BATTERY TERMINAL | *12 | GROUND WIRE |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | HOOD LOCK ASSEMBLY | *2 | NO. 1 RADIATOR SUPPORT |
| *3 | NO. 2 RADIATOR SUPPORT | *4 | WATER BY-PASS HOSE ASSEMBLY |
| *5 | UPPER RADIATOR SUPPORT | *6 | RADIATOR SUPPORT CUSHION |
| *7 | NO. 5 WATER BY-PASS HOSE | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *A | w/ Air Conditioning System | - | - |
| *1 | DISCHARGE HOSE SUB-ASSEMBLY | *2 | RADIATOR ASSEMBLY |
| *3 | RADIATOR HOSE SUB-ASSEMBLY | *4 | SUCTION HOSE SUB-ASSEMBLY |
| *5 | COOLER CONDENSER ASSEMBLY | *6 | NO. 2 AIR HOSE |
| *7 | NO. 3 AIR HOSE | *8 | NO. 2 AIR TUBE |
| *9 | O-RING | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
 |
for HFC-134a(R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf(R1234yf): Compressor oil ND-OIL 12 or equivalent |
- | - |
ILLUSTRATION
| *A | w/ Air Conditioning System | - | - |
| *1 | AIR CLEANER BRACKET | *2 | DISCHARGE HOSE SUB-ASSEMBLY |
| *3 | FUEL FILTER ASSEMBLY | *4 | FUEL FILTER SUPPORT |
| *5 | NO. 1 AIR TUBE ASSEMBLY | *6 | RADIATOR RESERVOIR ASSEMBLY |
| *7 | SUCTION HOSE SUB-ASSEMBLY | *8 | TRANSMISSION CONTROL CABLE ASSEMBLY |
| *9 | WATER BY-PASS HOSE ASSEMBLY | *10 | WATER HOSE SUB-ASSEMBLY |
| *11 | INLET HEATER WATER HOSE | *12 | AIR CONDITIONER TUBE AND ACCESSORY ASSEMBLY |
| *13 | SUCTION PIPE SUB-ASSEMBLY | *14 | NO. 4 WATER BY-PASS HOSE |
| *15 | COMPRESSOR OUTLET ELBOW | *16 | NO. 1 FUEL FILTER PROTECTOR |
| *17 | PIN | *18 | O-RING |
| *19 | RADIATOR HOSE SUB-ASSEMBLY | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
| |
for HFC-134a(R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf(R1234yf): Compressor oil ND-OIL 12 or equivalent |
- | - |
ILLUSTRATION
| *1 | CLUTCH RELEASE CYLINDER ASSEMBLY | *2 | FRONT ENGINE MOUNTING BRACKET LOWER REINFORCEMENT |
| *3 | FUEL HOSE | *4 | NO. 2 FUEL HOSE |
| *5 | GROUND CABLE | *6 | VACUUM HOSE |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | COLUMN HOLE COVER SILENCER SHEET | *2 | NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY |
| *3 | FRONT AXLE SHAFT NUT LH | *4 | FRONT STABILIZER LINK ASSEMBLY LH |
| *5 | FRONT SPEED SENSOR LH | *6 | TIE ROD END SUB-ASSEMBLY LH |
| *7 | FRONT SUSPENSION NO. 1 LOWER ARM SUB-ASSEMBLY LH | *8 | FRONT DRIVE SHAFT ASSEMBLY RH |
| *9 | FRONT DRIVE SHAFT ASSEMBLY LH | *10 | FRONT DRIVE SHAFT HOLE SNAP RING LH |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
| |
MP grease |  |
Do not apply lubricants to the threads |
ILLUSTRATION
| *1 | FRONT ENGINE MOUNTING INSULATOR | *2 | FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY |
| *3 | FRONT SUSPENSION MEMBER REAR BRACE LH | *4 | FRONT SUSPENSION MEMBER REAR BRACE RH |
| *5 | FRONT SUSPENSION MEMBER REINFORCEMENT LH | *6 | FRONT SUSPENSION MEMBER REINFORCEMENT RH |
| *7 | REAR ENGINE MOUNTING INSULATOR | *8 | FRONT CROSSMEMBER SUB-ASSEMBLY |
| *9 | ENGINE MOUNTING BRACKET LH | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ★ | Precoated part |
ILLUSTRATION
| *1 | STARTER ASSEMBLY | *2 | FRONT ENGINE MOUNTING BRACKET |
| *3 | MANUAL TRANSAXLE ASSEMBLY | *4 | REAR ENGINE MOUNTING BRACKET |
| *5 | NO. 2 MANIFOLD STAY | *6 | NO. 1 CLUTCH HOUSING COVER |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *1 | ENGINE MOUNTING INSULATOR LH | *2 | ENGINE MOUNTING INSULATOR SUB-ASSEMBLY RH |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |