DATA LIST
Note
In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.
Tech Tips
Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
Warm up the engine.
Turn the ignition switch off.
Connect the GTS to the DLC3.
Turn the ignition switch to ON.
Turn the GTS on.
Enter the following menus:
for Combination Meter: Body Electrical / Combination Meter / Data List.
for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.
for Engine and ECT: Powertrain / Engine and ECT / Data List.
for Main Body: Body Electrical / Main Body / Data List.
Read the Data List according to the display on the GTS.
| Tester Display | Measurement Item/Range | Normal Condition | Diagnostic Note |
|---|---|---|---|
| ODO/TRIP Change SW | ODO/TRIP switch/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| P-Seatbelt Buckle SW*3, *4 | Front passenger seat belt buckle switch/OFF or ON | OFF: Front passenger seat belt fastened (warning light off) | - |
| ON: Front passenger seat belt unfastened (warning light on) | |||
| Vehicle Speed Meter | Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) | Almost the same as actual vehicle speed | - |
| Engine Rpm | Engine speed/Min.: 0 rpm, Max.: 12750 rpm | Almost the same as actual engine speed | - |
| Coolant Temperature | Engine coolant temperature/Min.: 0°C (32°F), Max.: 127.5°C (261.5°F) | 75 to 100°C (167 to 212°F): After warming up engine | - |
| Washer Switch | Washer fluid level warning switch/OFF or ON | OFF: Washer fluid level not low | - |
| ON: Washer fluid level low | |||
| Check Engine SW | MIL (Check engine warning light)/OFF or ON | OFF: MIL (Check engine warning light) off | - |
| ON: MIL (Check engine warning light) on | |||
| Light Control Switch | Light control switch/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| +B Voltage Value | Battery voltage/Min.: 0 V, Max.: 25.5 V | 11 to 14 V | - |
| Fuel Input*3 | Fuel input/Min.: 0 L, Max.: 127.5 L | Fuel receiver gauge indicates F: 62.9 | Unit: Liter |
| Fuel receiver gauge indicates 3/4: 54.5 | |||
| Fuel receiver gauge indicates 1/2: 35.0 | |||
| Fuel receiver gauge indicates 1/4: 15.4 | |||
| Fuel receiver gauge indicates E: 7.0 | |||
| Fuel Input*2 | Fuel input/Min.: 0 L, Max.: 127.5 L | Fuel receiver gauge indicates F: 57.9 | Unit: Liter |
| Fuel receiver gauge indicates 3/4: 45.6 | |||
| Fuel receiver gauge indicates 1/2: 32.2 | |||
| Fuel receiver gauge indicates 1/4: 18.9 | |||
| Fuel receiver gauge indicates E: 6.4 | |||
| Ambient Temperature | Outside temperature/Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) | Almost the same as actual outside temperature | The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F) |
| Multi Switch (Up) | Steering pad switch (Up)/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| Multi Switch (Down) | Steering pad switch (Down)/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| Multi Switch (Enter) | Steering pad switch (Enter)/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| Multi Switch (Right) | Steering pad switch (Page)/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| Oil Pressure Switch | Oil pressure switch/OFF or ON | OFF: Engine started | - |
| ON: Engine not started | |||
| Turn Signal Switch (Right) | RH turn signal switch/OFF or ON | OFF: RH turn signal switch off | - |
| ON: RH turn signal switch on | |||
| Turn Signal Switch (Left) | LH turn signal switch/OFF or ON | OFF: LH turn signal switch off | - |
| ON: LH turn signal switch on | |||
| Hazard Flasher Switch | Hazard warning signal switch/OFF or ON | OFF: Hazard warning signal switch off | - |
| ON: Hazard warning signal switch on | |||
| Headlight Auto Leveling Switch*1 | Headlight leveling warning/OFF or ON | OFF: "Check Headlight System"*3 or "Check Headlight Leveling System"*2 not displayed | - |
| ON: "Check Headlight System"*3 or "Check Headlight Leveling System"*2 displayed | |||
| Turn Switch Signal (Full Turn) | LH or RH turn signal switch/OFF or ON | OFF: LH or RH turn signal switch off | - |
| ON: LH or RH turn signal switch on | |||
| Multi Switch (Back) | Steering pad switch (Back)/OFF or ON | OFF: Switch released | - |
| ON: Switch pushed | |||
| Key Remind Sound | Cycle of the key reminder warning buzzer/Normal, Slow, Fast | Displays customize setting of key remind sound | - |
| Driver Side Seatbelt Warning Buzzer | Setting of the driver seat belt warning buzzer/OFF or ON | OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened | Displays customize setting of Driver Side Seatbelt Warning Buzzer |
| ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened | |||
| P-Seatbelt Warning Buzzer*4 | Setting of the front passenger seat belt warning buzzer/OFF or ON | OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened | Displays customize setting of Front Passenger Side Seatbelt Warning Buzzer |
| ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened | |||
| ODO Display Time After IG OFF Setting*2 | Setting of the ODO display time after the ignition switch is turned off/30s, 60s, 600s, OFF | Displays customize setting of ODO Display Time After IG OFF setting | - |
| Lane Change Flashing Times Setting | Setting of the lane change flashing times/OFF, 3, 4, 5, 6, 7 | Displays customize setting of Lane Change Flashing Times Setting | - |
| Flasher Sound Volume Adjustment*3 | Setting of the flasher sound volume adjustment/Small, Medium, Large | Displays customize setting of Flasher Sound Volume Adjustment | - |
| TPMS System | Existence of function/With or Without | With: w/ Tire pressure warning system | - |
| Without: w/o Tire pressure warning system | |||
| LDA System | Existence of function/With or Without | With: w/ Lane departure alert system | - |
| Without: w/o Lane departure alert system | |||
| PCS System | Existence of function/With or Without | With: w/ Pre-crash safety system | - |
| Without: w/o Pre-crash safety system | |||
| Radar Cruise System | Existence of function/With or Without | With: w/ Dynamic radar cruise control system | - |
| Without: w/o Dynamic radar cruise control system | |||
| Number of Trouble Code | The number of DTCs currently stored/Min.: 0, Max.: 255 | 0 | - |
*1: w/ Automatic Headlight Beam Level Control System
*2: for TMMK Made
*3: except TMMK Made
*4: w/ Front Passenger Seat Belt Warning
| Tester Display | Measurement Item/Range | Normal Condition | Diagnostic Note |
|---|---|---|---|
| Vehicle Speed | Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) | Vehicle stopped: 0 km/h (0 mph) | When driving at constant speed: No large fluctuations |
| Tester Display | Measurement Item/Range | Normal Condition | Stored as Freeze Frame Data |
|---|---|---|---|
| Engine Speed | Engine speed/Min.: 0 rpm, Max.: 16383 rpm | for 2GR-FE: 600 to 700 rpm: Idling for 2AR-FE: 610 to 710 rpm: Idling for 6AR-FSE: 600 to 700 rpm: Idling (shift lever in P, engine warmed up and A/C off) |
Yes |
| Results of real-vehicle check (for 2GR-FE, 2AR-FE): Idling (engine warmed up and A/C off): 660 rpm |
|||
| Diagnostic Note: When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed. |
|||
| Coolant Temp | Engine coolant temperature/Min.: -40°C (-40°F), Max.: 140°C (284°F) | 75 to 100°C (167 to 212°F): After warming up | Yes |
| Diagnostic Note: This is the engine coolant temperature. Tech Tips
|
|||
| Tester Display | Measurement Item/Range | Normal Condition | Diagnostic Note |
|---|---|---|---|
| Light Sensor Illuminance | Illumination rate information/0.00 ms. to 2162.65 ms. | Value is output according to ambient light levels | - |
ACTIVE TEST
Tech Tips
Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.
Connect the GTS to the DLC3.
Turn the ignition switch to ON.
Turn the GTS on.
Enter the following menus: Body Electrical / Combination Meter / Active Test.
Perform the Active Test according to the display on the GTS.
| Tester Display | Test Part | Control Range | Diagnostic Note |
|---|---|---|---|
| Speed Meter Operation | Speedometer | 0, 40, 80, 120, 160, 200, 240*6 km/h | There is a deviation in the values displayed on the speedometer (Control range → Speedometer display)
|
| Tacho Meter Operation | Tachometer | OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000, 7000 | - |
| Fuel Meter Operation | Fuel receiver gauge | OFF, Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full, Sender F | - |
| A/T Indicator Operation 1 | Shift position indicator | OFF, L, 2, 3, 4, D, N, R, P | - |
| A/T Indicator Operation 2 | Shift position indicator | OFF, 8, 5, 6, 7, S | - |
| Indicat. Lamp Airbag | SRS warning light | OFF or ON | - |
| Driver Side Seat Belt | Driver seat belt warning light*6 or Driver or front passenger seat belt warning light*7 | OFF or ON | - |
| Indicat. Lamp ABS | ABS warning light | OFF or ON | - |
| Indicat. Lamp Slip | Slip indicator light | OFF or ON | - |
| Indicat. Lamp Beam | High beam indicator light | OFF or ON | - |
| Indicat. Lamp Tail | Tail indicator light | OFF or ON | - |
| Indicat. Lamp Fr FOG*5 | Front fog indicator light | OFF or ON | - |
| Indicat. Lamp Rr FOG*1 | Rear fog indicator light | OFF or ON | - |
| Indicat. AFS*2 | AFS OFF indicator light | OFF or ON | - |
| Indicat. Lamp Fuel | Fuel level warning light | OFF or ON | - |
| Indicat. Tire Pressure Warning System*8 | Tire pressure warning light | OFF or ON | - |
| Indicat. ECONO | Eco driving indicator light | OFF or ON | - |
| Indicat. Lamp Brake | Brake warning light | OFF or ON | - |
| Indicat. EPS | EPS warning light | OFF or ON | - |
| Indicat. Over Speed*4 | Speed warning light | OFF or ON | - |
| Master Warning | Master warning light | OFF or ON | - |
| Indicat. VSC OFF | VSC OFF indicator light | OFF or ON | - |
| Automatic High Beam Indicator*3 | Automatic high beam indicator light | OFF or ON | - |
| Turn Signal (Left) Indicator | LH turn indicator light | OFF or ON | - |
| Turn Signal (Right) Indicator | RH turn indicator light | OFF or ON | - |
| Check Engine Indicator | MIL (Check engine warning light) | OFF or ON | - |
| Water temperature meter operation | Engine coolant temperature receiver gauge | OFF, LOW, NORMAL, HIGH | - |
| Meter Display 1 | Multi-information display | OFF, All | - |
*1: w/ Rear Fog Light
*2: w/ AFS (Adaptive Front-lighting System)
*3: w/ Automatic High Beam System
*4: w/ Speed Warning
*5: w/ Front Fog Light
*6: w/o Front Passenger Seat Belt Warning
*7: w/ Front Passenger Seat Belt Warning
*8: w/ Tire Pressure Warning system