METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST


  1. DATA LIST

    Tech Tips

    Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    Note

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.


    1. Warm up the engine.

    2. Turn the ignition switch off.

    3. Connect the GTS to the DLC3.

    4. Turn the ignition switch to ON.

    5. Turn the GTS on.

    6. Enter the following menus:


      1. for Combination Meter: Body Electrical / Combination Meter / Data List.

      2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

      3. for Engine and ECT: Powertrain / Engine and ECT / Data List.

      4. for Main Body: Body Electrical / Main Body / Data List.

    7. Check the values by referring to the table below.


      1. Combination Meter


        Body Electrical > Combination Meter > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Tail Relay SW Tail relay OFF or ON

        OFF: Tail relay off

        ON: Tail relay on

        		 -
        ODO/TRIP Change SW ODO/TRIP switch OFF or ON

        OFF: Switch released

        ON: Switch pushed

        		 -
        P-Seatbelt Buckle SW Front passenger seat belt buckle switch OFF or ON

        OFF: Front passenger seat belt fastened (warning light off)

        ON: Front passenger seat belt unfastened (warning light on)

        		 -
        Vehicle Speed Meter Vehicle speed Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost the same as actual vehicle speed -
        Engine Rpm Engine speed Min.: 0 rpm, Max.: 12750 rpm

        1NR-FE:

        600 to 700 rpm (Idling)

        1ZR-FAE:


        • 600 to 700 rpm (Idling (for CVT))

        • 580 to 680 rpm (Idling (for Multi-mode manual transaxle))

        1AD-FTV:


        • 720 to 820 rpm (Idling)

        1ND-TV:


        • 720 to 820 rpm (Idling)

        		 -
        Coolant Temperature Engine coolant temperature Min.: 0°C (0°F), Max.: 127.5°C (261.5°F)

        1NR-FE, 1ZR-FAE:

        75 to 100 °C (167 to 212°F) (After warming up engine)

        1AD-FTV:

        60 to 90 °C (140 to 194°F) (After warming up engine)

        1ND-TV:

        75 to 100°C (167 to 212°F) (After warming up engine)

        		 -
        Oil Level SW Engine oil level sensor OFF or ON

        OFF: Oil level not low

        ON: Oil level low

        		 *1
        Water Level SW Water level switch OFF or ON

        OFF: Small amount of water in fuel

        ON: Large amount of water in fuel

        		 *1
        Multi Display Select Switch DISP switch OFF or ON

        OFF: DISP switch not pressed

        ON: DISP switch pressed

        		 *2
        +B Voltage Value Battery voltage Min.: 0 V, Max.: 25.5 V 11 to 14 V -
        Fuel Input Fuel input Min.: 0 L, Max.: 127.5 L

        Fuel receiver gauge indicates F: 44.7 L (for Gasoline)

        Fuel receiver gauge indicates F: 44.1 L (for Diesel)

        Fuel receiver gauge indicates 3/4: 35.0 L

        Fuel receiver gauge indicates 1/2: 25.0 L

        Fuel receiver gauge indicates 1/4: 15.0 L

        Fuel receiver gauge indicates E: 5.0 L

        		 -
        Ambient Temperature Outside temperature Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) Almost the same as actual outside temperature The temperature displayed on the multi-information display is -40 to 50°C (-40 to 122°F)
        2nd-Row Seatbelt Buckle (R) Rear seat belt buckle switch RH OFF or ON

        ON: Rear seat belt buckle switch RH unfastened

        OFF: Rear seat belt buckle switch RH fastened

        		 *3
        2nd-Row Seatbelt Buckle (L) Rear seat belt buckle switch LH OFF or ON

        ON: Rear seat belt buckle switch LH unfastened

        OFF: Rear seat belt buckle switch LH fastened

        		 *3
        2nd-Row Seatbelt Buckle (C) Rear seat belt buckle switch center OFF or ON

        ON: Rear seat belt buckle switch center unfastened

        OFF: Rear seat belt buckle switch center fastened

        		 *3
        Oil Pressure Switch Oil pressure switch OFF or ON

        OFF: Engine started

        ON: Engine not started

        		 *4
        Turn Signal Switch (Right) RH turn signal switch OFF or ON

        OFF: RH turn signal switch off

        ON: RH turn signal switch on

        		 -
        Turn Signal Switch (Left) LH turn signal switch OFF or ON

        OFF: LH turn signal switch off

        ON: LH turn signal switch on

        		 -
        Hazard Flasher Switch Hazard warning switch OFF or ON

        OFF: Hazard warning switch off

        ON: Hazard warning switch on

        		 -
        Key Remind Sound Cycle of the key reminder warning buzzer Normal, Slow, Fast Normal, Slow, Fast Displays customize setting of key remind sound
        Driver Side Seatbelt Warning Buzzer Condition of the driver seat belt warning buzzer OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when driver seat belt unfastened

        		 Displays customize setting of driver side seat belt warning buzzer
        P-Seatbelt Warning Buzzer Condition of the front passenger seat belt warning buzzer OFF or ON

        OFF: Seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        ON: Seat belt warning buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when front passenger seat belt unfastened

        		 Displays customize setting of front passenger side seat belt warning buzzer
        Rear Seatbelt Warning Buzzer Condition of the rear seat belt warning buzzer OFF or ON

        OFF: Rear seat belt warning buzzer does not sound at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        ON: Rear seat belt warning displayed buzzer sounds at vehicle speed of 20 km/h (12 mph) or more when rear seat belt unfastened

        		 Displays customize setting of rear seat belt warning buzzer*3
        Units By Region Unit of the cruise information display Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g Km/l JP, Ml/g US, Km/l, Ml/g UK, Km/g Displays customize setting of units by region*5
        ECO Drive Indicator Zone Condition of the eco driving indicator zone OFF or ON

        OFF: Eco driving indicator zone not displayed

        ON: Eco driving indicator zone displayed

        		 Displays customize setting of ECO drive indicator zone*6
        Number of Trouble Code The number of the DTC currently stored Min.: 0, Max.: 255 0 -

        • *1: for Diesel

        • *2: for Multi-information display (Dot LCD type)

        • *3: w/ Rear seat belt warning

        • *4: for Gasoline

        • *5: for Multi-information display (Segment LCD type)

        • *6: for CVT

      2. ABS/VSC/TRC


        Chassis > ABS/VSC/TRC > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Vehicle Speed Maximum wheel speed sensor reading Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Vehicle stopped: 0 km/h (0 mph) When driving at constant speed: No large fluctuations

      3. Engine and ECT (for Gasoline)


        Powertrain > Engine and ECT > Data List
        Tester Display Measurement Item Range Normal Condition Reference Value Diagnostic Note
        Engine Speed Engine speed Min.: 0 rpm, Max.: 16383 rpm

        1NR-FE:

        600 to 700 rpm: Idling

        1ZR-FAE:


        • 600 to 700 rpm: Idling (for CVT)

        • 580 to 680 rpm: Idling (for Manual transaxle)

        1NR-FE:

        -

        1ZR-FAE:

        Idling (engine warmed up and A/C off): 666 rpm

        • Stored as Freeze Frame Data: Yes

        • When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 rpm or varies greatly from the actual engine speed.
        Coolant Temp Coolant temperature Min.: -40°C (-40°F), Max.: 140°C (284°F) 75 to 100°C (167 to 212°F): After warming up engine -

        • Stored as Freeze Frame Data: Yes

        • This is the engine coolant temperature.

        Tech Tips


        • After warming up the engine, the engine coolant temperature is 75 to 100°C (167 to 212°F).

        • After a long soak, the engine coolant temperature, intake air temperature and ambient temperature are approximately equal.

        • If the value is -40°C (-40°F), or 140°C (284°F), the sensor circuit is open or shorted.

        • Check if the engine overheats when the value indicates 140°C (284°F).

      4. Engine and ECT (for Diesel)


        Powertrain > Engine and ECT > Data List
        Tester Display Measurement Item Type Range Normal Condition Reference Value Diagnostic Note
        Engine Speed Engine speed Sensor output (crankshaft position sensor) Min.: 0 rpm, Max.: 16383 rpm

        1AD-FTV:


        • 50 to 400 rpm: Cranking

        • 720 to 820 rpm: Idling with warm engine

        1ND-TV:

        Idling: 720 to 820 rpm

        1AD-FTV:

        -

        1ND-TV:

        Idling ("Coolant Temp" is 75°C (167°F)): 770 rpm

        When the crankshaft position sensor is malfunctioning, "Engine Speed" is approximately 0 or varies greatly from the actual engine speed.

        Cause of Out of Range:


        • Crankshaft position sensor

        • Crankshaft position sensor circuit
        Coolant Temp Engine coolant temperature Sensor output (engine coolant temperature sensor) Min.: -40°C, Max.: 140°C

        1AD-FTV:

        After warming up engine: 60 to 90°C (140 to 194°F)

        1ND-TV:

        After warming up engine: 75 to 90°C (167 to 194°F)

        1AD-FTV:

        -

        1ND-TV:

        After warming up engine: 75°C (167°F)

        • 1AD-FTV: If the value is -40°C (-40°F) or 140°C (284°F), the sensor circuit is open or shorted.

        • 1ND-TV: If the value is 30°C (-22°F) or less or 120°C (248°F) or more, the sensor circuit is open or shorted.

        • After a long soak, the coolant temperature, intake air temperature and ambient temperature are approximately equal.

        Cause of out of range:


        • Engine coolant temperature sensor

        • Thermostat

        Symptoms when out of range:

        Difficult to start when engine is cold, rough idle, black smoke, lack of power

      5. Main Body


        Body Electrical > Main Body > Data List
        Tester Display Measurement Item Range Normal Condition Diagnostic Note
        Illumination Rate Info Illumination rate information 0.00 ms. to 2162.65 ms. Value output according to ambient light levels -

  2. ACTIVE TEST

    Tech Tips

    Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Connect the GTS to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the GTS on.

    4. Enter the following menus: Body Electrical / Combination Meter / Active Test.

    5. Check the operation by referring to the table below.


      Body Electrical > Combination Meter > Active Test
      Tester Display Measurement Item Control Range Diagnostic Note
      Speed Meter Operation Speedometer

      • OFF, 0, 40, 80, 120, 160, 200, 240 km/h*15

      • OFF, 0, 40, 80, 120, 160 mph*16

      		 -
      TachoMeter Operation Tachometer OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000*1, 7000*1 -
      Fuel Meter Operation Fuel receiver gauge OFF, Empty, 1/2, Full -
      Water Temperature Meter Operation Engine coolant temperature receiver gauge OFF, Low, Normal, High *2
      A/T Indicator Operation 1 Shift indicator OFF, L, 2, 3(M), 4(M), D, N, R, P -
      A/T Indicator Operation 2 Shift indicator OFF, 5, 6, 7, Es, M, S, B -
      A/T Indicator Operation 3 Shift indicator OFF, D -
      Indicat. Lamp Airbag SRS warning light OFF or ON -
      Indicat. Lamp Doors All Open Door open warning light OFF or ON *4
      Front Passenger Side Seat Belt Driver or front passenger seat belt warning light OFF or ON -
      Driver Side Seat Belt Driver or front passenger seat belt warning light OFF or ON -
      Indicat. Lamp ABS ABS warning light OFF or ON *4
      Indicat. Lamp Charge Charge warning light OFF or ON *4
      Indicat. Lamp Slip Slip indicator light OFF or ON *3
      Indicat. Lamp Coolant Hot Water temperature hot warning light OFF or ON *4
      Indicat GLOW Glow warning light OFF or ON *5
      Indicat. AFS AFS OFF warning light OFF or ON *6
      Indicat. Lamp Fuel Fuel level warning light OFF or ON -
      VSC TRC Indicator TRC OFF warning light OFF or ON *3
      Indicat. Oil Pressure Engine oil pressure warning light OFF or ON *4
      Indicat. Lamp Water Level Fuel sedimenter warning light OFF or ON *4, *5
      Indicat. ECONO Eco driving indicator light OFF or ON *4, *8
      Indicat. Lamp Cruise Cruise main indicator light (Green) OFF or ON *4, *9
      Indicat. Lamp Oil Level Engine oil level warning light OFF or ON *4, *5
      Indicat. Lamp Brake Brake warning light OFF or ON -
      Indicat. EPS EPS warning light OFF or ON -
      Maintenance Indicator Oil maintenance warning light OFF or ON *4, *5
      Indicat. MMT E Mode Multi-mode manual transaxle warning light OFF or ON *10
      Master Warning Master warning light OFF or ON *2
      Indicat. SET Cruise SET indicator light OFF or ON *4, *9
      Indicat. SIL (Up) Shift up indicator light OFF or ON *4, *11
      Indicat. SIL (Down) Shift down indicator light OFF or ON *4, *11
      Indicat. ASL Adjustable speed limiter indicator light (Green) OFF or ON *4, *12
      Indicat. Sport(CVT Sport) Sport indicator light OFF or ON *8
      Indicat. VSC OFF VSC OFF indicator light OFF or ON *3
      Rear Seat Belt Rear seat belt indicator light OFF or ON *13
      Automatic High Beam Indicator Automatic high beam indicator light (Green) OFF or ON *14
      Cruise Indicator Cruise main indicator light (Amber) OFF or ON *4, *9
      Turn Signal (Left) Indicator LH turn indicator light OFF or ON -
      Turn Signal (Right) Indicator RH turn indicator light OFF or ON -
      Smart System Indicator Smart key warning light (Green) OFF or ON *1, *4
      Smart System Warning Smart key warning light (Amber) OFF or ON *1, *4
      ASL Warning Indicator Adjustable speed limiter indicator light (Amber) OFF or ON *12
      Automatic High Beam Indicator Automatic high beam indicator light (Amber) OFF or ON *14
      Diesel Particulate Filter Warning DPF warning light OFF or ON *4, *5
      Stop and Start ON Indicator Stop and start indicator light OFF or ON *4, *7
      Stop and Start OFF Indicator Stop and start off warning light OFF or ON *4, *7
      Water Temperature Meter Operation Engine coolant temperature receiver gauge OFF, LOW, NORMAL, HIGH *4
      Meter Display 1 Multi-information display

      • Multi-information display (Dot LCD type):

        OFF, All

      • Multi-information display (Segment LCD type):

        OFF, 6, 5, 4, 3, 2, 1, 0, All

      		 -
      Meter Display 2 Multi-information display (Segment LCD type) OFF, 9, 8, 7 *4

      • *1: w/ Entry and start system

      • *2: for Multi-information display (Dot LCD type)

      • *3: w/ VSC

      • *4: for Multi-information display (Segment LCD type)

      • *5: for Diesel

      • *6: w/ AFS (Adaptive Front-lighting System)

      • *7: w/ Stop and start system

      • *8: for CVT

      • *9: w/ Cruise control system

      • *10: for Multi-mode manual transaxle

      • *11: for Manual transaxle or multi-mode manual transaxle

      • *12: w/ Speed limiter system

      • *13: w/ Rear seat belt warning

      • *14: w/ Automatic high beam system

      • *15: for Speedometer with Metric units

      • *16: for Speedometer with Imperial units