ENGINE ASSEMBLY COMPONENTS
ILLUSTRATION
| *A | for LHD | *B | for RHD |
| *1 | NO. 2 HEATER AIR DUCT SPLASH SHIELD SEAL | *2 | OUTER COWL TOP PANEL |
| *3 | WATER GUARD PLATE LH | - | - |
 |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *A | w/ Cover | - | - |
| *1 | FRONT LOWER BUMPER ABSORBER | *2 | CENTER NO. 4 ENGINE UNDER COVER |
| *3 | NO. 2 ENGINE UNDER COVER | *4 | REAR ENGINE UNDER COVER LH |
| *5 | REAR ENGINE UNDER COVER RH | - | - |
ILLUSTRATION
| *1 | AIR CLEANER CAP SUB-ASSEMBLY WITH AIR CLEANER HOSE ASSEMBLY | *2 | AIR CLEANER CASE SUB-ASSEMBLY |
| *3 | BATTERY | *4 | BATTERY CLAMP SUB-ASSEMBLY |
| *5 | BATTERY TRAY | *6 | AIR CLEANER FILTER ELEMENT SUB-ASSEMBLY |
| *7 | BATTERY CLAMP BOLT | *8 | BATTERY INSULATOR |
| *9 | BATTERY CARRIER | *10 | NO. 1 ENGINE COVER |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *A | w/ Air Conditioning System | - | - |
| *1 | AIR CLEANER BRACKET | *2 | DISCHARGE HOSE SUB-ASSEMBLY |
| *3 | FUEL FILTER ASSEMBLY | *4 | FUEL FILTER SUPPORT |
| *5 | WATER HOSE SUB-ASSEMBLY | *6 | NO. 1 AIR TUBE ASSEMBLY |
| *7 | RADIATOR RESERVE TANK ASSEMBLY | *8 | SUCTION HOSE SUB-ASSEMBLY |
| *9 | TRANSMISSION CONTROL CABLE ASSEMBLY | *10 | WATER BY-PASS HOSE ASSEMBLY |
| *11 | OUTLET HEATER WATER HOSE | *12 | AIR CONDITIONER TUBE AND ACCESSORY ASSEMBLY |
| *13 | SUCTION PIPE SUB-ASSEMBLY | *14 | NO. 4 WATER BY-PASS HOSE |
| *15 | COMPRESSOR OUTLET ELBOW | *16 | NO. 1 FUEL FILTER PROTECTOR |
| *17 | PIN | *18 | O-RING |
| *19 | NO. 2 WATER BY-PASS HOSE ASSEMBLY | *20 | RADIATOR HOSE SUB-ASSEMBLY |
| *21 | GLOW PLUG RELAY ASSEMBLY | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
 |
for HFC-134a (R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf (R1234yf): Compressor oil ND-OIL 12 or equivalent |
- | - |
ILLUSTRATION
| *1 | CLUTCH RELEASE CYLINDER ASSEMBLY | *2 | ENGINE WIRE |
| *3 | FUEL HOSE | *4 | NO. 2 FUEL HOSE |
| *5 | VACUUM HOSE | *6 | NO. 1 ENGINE ROOM RELAY BLOCK COVER |
| *7 | ECM CONNECTOR | *8 | GROUND CABLE |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |
ILLUSTRATION
| *A | w/ Reinforcement | *B | Type A |
| *C | Type B | - | - |
| *1 | COLUMN HOLE COVER SILENCER SHEET | *2 | FRONT EXHAUST PIPE ASSEMBLY |
| *3 | FRONT ENGINE MOUNTING BRACKET LOWER REINFORCEMENT | *4 | NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY |
| *5 | EXHAUST PIPE SUPPORT | *6 | FRONT CENTER FLOOR BRACE SUB-ASSEMBLY |
| *7 | GASKET | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | ● | Non-reusable part |
ILLUSTRATION
| *1 | ENGINE MOUNTING BRACKET RH | *2 | FRONT ENGINE MOUNTING INSULATOR |
| *3 | FRONT SUSPENSION MEMBER REINFORCEMENT LH | *4 | FRONT SUSPENSION MEMBER REINFORCEMENT RH |
| *5 | NO. 1 STEERING COLUMN HOLE COVER SUB-ASSEMBLY | *6 | REAR ENGINE MOUNTING INSULATOR |
| *7 | FRONT SUSPENSION MEMBER REAR BRACE RH | *8 | FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY |
| *9 | FRONT SUSPENSION MEMBER REAR BRACE LH | *10 | FRONT CROSSMEMBER SUB-ASSEMBLY |
| *11 | ENGINE ASSEMBLY WITH TRANSAXLE | *12 | ENGINE MOUNTING INSULATOR LH |
| *13 | ENGINE MOUNTING INSULATOR SUB-ASSEMBLY RH | *14 | TRANSMISSION CONTROL CABLE ASSEMBLY |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | |
Adhesive 1324 |
 |
Do not apply lubricants | ★ | Precoated part |
ILLUSTRATION
| *1 | FRONT ENGINE MOUNTING BRACKET | *2 | MANUAL TRANSAXLE ASSEMBLY |
| *3 | REAR ENGINE MOUNTING BRACKET | *4 | STARTER ASSEMBLY |
| *5 | NO. 2 MANIFOLD STAY | *6 | NO. 1 CLUTCH HOUSING COVER |
| *7 | ENGINE ASSEMBLY | - | - |
| |
N*m (kgf*cm, ft.*lbf): Specified torque | - | - |