FRONT DOOR LOCK INSTALLATION

CAUTION / NOTICE / HINT

Tech Tips


  • Use the same procedures for the LH side and RH side.

  • The procedures listed below are for the LH side.

  • Use the same procedure for RHD and LHD vehicles.

  • The procedure listed below is for LHD vehicles.

PROCEDURE


  1. INSTALL FRONT DOOR INSIDE LOCKING CABLE ASSEMBLY LH


    1. B0018FS

      Attach the clamp to install the front door inside locking cable assembly LH to the front door lock assembly LH.

  2. INSTALL FRONT DOOR LOCK REMOTE CONTROL CABLE ASSEMBLY LH


    1. B001974

      Attach the clamp to install the front door lock remote control cable assembly LH to the front door lock assembly LH.

  3. INSTALL FRONT DOOR LOCK COVER SUB-ASSEMBLY LH


    1. Attach the 2 guides.

    2. B0019RJ

      Attach the 2 claws to install the front door lock cover sub-assembly LH.

  4. INSTALL FRONT DOOR LOCK ASSEMBLY LH


    1. Reusing the front door lock assembly LH:

      Install a new door lock wiring harness seal to the front door lock assembly LH.

    2. Apply MP grease to the sliding parts of the front door lock assembly LH.

    3. B0019SB

      Insert the front door lock open rod into the front door lock assembly LH.

    4. Make sure that the front door lock open rod is securely connected to the front door lock assembly LH.

    5. Using a T30 "TORX" wrench, install the door lock with the 3 screws.

      Torque:
      5.0 N*m  { 51 kgf*cm, 44 in.*lbf }
  5. INSTALL FRONT DOOR OUTSIDE HANDLE COVER (for Driver Side)

    Click here

  6. INSTALL FRONT DOOR NO. 2 STIFFENER CUSHION

    Click here

  7. INSTALL FRONT DOOR REAR LOWER FRAME SUB-ASSEMBLY LH

    Click here

  8. INSTALL FRONT DOOR GLASS RUN LH

    Click here

  9. INSTALL FRONT DOOR GLASS SUB-ASSEMBLY LH

    Click here

  10. INSTALL FRONT DOOR SERVICE HOLE COVER LH

    Click here

  11. INSTALL FRONT NO. 1 SPEAKER ASSEMBLY

    Click here

  12. INSTALL FRONT DOOR INNER GLASS WEATHERSTRIP LH

    Click here

  13. INSTALL FRONT DOOR TRIM BOARD SUB-ASSEMBLY LH

    Click here

  14. INSTALL FRONT DOOR NO. 1 STIFFENER CUSHION

    Click here

  15. INSTALL COURTESY LIGHT ASSEMBLY

    Click here

  16. INSTALL FRONT UPPER ARMREST BASE PANEL LH (for Driver Side)

    Click here

  17. INSTALL FRONT UPPER ARMREST BASE PANEL RH (for Front Passenger Side)

    Click here

  18. INSTALL FRONT DOOR INSIDE HANDLE BEZEL PLUG LH

    Click here

  19. INSTALL FRONT DOOR LOWER FRAME BRACKET GARNISH LH

    Click here

  20. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

    Note

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected Click here.

  21. CHECK SRS WARNING LIGHT


    1. Check the SRS warning light Click here.

  22. INSTALL UPPER RADIATOR SUPPORT SEAL

    Click here