REAR POWER SEAT MOTOR ASSEMBLY(for Ottoman) REMOVAL

CAUTION / NOTICE / HINT

CAUTION:

Wear protective gloves. Sharp areas on the parts may injure your hands.

Tech Tips


  • Use the same procedure for RHD and LHD vehicles.

  • The procedure listed below is for LHD vehicles.

  • for Power Seat:

    Before removing the rear seat, make sure to move the seat 37 mm (1.46 in.) from the rearmost position.

  • for Ottoman:

    Before removing the rear seat, make sure to move the seat 17 mm (0.67 in.) from the rearmost position.

PROCEDURE


  1. PRECAUTION

    Note

    After turning the power switch off, waiting time may be required before disconnecting the cable from the auxiliary battery terminal. Therefore, make sure to read the disconnecting the cable from the auxiliary battery terminal notice before proceeding with work Click here.

  2. REMOVE LUGGAGE COMPARTMENT MAT SUB-ASSEMBLY (w/ Spare Tire)

    Click here

  3. REMOVE DECK BOARD ASSEMBLY (w/o Spare Tire)

    Click here

  4. REMOVE DECK TRIM SIDE BOARD LH (w/o Spare Tire)

    Click here

  5. REMOVE BATTERY SERVICE HOLE COVER LH

    Click here

  6. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL

    CAUTION:

    Wait at least 90 seconds after disconnecting the cable from the negative (-) auxiliary battery terminal to disable the SRS system.

    Note

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected Click here.

  7. REMOVE REAR SEAT CUSHION ASSEMBLY LH

    Click here

  8. REMOVE REAR SEAT CUSHION ASSEMBLY RH

    Click here

  9. REMOVE REAR CENTER SEAT CUSHION ASSEMBLY (w/ Center Seat)

    Click here

  10. REMOVE REAR SEAT CONSOLE BOX (w/ Rear Console Box)

    Click here

  11. REMOVE REAR SEATBACK ASSEMBLY LH

    Click here

  12. REMOVE REAR SEATBACK ASSEMBLY RH

    Click here

  13. REMOVE REAR SEAT CENTER ARMREST ASSEMBLY (w/ Center Seat)

    Click here

  14. REMOVE REAR NO. 2 SEAT ADJUSTER ASSEMBLY


    1. A000ZPA

      w/ Center Seat:

      Remove the nut and disconnect the anchor part of the rear center seat outer belt assembly.

    2. A000Z7D

      Remove the 4 bolts, nut and rear No. 2 seat adjuster assembly.

      Note

      Be careful not to damage the vehicle body.

    3. Disconnect the air duct from the vehicle body.

  15. REMOVE REAR SEAT BELT INNER ANCHOR BRACKET ASSEMBLY LH

    Click here

  16. REMOVE SEAT CLIMATE CONTROL CONTROLLER LH

    Click here

  17. REMOVE REAR SEAT CLIMATE CONTROL BLOWER LH

    Click here

  18. REMOVE REAR SEAT AIRBAG ASSEMBLY RH

    Click here

  19. REMOVE REAR NO. 1 SEAT ADJUSTER ASSEMBLY

    A000VMU

    1. Remove the 4 bolts, nut and rear No. 1 seat adjuster assembly.

      Note

      Be careful not to damage the vehicle body.

    2. Disconnect the air duct from the vehicle body.

  20. REMOVE REAR SEAT BELT INNER ANCHOR BRACKET ASSEMBLY RH

    Click here

  21. REMOVE SEAT CLIMATE CONTROL CONTROLLER RH

    Click here

  22. REMOVE REAR SEAT CLIMATE CONTROL BLOWER RH

    Click here

  23. REMOVE REAR SEAT RECLINING ADJUSTER ASSEMBLY RH

    A000W2I

    1. Disconnect the connector.

    2. Remove the 4 nuts and rear seat reclining adjuster assembly RH.

      Note

      Be careful not to damage the vehicle body.

  24. REMOVE REAR SEAT HEADREST ASSEMBLY

    Click here

  25. REMOVE REAR SEAT HEADREST SUPPORT

    Click here

  26. REMOVE REAR NO. 1 SEAT HEADREST ADJUSTER SUB-ASSEMBLY


    1. A000YLA

      Detach the wire harness clamp and disconnect the 2 connectors.

    2. Remove the 2 bolts.

    3. Detach the 2 claws to remove the rear No. 1 seat headrest adjuster sub-assembly.

  27. REMOVE REAR SEAT SHOULDER BELT GUIDE LH

    Click here

  28. REMOVE POSITION CONTROL ECU ASSEMBLY

    Click here

  29. REMOVE REAR SEAT CLIMATE CONTROL ECU LH

    Click here

  30. REMOVE SEAT HEATER CONTROL SUB-ASSEMBLY

    Click here

  31. REMOVE REAR SEAT COVER CAP LH

    Click here

  32. REMOVE REAR SEAT LOCK BASE LH

    Click here

  33. REMOVE REAR SEATBACK COVER WITH PAD LH

    Click here

  34. REMOVE REAR SEATBACK CLIMATE CONTROL BLOWER LH

    Click here

  35. REMOVE REAR SEAT WIRE LH

    A000TLP

    1. Disconnect the 3 connectors.

    2. Detach the 11 wire harness clamps to remove the rear seat wire LH.

  36. REMOVE REAR SEAT SHOULDER BELT GUIDE RH

    Click here

  37. REMOVE REAR SEAT CLIMATE CONTROL ECU RH

    Click here

  38. REMOVE REAR SEAT COVER CAP RH

    Click here

  39. REMOVE REAR SEAT LOCK BASE RH

    Click here

  40. REMOVE REAR SEATBACK CLIMATE CONTROL BLOWER RH

    Click here

  41. REMOVE REAR SEATBACK COVER WITH PAD RH

    Click here

  42. REMOVE REAR SEAT WIRE RH

    A000T8R

    1. Disconnect the 3 connectors.

    2. Detach the 11 wire harness clamps to remove the rear seat wire RH.

  43. REMOVE SUB SEATBACK PLATE SUB-ASSEMBLY


    1. A000YAP

      Detach the 2 claws to disconnect the 2 air hoses.

    2. Detach the 2 clamps to remove the upper part of the sub seatback plate sub-assembly.

    3. A000UD2

      Detach the 2 hose clamps to disconnect the air hose.

    4. Detach the 4 clamps to remove the lower part of the sub seatback plate sub-assembly.