METER / GAUGE SYSTEM DATA LIST / ACTIVE TEST


  1. DATA LIST

    Tech Tips

    Using the intelligent tester to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.

    Note

    In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.


    1. Connect the intelligent tester to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the intelligent tester on.

    4. Enter the following menus: Body, Powertrain or Chassis / (desired system) / Data List.

    5. According to the display on the intelligent tester, read the Data List.

      Combination Meter
      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      ODO/TRIP Change SW ODO/TRIP switch condition/ON or OFF

      ON: ODO/TRIP switch pushed

      OFF: ODO/TRIP switch not pushed

      		 -
      P-Seatbelt Buckle SW Front passenger side seat belt warning light request signal/ON or OFF

      ON: Tongue plate (for front passenger side) inserted

      OFF: Tongue plate (for front passenger side) not inserted

      		 -
      Vehicle Speed Meter Vehicle speed/Min.: 0 (0), Max.: 255 (158) Almost same as actual vehicle speed (when driving) Unit: km/h (mph)
      Engine Rpm Engine speed/Min.: 0, Max.: 12750 Idling: 700 to 800 Unit: rpm
      Coolant Temperature Engine coolant temperature/Min.: -40 (-40), Max.: 127.5 (261.5) After warming up: 80 to 95 (176 to 203)

      • Unit: °C (°F).

      • If the value is -40 (-40), the sensor circuit is open.

      • If the value is 127.5 (261.5), the sensor circuit is shorted.
      Oil Level SW Oil level switch/ON or OFF

      ON: Engine oil level except above

      OFF: Engine oil level low

      		 -
      Water Level SW Level warning switch/ON or OFF

      ON: Washer fluid level low

      OFF: Washer fluid level not low

      		 -
      Multi Display Select Switch Steering pad switch/ON or OFF

      ON: Steering pad DISP switch on

      OFF: Steering pad DISP switch off

      		 -
      +B Voltage Value +B voltage/Min.: 0, Max.: 25.5 11 to 14 Unit: V
      Fuel Input Fuel sender gauge input/Min.: 0, Max.: 127.5 Fuel sender input value Unit: L
      Ambient Temperature Outside temperature/Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F) Almost the same as actual outside temperature The temperature displayed on the multi-information display is -40 to 87.5°C (-40 to 189.5°F)
      Rheostat value Light control rheostat switch input/Min.: 0, Max.: 100 Increases from 0 to 100 as light control rheostat switch turned from left to right Unit: %
      Light Control Switch Light control switch/ON or OFF

      ON: Headlight dimmer switch on

      OFF: Headlight dimmer switch off

      		 -
      2nd-Row Seatbelt Buckle (R) Buckle switch (Rear RH side)/ON or OFF

      ON: Tongue plate (for rear RH side) inserted

      OFF: Tongue plate (for rear RH side) not inserted

      		 -
      2nd-Row Seatbelt Buckle (L) Buckle switch (Rear LH side)/ON or OFF

      ON: Tongue plate (for rear LH side) inserted

      OFF: Tongue plate (for rear LH side) not inserted

      		 -
      2nd-Row Seatbelt Buckle (C) Buckle switch (Rear Center)/ON or OFF

      ON: Tongue plate (for rear Center) inserted

      OFF: Tongue plate (for rear Center) not inserted

      		 -
      Oil Pressure Switch Engine oil pressure switch assembly/ON or OFF

      ON: Engine oil pressure switch assembly on

      OFF: Engine oil pressure switch assembly off

      		 -
      Key Remind Volume Key reminder volume/Large, Medium or Small Current key reminder buzzer volume setting displayed -
      Key Remind Sound Key reminder sound/Fast, Normal or Slow Current key reminder buzzer speed setting displayed -
      Driver Side Seatbelt Warning Buzzer Driver side seat belt warning buzzer setting/ON or OFF

      ON: Driver side seat belt warning buzzer enabled

      OFF: Driver side seat belt warning buzzer disabled

      		 -
      P-Seatbelt Warning Buzzer Front passenger side seat belt warning buzzer setting/ON or OFF

      ON: Front passenger side seat belt warning buzzer enabled

      OFF: Front passenger side seat belt warning buzzer disabled

      		 -
      Rear Seatbelt Warning Buzzer Rear seat belt warning buzzer setting/ON or OFF

      ON: Rear seat belt warning buzzer enabled

      OFF: Rear seat belt warning buzzer disabled

      		 -
      ECO Driver Indicator Zone Eco driving indicator light signal/ ON or OFF

      ON: Eco driving indicator light on

      OFF: Eco driving indicator light off

      		 -
      TPMS System Existence of function/With or Without

      With: w/ Tire pressure warning system

      Without: w/o Tire pressure warning system

      		 -
      Number of Trouble Code

      Number of trouble codes/

      Min.: 0, Max.: 255

      		 0 -
      Engine
      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      Engine speed

      Engine speed/

      Min.: 0 rpm, Max.: 16383 rpm

      		 Idling: 600 to 700 rpm -
      Vehicle Speed

      Vehicle speed/

      Min.: 0 km/h, Max.: 255 km/h

      		 Actual vehicle speed The speed is indicated on the speedometer.
      Coolant Temp

      Engine coolant temperature/

      Min.: -40°C (-40°F), Max.: 140°C (284°F)

      		 After warming up: 80 to 100°C (176 to 212°F)

      • If the value is -40°C (-40°F), the sensor circuit is open.

      • If the value is 140°C (284°F), the sensor circuit is shorted.
      Main Body
      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      Dimmer SW Dimmer switch signal / ON or OFF

      ON: Dimmer switch on

      OFF: Dimmer switch off

      		 -

  2. ACTIVE TEST

    Tech Tips

    Using the intelligent tester to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.


    1. Connect the intelligent tester to the DLC3.

    2. Turn the ignition switch to ON.

    3. Turn the intelligent tester on.

    4. Enter the following menus: Body / Combination Meter / Active Test.

    5. According to the display on the intelligent tester, perform the Active Test.

      Combination Meter
      Tester Display Test Part Control Range Diagnostic Note
      Speed Meter Operation*1 Speedometer 0, 40, 80, 120, 160, 200, or 240 Perform the test with the vehicle stopped and the engine idling.
      Tachometer Operation Tachometer 0, 1000, 2000, 3000, 4000, 5000, 6000 or 7000 Perform the test with the vehicle stopped and the engine idling.
      Fuel Meter Operation Fuel gauge Sender E, Empty, Warning, 1/4, 1/2, 3/4, Full or Sender F Perform the test with the vehicle stopped and the engine idling.
      A/T Indicator Operation 1 Shift position indicator L, 2, 3 (M), 4 (M), D, N, R or P Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Airbag SRS warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Driver Side Seat Belt Front seat belt warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp ABS ABS warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Charge CHARGE warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Slip SLIP indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. GLOW Glow indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Beam BEAM indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Tail TAIL indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Fr FOG*2 FRONT FOG indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Rr FOG*3 REAR FOG indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Precrash*9 PCS warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. AFS*4 AFS OFF indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Fuel FUEL warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Tire Pressure Warning System*5 Tire pressure warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp ECB Brake system warning light (Yellow indicator) ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. ECONO*6 Eco Driving Indicator Light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Drift From The Lane*10 LKA indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Cruise*7 Cruise main indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Lamp Brake Brake system warning light (Red indicator) ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. EPS EPS warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Master Warning Master warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Park PARK warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. SET*7 Cruise set indicator ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. SIL (Up)*8 SIL indicator (UP) light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. SIL (Down)*8 SIL indicator (DOWN) light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Radar Cruise*10 Radar cruise indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. ASL*7 Speed limiter indicator ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. Sport (CVT Sport) SPORT indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Indicat. VSC OFF VSC OFF indicator light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Rear Seat Belt Rear seat belt warning light ON or OFF Perform the test with the vehicle stopped and the engine idling.
      Water Temperature Meter Operation Engine coolant temperature receiver gauge LOW, NORMAL or HIGH Perform the test with the vehicle stopped and the engine idling.
      Meter Display 1 All dots in multi-information display ALL, 0, 1, 2, 3, 4, 5 or 6 Perform the test with the vehicle stopped and the engine idling.
      Meter Display 2 All dots in multi-information display 7, 8 or 9 Perform the test with the vehicle stopped and the engine idling.

      • EPB*: Electric Parking Brake System

      • *1:


        • The doors are locked automatically when performing the speedometer Active Test. This is a normal function.

        • The needle position should be within the acceptable range.

        • The displayed value has the same units (km/h, mph) as the main scale of the vehicle speedometer.

      • *2: w/ Front Fog Light

      • *3: w/ Rear Fog Light

      • *4: w/ Adaptive Front-lighting System

      • *5: w/ Tire Pressure Warning System

      • *6: for Automatic Transaxle

      • *7: w/ Cruise Control System

      • *8: w/ SIL Indicator Light

      • *9: w/ Pre-crash Safety System

      • *10: w/ Dynamic Radar Cruise Control System