BRAKE PEDAL SUPPORT (for RHD) INSTALLATION

Note

While the battery is connected, even if the power switch is off, the brake control system activates when the brake pedal is depressed or the door courtesy switch turns on. Therefore during servicing of the brake system components, do not operate the brake pedal or open/close the doors while the battery is connected.


  1. INSTALL BRAKE PEDAL SUPPORT ASSEMBLY


    1. A01H0WRE02
      Text in Illustration
      *1 Brake Pedal Support

      Install the brake pedal support with the 2 bolts.

      Torque:
      19 N*m  { 195 kgf*cm, 14 ft.*lbf }

    2. Install the 4 nuts.

      Torque:
      13 N*m  { 130 kgf*cm, 9 ft.*lbf }

  2. INSTALL PUSH ROD PIN


    1. A01H1W8E06
      Text in Illustration
      *1 Push Rod Pin
      *2 Clip
      *3 Push Rod Clevis
      *4 Lithium soap base glycol grease

      Apply a light coat of lithium soap base glycol grease to the push rod pin.

    2. Set the master cylinder push rod clevis in place, insert the push rod pin from outside of the vehicle and then install a new clip.

  3. INSTALL BRAKE PEDAL RETURN SPRING


    1. Install the spring between the pedal and steering column as shown in the illustration.

  4. CONNECT CONNECTORS


    1. Connect the stop light switch connector and then attach the wire harness clamp.

    2. Connect the brake pedal stroke sensor connector.

  5. CHECK BRAKE DRAG

  6. CHECK AND ADJUST BRAKE PEDAL

    Click here

  7. INSTALL INSTRUMENT PANEL SAFETY PAD SUB-ASSEMBLY

    Click here

  8. CONNECT CABLE TO AUXILIARY BATTERY NEGATIVE TERMINAL

    Note

    When disconnecting the cable, some systems need to be initialized after the cable is reconnected Click here.

  9. INSTALL BATTERY SERVICE HOLE COVER LH


    1. A01GZIME02
      Text in Illustration
      *A for Standard
      *B for Ottoman

      Attach the battery service hole cover LH with the clip and fastening tape.

  10. INSTALL DECK TRIM SIDE BOARD LH (w/o Spare Tire)


    1. A01GXQQ

      Attach the 2 clips to install the deck trim side board LH.

  11. INSTALL DECK BOARD ASSEMBLY (w/o Spare Tire)

    A01GZ3P

  12. INSTALL LUGGAGE COMPARTMENT MAT SUB-ASSEMBLY (w/ Spare Tire)

    A01GWKI

  13. CHECK SRS WARNING LIGHT

    Click here