AUTOMATIC TRANSMISSION SYSTEM (for 1KD-FTV) PROBLEM SYMPTOMS TABLE
Tech Tips
-
Use the table below to help determine the cause of problem symptoms. If multiple suspected areas are listed, the potential causes of the symptoms are listed in order of probability in the "Suspected Area" column of the table. Check each symptom by checking the suspected areas in the order they are listed. Replace parts as necessary.
-
Inspect the fuses and relays related to this system before inspecting the suspected areas below.
-
The Matrix Chart is divided into 3 chapters.
Chapter 1:
Refer to the table below when the cause of the trouble is considered to be electrical.
-
If the instruction "Proceed to Next Suspected Area Shown in Problem Symptoms Table" is given in the flowchart of a circuit, proceed to the next suspected area in the table to continue the check.
-
If the trouble still occurs even though there are no abnormalities in any of the other circuits, check the TCM and replace it if necessary.
-
*: When the circuit is defective, a DTC may be stored.
| Symptom | Suspected Area | See page |
|---|---|---|
| Up-shifts between 1st and 4th gear do not occur | Shift solenoid valve S1 circuit* | |
| Shift solenoid valve S2 circuit* | ||
| TCM | ||
| No up-shift (4th -> 5th) | Speed sensor NT circuit* | |
| Shift solenoid valve SL1 circuit* | ||
| Shift solenoid valve SL2 circuit* | ||
| Shift solenoid valve SR circuit* | ||
| TCM | ||
| No up-shift (3rd -> 4th) | Shift solenoid valve S2 circuit* | |
| TCM | ||
| No up-shift (1st -> 2nd) | TCM | |
| No down-shift (5th -> 4th) | Shift solenoid valve SL1 circuit* | |
| Shift solenoid valve SL2 circuit* | ||
| Shift solenoid valve SR circuit* | ||
| TCM | ||
| No down-shift (2nd -> 1st) | Shift solenoid valve S2 circuit* | |
| TCM | ||
| Down-shifts between 4th and 1st gear do not occur | Shift solenoid valve S1 circuit* | |
| Shift solenoid valve S2 circuit* | ||
| TCM | ||
| No lock-up | No. 1 ATF temperature sensor circuit* | |
| Stop light switch circuit* | ||
| Speed sensor NT circuit* | ||
| Shift solenoid valve SLU circuit* | ||
| Engine coolant temperature sensor circuit (w/ DPF)* | ||
| Engine coolant temperature sensor circuit (w/o DPF)* | ||
| TCM | ||
| No lock-up off | Shift solenoid valve SLU circuit* | |
| TCM | ||
| Shift point too high or too low | Shift solenoid valve SLT circuit* | |
| Speed sensor NT circuit* | ||
| Speed sensor SP2 circuit* | ||
| Throttle position sensor circuit (w/ DPF)* | ||
| Throttle position sensor circuit (w/o DPF)* | ||
| No. 1 ATF temperature sensor circuit* | ||
| TCM | ||
| Up-shift to 5th from 4th while engine is cold | Engine coolant temperature sensor circuit (w/ DPF)* | |
| Engine coolant temperature sensor circuit (w/o DPF)* | ||
| TCM | ||
| Harsh engagement (N -> D) | Speed sensor NT circuit* | |
| Shift solenoid valve SL1 circuit* | ||
| Shift solenoid valve SLT circuit* | ||
| TCM | ||
| Harsh engagement (lock-up) | Speed sensor NT circuit* | |
| Speed sensor SP2 circuit* | ||
| Shift solenoid valve SLU circuit* | ||
| TCM | ||
| Harsh engagement (any gear position) | TCM | |
| Poor acceleration | No. 2 ATF temperature sensor circuit* | |
| Engine coolant temperature sensor circuit (w/ DPF)* | ||
| Engine coolant temperature sensor circuit (w/o DPF)* | ||
| Shift solenoid valve SLT circuit* | ||
| Pattern select (2ND) switch circuit | ||
| Steering pad switch assembly (w/o Pattern Select (2ND) Switch Assembly) | ||
| Combination meter assembly (w/o Pattern select (2ND) switch assembly)* | ||
| TCM | ||
| No engine braking | TCM | |
| No kick-down | TCM | |
| Engine stalls when starting off or stopping | Shift solenoid valve SLU circuit* | |
| TCM | ||
| 2nd start does not operate | Shift solenoid valve SLT circuit* | |
| Pattern select (2ND) switch circuit | ||
| Steering pad switch assembly (w/o Pattern Select (2ND) Switch Assembly) | ||
| Combination meter assembly (w/o Pattern select (2ND) switch assembly)* | ||
| TCM | ||
| ATF temperature warning light remains on, lock-up in 3rd gear and/or shift point too high | No. 2 ATF temperature sensor circuit* | |
| Engine coolant temperature sensor circuit (w/ DPF)* | ||
| Engine coolant temperature sensor circuit (w/o DPF)* | ||
| TCM | ||
| No gear change by moving shift lever to "+" or "-" while shift lever in S | Transmission control switch circuit | |
| TCM | ||
| Shifting malfunction | Park/neutral position switch circuit* | |
| Transmission control switch circuit | ||
| TCM |
| Symptom | Suspected Area | See page |
|---|---|---|
| Vehicle does not move with shift lever in any forward position or reverse position | Transmission control cable | |
| Manual valve | ||
| Parking lock pawl | ||
| Off-vehicle repair matrix chart | - | |
| Vehicle does not move with shift lever in R | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No up-shift (1st -> 2nd) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No up-shift (2nd -> 3rd) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No up-shift (3rd -> 4th) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No up-shift (4th -> 5th) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No down-shift (5th -> 4th) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No down-shift (4th -> 3rd) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No down-shift (3rd -> 2nd) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No down-shift (2nd -> 1st) | Valve body assembly | |
| Off-vehicle repair matrix chart | - | |
| No lock-up or no lock-up off | Shift solenoid valve SLU | |
| Valve body assembly | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (N -> D) | Shift solenoid valve SL1 | |
| Valve body assembly | ||
| C1 accumulator | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (lock-up) | Shift solenoid valve SLU | |
| Valve body assembly | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (N -> R) | Shift solenoid valve SLT | |
| Shift solenoid valve SLU | ||
| Valve body assembly | ||
| C3 accumulator | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (1st -> 2nd -> 3rd -> 4th -> 5th) | Shift solenoid valve SLT | |
| Shift solenoid valve SL1 | ||
| Valve body assembly | ||
| Harsh engagement (1st -> 2nd) | Valve body assembly | |
| B3 accumulator | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (2nd -> 3rd) | Valve body assembly | |
| C3 accumulator | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (3rd -> 4th) | Valve body assembly | |
| C2 accumulator | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (4th -> 5th) | Shift solenoid valve SL1 | |
| Shift solenoid valve SL2 | ||
| Valve body assembly | ||
| Off-vehicle repair matrix chart | - | |
| Harsh engagement (5th -> 4th) | Shift solenoid valve SL1 | |
| Shift solenoid valve SL2 | ||
| Valve body assembly | ||
| Off-vehicle repair matrix chart | - | |
| Slip or shudder (forward and reverse) | Transmission control cable | |
| Valve body assembly | ||
| Oil strainer | ||
| Off-vehicle repair matrix chart | - | |
| No kick-down | Valve body assembly | |
| Shift point too high or too low | Shift solenoid valve SLT | |
| Shift solenoid valve SL1 | ||
| Valve body assembly | ||
| Poor acceleration | Shift solenoid valve SLT | |
| Valve body assembly | ||
| Engine stalls when starting off or stopping | Shift solenoid valve SLU | |
| Valve body assembly |
| Symptom | Suspected Area | See page |
|---|---|---|
| Vehicle does not move with shift lever in any forward position or reverse position | Rear planetary gear unit | |
| Torque converter clutch | ||
| Vehicle does not move with shift lever in R | Brake No. 4 (B4) | |
| Clutch No. 3 (C3) | ||
| One-way clutch No. 1 (F1) | ||
| No up-shift (1st -> 2nd) | Brake No. 3 (B3) | |
| One-way clutch No. 1 (F1) | ||
| One-way clutch No. 2 (F2) | ||
| No up-shift (2nd -> 3rd) | Clutch No. 3 (C3) | |
| No up-shift (3rd -> 4th) | Clutch No. 2 (C2) | |
| No up-shift (4th -> 5th) | Brake No. 1 (B1) | |
| Clutch No. 1 (C1) | ||
| No lock-up or no lock-up off | Torque converter clutch | |
| Harsh engagement (N -> D) | Clutch No. 1 (C1) | |
| One-way clutch No. 3 (F3) | ||
| Harsh engagement (N -> R) | Clutch No. 3 (C3) | |
| Brake No. 4 (B4) | ||
| One-way clutch No. 1 (F1) | ||
| Harsh engagement (1st -> 2nd) | Brake No. 3 (B3) | |
| One-way clutch No. 1 (F1) | ||
| One-way clutch No. 2 (F2) | ||
| Harsh engagement (2nd -> 3rd) | Clutch No. 3 (C3) | |
| Harsh engagement (3rd -> 4th) | Clutch No. 2 (C2) | |
| Harsh engagement (4th -> 5th) | Brake No. 1 (B1) | |
| Clutch No. 1 (C1) | ||
| Harsh engagement (lock-up) | Torque converter clutch | |
| Slip or shudder (forward and reverse, after engine is warmed up) | One-way clutch No. 1 (F1) | |
| Clutch No. 3 (C3) | ||
| Torque converter clutch | ||
| Slip or shudder (particular position, just after engine starts) | Torque converter clutch | |
| Slip or shudder (R position) | Brake No. 4 (B4) | |
| One-way clutch No. 1 (F1) | ||
| Clutch No. 3 (C3) | ||
| Slip or shudder (1st) | Clutch No. 1 (C1) | |
| One-way clutch No. 3 (F3) | ||
| Slip or shudder (2nd) | Clutch No. 1 (C1) | |
| Brake No. 3 (B3) | ||
| One-way clutch No. 1 (F1) | ||
| One-way clutch No. 2 (F2) | ||
| Slip or shudder (3rd) | Clutch No. 1 (C1) | |
| Clutch No. 3 (C3) | ||
| One-way clutch No. 1 (F1) | ||
| Slip or shudder (4th) | Clutch No. 1 (C1) | |
| Clutch No. 2 (C2) | ||
| Slip or shudder (5th) | Clutch No. 2 (C2) | |
| Clutch No. 3 (C3) | ||
| Brake No. 1 (B1) | ||
| No engine braking (1st to 4th, shift lever in D) | Clutch No. 1 (C1) | |
| Poor acceleration (all positions) | Torque converter clutch | |
| Poor acceleration (5th) | Clutch No. 1 (C1) | |
| Clutch No. 3 (C3) | ||
| Brake No. 1 (B1) | ||
| Front planetary gear unit | ||
| Engine stalls when starting off or stopping | Torque converter clutch |