DATA LIST
Tech Tips
Using the intelligent tester to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
Note
In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.
Warm up the engine.
Turn the ignition switch off.
Connect the intelligent tester to the DLC3.
Turn the ignition switch on (IG).
Turn the intelligent tester on.
Enter the following menus: Chassis / ABS/VSC/TRC / Data List.
According to the display on the tester, read the Data List.
| Tester Display | Measurement Item/Range | Normal Condition | Diagnostic Note |
|---|---|---|---|
| ABS Warning Light | ABS warning light / ON or OFF | ON: Warning light ON OFF: Warning light OFF |
- |
| Brake Warning Light | Brake warning light / ON or OFF | ON: Warning light ON OFF: Warning light OFF |
- |
| Slip Indicator Light | Slip indicator light / ON or OFF | ON: Indicator light ON OFF: Indicator light OFF |
- |
| Downhill Assist Control Light (*1) | Downhill assist control indicator light / ON or OFF | ON: Indicator light ON OFF: Indicator light OFF |
- |
| Buzzer | Skid control buzzer / ON or OFF | ON: Buzzer ON OFF: Buzzer OFF |
- |
| Stop Light SW | Stop light switch / ON or OFF | ON: Brake pedal depressed OFF: Brake pedal released |
- |
| Parking Brake SW | Parking brake switch / ON or OFF | ON: Parking brake applied OFF: Parking brake released |
- |
| Main Idle SW | Main idle switch / ON or OFF | ON: Accelerator pedal released OFF: Accelerator pedal depressed |
- |
| Brake Pedal Load Sensing SW | Brake pedal load sensing switch / ON or OFF | ON: Brake pedal depressed beyond the specified point OFF: Brake pedal not depressed beyond the specified point |
- |
| Gear Position | Gear position information / P/N, R, 1st-8th, FAIL, NOT R | Actual gear position | - |
| Shift Lever Position | Shift lever position information / P/N, R, D/M, 1st-6th/B, FAIL | Actual shift lever position | - |
| Shift Information | Shift information / ON or OFF | ON: During gear change | - |
| Inspection Mode | Inspection mode / OTHER or INSPECT | OTHER: Normal mode INSPECT: Inspection mode |
- |
| Number of IG ON (Inspection) | Number of ignition switch being turned on (IG) after entering inspection mode / min.: 0, max.: 255 | Min.: 0 Max.: 255 |
- |
| Downhill Assist Control Switch (*1) | Downhill assist control switch / ON or OFF | ON: Switch ON OFF: Switch OFF |
- |
| Master Cylinder Sensor | Master cylinder pressure sensor / min.: 0 V, max.: 5 V | When brake pedal is released: 0.3 to 0.9 V | Reading increases when brake pedal is depressed |
| Zero Point of M/C | Memorized zero value / min.: -12.5 MPa, max.: 12.4 MPa | Min.: -12.5 MPa Max.: 12.4 MPa |
- |
| Deceleration Sensor | Acceleration sensor / min.: -18.52 m/s2, max.: 18.39 m/s2 |
Min.: -18.52 m/s2 Max.: 18.39 m/s2 |
Reading changes when vehicle is bounced |
| Zero Point of Decele | Memorized zero value / min.: -25.11 m/s2, max.: 24.91 m/s2 |
Min.: -25.11 m/s2 Max.: 24.91 m/s2 |
- |
| Deceleration Sensor 2 | Acceleration sensor 2 / min.: -18.52 m/s2, max.: 18.39 m/s2 |
Min.: -18.52 m/s2 Max.: 18.39 m/s2 |
Reading changes when vehicle is bounced |
| Zero Point of Decele 2 | Memorized zero value / min.: -25.11 m/s2, max.: 24.91 m/s2 |
Min.: -25.11 m/s2 Max.: 24.91 m/s2 |
- |
| Yaw Rate Sensor | Yaw rate sensor / min.: -128 deg/s, max.: 127 deg/s | Vehicle stationary: 0 deg/s Right turn: -128 to 0 deg/s Left turn: 0 to 127 deg/s |
- |
| Zero Point of Yaw Rate | Memorized zero value / min.: -128 deg/s, max.: 127 deg/s | Min.: -128 deg/s Max.: 127 deg/s |
- |
| Yaw Rate Sensor 2 | Yaw rate sensor 2 / min.: -128 deg/s, max.: 127 deg/s | Vehicle stationary: 0 deg/s Right turn: -128 to 0 deg/s Left turn: 0 to 127 deg/s |
- |
| Zero Point of Yaw Rate 2 | Memorized zero value / min.: -128 deg/s, max.: 127 deg/s | Min.: -128 deg/s Max.: 127 deg/s |
- |
| Steering Angle Sensor | Steering angle sensor / min.: -3276.8 deg, max.: 3276.7 deg | Left turn: Increase Right turn: Decrease |
- |
| Zero Point of Steering Angle | Memorized zero value / min.: -3276.8 deg, max.: 3276.7 deg | Min.: -3276.8 deg Max.: 3276.7 deg |
- |
| Lateral G | Lateral G / min.: -25.11 m/s2, max.: 24.91 m/s2 |
Min.: -25.11 m/s2 Max.: 24.91 m/s2 |
- |
| Forward and Rearward G | Forward and backward G / min.: -25.11 m/s2, max.: 24.91 m/s2 |
Min.: -25.11 m/s2 Max.: 24.91 m/s2 |
- |
| Yaw Rate Value | Yaw rate value / min.: -128 deg/s, max.: 127 deg/s | Min.: -128 deg/s Max.: 127 deg/s |
- |
| Steering Angle Value | Steering angle value / min.: -3276.8 deg, max.: 3276.7 deg | Min.: -3276.8 deg Max.: 3276.7 deg |
- |
| Stop Light Relay (*2) | Stop light control relay / ON or OFF | ON: Relay ON OFF: Relay OFF |
- |
| FR Wheel Speed | FR wheel speed sensor reading / min.: 0 km/h (0 mph), max.: 326 km/h (202 mph) | Actual wheel speed | Similar speed as indicated on speedometer |
| FL Wheel Speed | FL wheel speed sensor reading / min.: 0 km/h (0 mph), max.: 326 km/h (202 mph) | Actual wheel speed | Similar speed as indicated on speedometer |
| RR Wheel Speed | RR wheel speed sensor reading / min.: 0 km/h (0 mph), max.: 326 km/h (202 mph) | Actual wheel speed | Similar speed as indicated on speedometer |
| RL Wheel Speed | RL wheel speed sensor reading / min.: 0 km/h (0 mph), max.: 326 km/h (202 mph) | Actual wheel speed | Similar speed as indicated on speedometer |
| Vehicle Speed | Maximum wheel speed sensor reading / min.: 0 km/h (0 mph), max.: 326 km/h (202 mph) | Actual vehicle speed | Speed indicated on speedometer |
| FR Wheel Acceleration | FR wheel acceleration / min.: -200.84 m/s2, max.: 199.27 m/s2 |
0 m/s2 |
- |
| FL Wheel Acceleration | FL wheel acceleration / min.: -200.84 m/s2, max.: 199.27 m/s2 |
0 m/s2 |
- |
| RR Wheel Acceleration | RR wheel acceleration / min.: -200.84 m/s2, max.: 199.27 m/s2 |
0 m/s2 |
- |
| RL Wheel Acceleration | RL wheel acceleration / min.: -200.84 m/s2, max.: 199.27 m/s2 |
0 m/s2 |
- |
| Stop Light Relay Output (*2) | Stop light control relay output / ON or OFF | ON: Relay output ON OFF: Relay output OFF |
- |
| FR Wheel ABS Ctrl Status | FR wheel ABS control status / ON or OFF | ON: During control | - |
| FL Wheel ABS Ctrl Status | FL wheel ABS control status / ON or OFF | ON: During control | - |
| RR Wheel ABS Ctrl Status | RR wheel ABS control status / ON or OFF | ON: During control | - |
| RL Wheel ABS Ctrl Status | RL wheel ABS control status / ON or OFF | ON: During control | - |
| RR Wheel EBD Ctrl Status | RR wheel EBD control status / ON or OFF | ON: During control | - |
| RL Wheel EBD Ctrl Status | RL wheel EBD control status / ON or OFF | ON: During control | - |
| BA Ctrl Status | BA control status / ON or OFF | ON: During control | - |
| TRC (TRAC) Ctrl Status | TRC control status / ON or OFF | ON: During control | - |
| TRC (TRAC) Engine Ctrl Status | TRC engine control status / ON or OFF | ON: During control | - |
| TRC (TRAC) Brake Ctrl Status | TRC brake control status / ON or OFF | ON: During control | - |
| FR Wheel VSC Ctrl Status | FR wheel VSC control status / ON or OFF | ON: During control | - |
| FL Wheel VSC Ctrl Status | FL wheel VSC control status / ON or OFF | ON: During control | - |
| RR Wheel VSC Ctrl Status | RR wheel VSC control status / ON or OFF | ON: During control | - |
| RL Wheel VSC Ctrl Status | RL wheel VSC control status / ON or OFF | ON: During control | - |
| Engine Revolutions | Engine revolutions / min.: 0 r/min, max.: 65535 r/min | Min..: 0 r/min Max.: 65535 r/min |
- |
| Real Engine Torque | Real engine torque / min.: -1024 N*m, max.: 1023 N*m | Min.: -1024 N*m Max.: 1023 N*m |
- |
| Accelerator Opening Angle % | The difference of a present accelerator / min.: 0 %, max.: 128 % | Min.: 0 % Max.: 128 % |
- |
| Solenoid Relay | ABS solenoid relay / ON or OFF | ON: Solenoid relay ON OFF: Solenoid relay OFF |
- |
| ABS Motor Relay | ABS motor relay / ON or OFF | ON: Motor relay ON OFF: Motor relay OFF |
- |
| Fail Safe Motor Relay | ABS motor fail safe relay / ON or OFF | ON: Motor relay ON OFF: Motor relay OFF |
- |
| TR(A)C/VSC Solenoid (SM2) | Master cut solenoid (SM2) / ON or OFF | ON: Operates | - |
| TR(A)C/VSC Solenoid (SM1) | Master cut solenoid (SM1) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SFRH) | ABS solenoid (SFRH) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SFRR) | ABS solenoid (SFRR) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SFLH) | ABS solenoid (SFLH) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SFLR) | ABS solenoid (SFLR) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SRRH) | ABS solenoid (SRRH) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SRRR) | ABS solenoid (SRRR) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SRLH) | ABS solenoid (SRLH) / ON or OFF | ON: Operates | - |
| ABS Solenoid (SRLR) | ABS solenoid (SRLR) / ON or OFF | ON: Operates | - |
| FR Speed Open | FR speed sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| FL Speed Open | FL speed sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| RR Speed Open | RR speed sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| RL Speed Open | RL speed sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| EFI Communication Open | EFI communication open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| Yaw Rate Open | Yaw rate sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| Deceleration Open | Acceleration sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| Steering Open | Steering angle sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| Master Cylinder Open | Master cylinder pressure sensor open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| MT Voltage Value | Motor driving monitor voltage / min.: 0 V, max.: 255 V | Min.: 0 V Max.: 255 V |
- |
| TRC/VSC Off Mode | VSC OFF switch / NORMAL, TRC OFF or VSC OFF | NORMAL: Normal mode TRC OFF: TRC off mode VSC OFF: VSC off mode |
- |
| Number of DTC | Number of DTC recorded / min.: 0, max.: 255 | Min.: 0 Max.: 255 |
- |
| IG Voltage Value Decreased | IG voltage value decrease detection / ERROR or NORMAL | ERROR: Decrease NORMAL: Normal |
- |
| IG Voltage Value Increased | IG voltage value increase detection / ERROR or NORMAL | ERROR: Increase NORMAL: Normal |
- |
| FR Speed Sensor Voltage Open | FR speed sensor voltage open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| FL Speed Sensor Voltage Open | FL speed sensor voltage open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| RR Speed Sensor Voltage Open | RR speed sensor voltage open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| RL Speed Sensor Voltage Open | RL speed sensor voltage open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| M/C Pressure Sensor Noise | Master cylinder pressure sensor noise detection / ERROR or NORMAL | ERROR: Malfunction NORMAL: Normal |
- |
| Brake Pedal Switch Open | Brake pedal load sensing switch open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| Yaw Rate Sensor Voltage Open | Yaw rate sensor voltage open detection / ERROR or NORMAL | ERROR: Momentary interruption NORMAL: Normal |
- |
| EFI Communication Invalid | EFI communication invalid detection / ERROR or NORMAL | ERROR: Invalid NORMAL: Normal |
- |
(*1): for 4WD
(*2): with downhill assist control (for 4WD) or hill-start assist control
ACTIVE TEST
Tech Tips
Using the intelligent tester to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts to operate without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.
Warm up the engine.
Turn the ignition switch off.
Connect the intelligent tester to the DLC3.
Turn the ignition switch on (IG).
Turn the intelligent tester on.
Enter the following menus: Chassis / ABS/VSC/TRC / Active Test.
According to the display on the tester, perform the Active Test.
| Tester Display | Test Part | Control Range | Diagnostic Note |
|---|---|---|---|
| ABS Warning Light | ABS warning light | Warning light ON / OFF | Observe combination meter |
| Brake Warning Light | Brake warning light | Warning light ON / OFF | Observe combination meter |
| Slip Indicator Light | Slip indicator light | Indicator light ON / OFF | Observe combination meter |
| VSC OFF Indicator Light | VSC OFF indicator light | Indicator light ON / OFF | Observe combination meter |
| TRC OFF Indicator Light | TRC OFF indicator light | Indicator light ON / OFF | Observe combination meter |
| Downhill Assist Control Light (*1) | Downhill assist control indicator light | Indicator light ON / OFF | Observe combination meter |
| Buzzer | Skid control buzzer | Buzzer ON / OFF | Buzzer can be heard |
| Solenoid Relay | ABS solenoid relay | Relay ON / OFF | - |
| Motor Relay | ABS motor relay | Relay ON / OFF | Operating sound of motor can be heard |
| Stop Light Relay (*2) | Stop light control relay | Relay ON / OFF | Stop lights come on |
| ABS Solenoid (SRLR) | ABS solenoid (SRLR) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SRLH) | ABS solenoid (SRLH) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SRRR) | ABS solenoid (SRRR) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SRRH) | ABS solenoid (SRRH) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SFLR) | ABS solenoid (SFLR) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SFLH) | ABS solenoid (SFLH) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SFRR) | ABS solenoid (SFRR) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| ABS Solenoid (SFRH) | ABS solenoid (SFRH) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| VSC/TRC Solenoid (SMR) | Master cut solenoid (SM2) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
| VSC/TRC Solenoid (SMF) | Master cut solenoid (SM1) | Solenoid ON / OFF | Operating sound of solenoid (clicking sound) can be heard |
(*1): for 4WD
(*2): with downhill assist control (for 4WD) or hill-start assist control