ECD SYSTEM (w/o DPF) DIAGNOSTIC TROUBLE CODE CHART
Tech Tips
Parameters listed in the chart may be different than your readings depending on the type of instrument and other factors.
If any DTCs are displayed during a check mode DTC check, check the circuit for the DTCs listed in the table below. For details of each DTC, refer to the page indicated.
| DTC Code | Detection Item | Trouble Area | MIL | Memory | See page |
|---|---|---|---|---|---|
| P0046 | Turbocharger / Supercharger Boost Control Solenoid Circuit Range / Performance | - Open or short in DC motor circuit - DC motor (turbocharger sub-assembly) - Turbo motor driver |
Comes on | DTC stored | |
| P0047 | Turbocharger/Supercharger Boost Control "A" Circuit Low | - Open in DC motor circuit - Turbo motor driver - DC Motor (turbocharger sub-assembly) |
Comes on | DTC stored | |
| P0048 | Turbocharger/Supercharger Boost Control "A" Circuit High | - Short in DC motor circuit - Turbo motor driver - DC Motor (turbocharger sub-assembly) |
Comes on | DTC stored | |
| P0069 | MAP Sensor Too High or Too Low | - ECM | Comes on | DTC stored | |
| P0087 | Fuel Rail / System Pressure - Too Low | - Open or short in fuel pressure sensor circuit - Fuel pressure sensor - ECM |
Comes on | DTC stored | |
| P0088 | Fuel Rail / System Pressure - Too High | - Suction control valve - Pressure discharge valve - Short in suction control valve circuit - Open in pressure discharge valve circuit - ECM |
Comes on | DTC stored | |
| P0093 | Fuel System Leak Detected - Large Leak | - Fuel line between supply pump and common rail - Fuel line between common rail and injector - Suction control valve - Common rail - Injector (P1238 set simultaneously) - Pressure discharge valve - Open or short in EDU circuit (P0200 set simultaneously) - Open or short in injector circuit (P0200 and P1238 set simultaneously) - EDU (P0200 set simultaneously) - ECM |
Comes on | DTC stored | |
| P0095 | Intake Air Temperature Sensor 2 Circuit | - Open or short in intake air temperature sensor (diesel turbo) circuit - Intake air temperature sensor (diesel turbo) - ECM |
Comes on | DTC stored | |
| P0097 | Intake Air Temperature Sensor 2 Circuit Low | - Short in intake air temperature sensor (diesel turbo) circuit - Intake air temperature sensor (diesel turbo) - ECM |
Comes on | DTC stored | |
| P0098 | Intake Air Temperature Sensor 2 Circuit High | - Open in intake air temperature sensor (diesel turbo) circuit - Intake air temperature sensor (diesel turbo) - ECM |
Comes on | DTC stored | |
| P0100 | Mass or Volume Air Flow Circuit | - Open or short in mass air flow meter circuit - Mass air flow meter - ECM |
Comes on | DTC stored | |
| P0101 | Mass or Volume Air Flow Circuit Range / Performance Problem | - Mass air flow meter | Comes on | DTC stored | |
| P0102 | Air Flow Meter Circuit Low Input | - Open in mass air flow meter circuit - Mass air flow meter - ECM |
Comes on | DTC stored | |
| P0103 | Air Flow Meter Circuit High Input | - Short in mass air flow meter circuit - Mass air flow meter - ECM |
Comes on | DTC stored | |
| P0105 | Manifold Absolute Pressure / Barometric Pressure Circuit | - Open or short in manifold absolute pressure sensor circuit - Manifold absolute pressure sensor - Turbocharger sub-assembly - Electric EGR control valve assembly - ECM |
Comes on | DTC stored | |
| P0106 | Manifold Absolute Pressure / Barometric Pressure Circuit Range / Performance Problem | - Manifold absolute pressure sensor | Comes on | DTC stored | |
| P0107 | Manifold Absolute Pressure / Barometric Pressure Circuit Low Input | - Open or short in manifold absolute pressure sensor circuit - Manifold absolute pressure sensor - Turbocharger sub-assembly - Electric EGR control valve assembly - ECM |
Comes on | DTC stored | |
| P0108 | Manifold Absolute Pressure / Barometric Pressure Circuit High Input | - Open or short in manifold absolute pressure sensor circuit - Manifold absolute pressure sensor - Turbocharger sub-assembly - Electric EGR control valve assembly - ECM |
Comes on | DTC stored | |
| P0110 | Intake Air Temperature Circuit | - Open or short in intake air temperature sensor circuit - Intake air temperature sensor (built into mass air flow meter) - ECM |
Comes on | DTC stored | |
| P0112 | Intake Air Temperature Circuit Low Input | - Short in intake air temperature sensor circuit - Intake air temperature sensor (built into mass air flow meter) - ECM |
Comes on | DTC stored | |
| P0113 | Intake Air Temperature Circuit High Input | - Open in intake air temperature sensor circuit - Intake air temperature sensor (built into mass air flow meter) - ECM |
Comes on | DTC stored | |
| P0115 | Engine Coolant Temperature Circuit | - Open or short in engine coolant temperature sensor circuit - Engine coolant temperature sensor - ECM |
Comes on | DTC stored | |
| P0116 | Engine Coolant Temperature Circuit Range / Performance Problem | - Thermostat - Engine coolant temperature sensor |
Comes on | DTC stored | |
| P0117 | Engine Coolant Temperature Circuit Low Input | - Short in engine coolant temperature sensor circuit - Engine coolant temperature sensor - ECM |
Comes on | DTC stored | |
| P0118 | Engine Coolant Temperature Circuit High Input | - Open in engine coolant temperature sensor circuit - Engine coolant temperature sensor - ECM |
Comes on | DTC stored | |
| P0122 | Throttle / Pedal Position Sensor / Switch "A" Circuit Low Input | - Throttle position sensor (Diesel throttle body assembly) - Open or short in throttle position sensor circuit - ECM |
Comes on | DTC stored | |
| P0123 | Throttle / Pedal Position Sensor / Switch "A" Circuit High Input | - Throttle position sensor (Diesel throttle body assembly) - Open or short in throttle position sensor circuit - ECM |
Comes on | DTC stored | |
| P0168 | Fuel Temperature Too High | - Fuel temperature sensor | Comes on | DTC stored | |
| P0180 | Fuel Temperature Sensor "A" Circuit | - Open or short in fuel temperature sensor circuit - Fuel temperature sensor - ECM |
Comes on | DTC stored | |
| P0182 | Fuel Temperature Sensor "A" Circuit Low Input | - Short in fuel temperature sensor circuit - Fuel temperature sensor - ECM |
Comes on | DTC stored | |
| P0183 | Fuel Temperature Sensor "A" Circuit High Input | - Open in fuel temperature sensor circuit - Fuel temperature sensor - ECM |
Comes on | DTC stored | |
| P0190 | Fuel Rail Pressure Sensor Circuit | - Open or short in fuel pressure sensor circuit - Fuel pressure sensor - ECM |
Comes on | DTC stored | |
| P0191 | Fuel Rail Pressure Sensor Circuit Range / Performance | - Fuel pressure sensor | Comes on | DTC stored | |
| P0192 | Fuel Rail Pressure Sensor Circuit Low Input | - Open or short in fuel pressure sensor circuit - Fuel pressure sensor - ECM |
Comes on | DTC stored | |
| P0193 | Fuel Rail Pressure Sensor Circuit High Input | - Open or short in fuel pressure sensor circuit - Fuel pressure sensor - ECM |
Comes on | DTC stored | |
| P0200 | Injector Circuit / Open | - Open or short in injector driver (EDU) circuit - Injector - EDU - ECM |
Comes on | DTC stored | |
| P0335 | Crankshaft Position Sensor "A" Circuit | - Open or short in crankshaft position sensor circuit - Crankshaft position sensor - No.1 crankshaft position sensor plate - ECM |
Comes on | DTC stored | |
| P0339 | Crankshaft Position Sensor "A" Circuit Intermittent | - Open or short in crankshaft position sensor circuit - Crankshaft position sensor - No.1 crankshaft position sensor plate - ECM |
- | DTC stored | |
| P0340 | Camshaft Position Sensor "A" Circuit (Bank 1 or Single Sensor) | - Open or short in camshaft position sensor circuit - Camshaft position sensor - Pump drive shaft pulley - ECM |
Comes on | DTC stored | |
| P0400 | Exhaust Gas Recirculation Flow | - Electric EGR control valve stuck - Electric EGR control valve does not move smoothly - E-VRV for EGR (electric EGR control valve assembly) - VSV for EGR cut - E-VRV for EGR circuit - VSV for EGR cut circuit - ECM |
Comes on | DTC stored | |
| P0405 | Exhaust Gas Recirculation Sensor "A" Circuit Low | - Open or short in EGR valve position sensor circuit - EGR valve position sensor (Electric EGR control valve assembly) - ECM |
Comes on | DTC stored | |
| P0406 | Exhaust Gas Recirculation Sensor "A" Circuit High | - Open or short in EGR valve position sensor circuit - EGR valve position sensor (Electric EGR control valve assembly) - ECM |
Comes on | DTC stored | |
| P0488 | Exhaust Gas Recirculation Throttle Position Control Range / Performance | - Throttle valve stuck - Throttle valve does not move smoothly - Open or short in throttle valve circuit - Open or short in throttle valve position sensor circuit - Throttle position sensor (diesel throttle body assembly) - ECM |
Comes on | DTC stored | |
| P0500 | Vehicle Speed Sensor "A" | - Open or short in speedometer circuit - Combination meter - ECM |
Comes on | DTC stored | |
| P0504 | Brake Switch "A" / "B" Correlation | - Short in stop light switch signal circuit - Stop light switch - ECM |
- | DTC stored | |
| P0560 | System Voltage | - Open in back-up power source circuit - EFI fuse - Battery - ECM |
Comes on | DTC stored | |
| P0606 | ECM / PCM Processor | - ECM | - | DTC stored | |
| P0607 | Control Module Performance | - ECM | Comes on | DTC stored | |
| P0617 | Starter Relay Circuit High | - Park/neutral position switch (A/T models) - STA relay circuit - Ignition switch - ECM |
Comes on | DTC stored | |
| P0622 | Generator Field "F" Terminal Circuit | - Open in generator circuit - Generator - ECM |
Comes on | DTC stored | |
| P0627 | Fuel Pump Control Circuit / Open | - Open or short in suction control valve circuit - Suction control valve - ECM |
Comes on | DTC stored | |
| P0630 | VIN not Programmed or Mismatch - ECM / PCM | - ECM | Comes on | DTC stored | |
| P1229 | Fuel Pump System | - Short in suction control valve circuit - Suction control valve - ECM |
Comes on | DTC stored | |
| P1238 | Injector Malfunction | - Injector - EDU (P0200 set simultaneously) - Open or short in engine wire harness (P0200 set simultaneously) - Connector connection (P0200 set simultaneously) - Compression pressure - Valve clearance - Valve timing - Fuel with low cetane number used - ECM |
Comes on | DTC stored | |
| P1251 | Turbocharger / Supercharger Overboost Condition (Too High) | - Turbocharger sub-assembly - VN turbo link stuck malfunction - Extremely low battery voltage (P0560 stored simultaneously) - Intake system - Exhaust system - Electric EGR control valve assembly - EGR cooler - Injector assembly - Diesel throttle body assembly - ECM |
Comes on | DTC stored | |
| P1264 | VN Turbo Controller Malfunction | - Turbo motor driver - Open or short in turbo motor driver circuit - Turbo motor driver ground problem - ECM |
Comes on | DTC stored | |
| P1271 | Fuel Regulator Circuit Malfunction (EDU Drive) | - Open or short in pressure discharge valve circuit - Pressure discharge valve (common rail assembly) - EDU - ECM |
Comes on | DTC stored | |
| P1272 | Fuel Pressure Regulator Malfunction | - Open or short in pressure discharge valve circuit (P1271 set simultaneously) - Pressure discharge valve (common rail assembly) - ECM |
Comes on | DTC stored | |
| P1292 | Short in Engine Coolant Temperature Circuit | - Short in engine coolant temperature (radiator) sensor circuit - Engine coolant temperature (radiator) sensor - ECM |
Comes on | DTC stored | |
| P1293 | Open in Engine Coolant Temperature Circuit | - Open in engine coolant temperature (radiator) sensor circuit - Engine coolant temperature (radiator) sensor - ECM |
Comes on | DTC stored | |
| P1601 | Injector Correction Circuit Malfunction (EEPROM) | - Injector compensation code - ECM |
Comes on | DTC stored | |
| P1611 | IC Circuit Malfunction | - ECM | Comes on | DTC stored | |
| P2006 | Intake Manifold Runner Control Stuck Closed (Bank 1) | - VSV for swirl control valve - Open or short in VSV for swirl control valve circuit - Intake manifold (swirl control valve) - Electric EGR control valve assembly - Mass air flow meter - Air cleaner hose - Vacuum hose - ECM |
Comes on | DTC stored | |
| P2009 | Intake Manifold Runner Control Circuit Low (Bank 1) | - VSV for swirl control valve - Open in VSV for swirl control valve circuit - ECM |
Comes on | DTC stored | |
| P2010 | Intake Manifold Runner Control Circuit High (Bank 1) | - VSV for swirl control valve - Short in VSV for swirl control valve circuit - ECM |
Comes on | DTC stored | |
| P2120 | Throttle / Pedal Position Sensor / Switch "D" Circuit | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2121 | Throttle / Pedal Position Sensor / Switch "D" Circuit Range / Performance | - Accelerator pedal position sensor circuit - Accelerator pedal position sensor (Accelerator pedal rod assembly) - ECM |
Comes on | DTC stored | |
| P2122 | Throttle / Pedal Position Sensor / Switch "D" Circuit Low Input | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Open in VCPA circuit - VPA circuit open or ground short - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2123 | Throttle / Pedal Position Sensor / Switch "D" Circuit High Input | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Open in EPA circuit - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2125 | Throttle / Pedal Position Sensor / Switch "E" Circuit | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2127 | Throttle / Pedal Position Sensor / Switch "E" Circuit Low Input | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Open in VCP2 circuit - VPA2 circuit open or ground short - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2128 | Throttle / Pedal Position Sensor / Switch "E" Circuit High Input | - Accelerator pedal position sensor (accelerator pedal rod assembly) - Open in EPA2 circuit - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2138 | Throttle / Pedal Position Sensor / Switch "D" / "E" Voltage Correlation | - Accelerator pedal position sensor (accelerator pedal rod assembly) - VPA and VPA2 circuits short circuited - Accelerator pedal rod (arm) deformed - ECM |
Comes on | DTC stored | |
| P2226 | Barometric Pressure Circuit | - ECM | Comes on | DTC stored | |
| P2228 | Barometric Pressure Circuit Low Input | - ECM | Comes on | DTC stored | |
| P2229 | Barometric Pressure Circuit High Input | - ECM | Comes on | DTC stored | |
| P2563 | Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit Range/Performance | - Nozzle vane position sensor (Turbocharger subassembly) | Comes on | DTC stored | |
| P2564 | Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit Low | - Nozzle vane position sensor (Turbocharger subassembly) - Open or short in nozzle vane position sensor circuit - Turbo motor driver |
Comes on | DTC stored | |
| P2565 | Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit High | - Nozzle vane position sensor (Turbocharger subassembly) - Open or short in nozzle vane position sensor circuit - Turbo motor driver |
Comes on | DTC stored | |
| P2588 | Turbocharger/Supercharger Boost Control Position Sensor "B" Circuit Low | - Nozzle vane position sensor (Turbocharger subassembly) - Open or short in nozzle vane position sensor circuit - Turbo motor driver |
Comes on | DTC stored | |
| P2589 | Turbocharger/Supercharger Boost Control Position Sensor "B" Circuit High | - Nozzle vane position sensor (Turbocharger subassembly) - Open or short in nozzle vane position sensor circuit - Turbo motor driver |
Comes on | DTC stored | |
| U0101 | Lost Communication with TCM | - ECM - Transmission control ECU - ECM to transmission control ECU circuit |
Comes on | DTC stored |