ENGINE ASSEMBLY COMPONENTS
ILLUSTRATION
*A |
for LHD |
*B |
for RHD |
*1 |
NO. 2 HEATER AIR DUCT SPLASH SHIELD SEAL |
*2 |
OUTER COWL TOP PANEL |
*3 |
WATER GUARD PLATE LH |
- |
- |
 |
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*A |
w/ Cover |
- |
- |
*1 |
FRONT LOWER BUMPER ABSORBER |
*2 |
CENTER NO. 4 ENGINE UNDER COVER |
*3 |
NO. 2 ENGINE UNDER COVER |
*4 |
REAR ENGINE UNDER COVER LH |
*5 |
REAR ENGINE UNDER COVER RH |
- |
- |
ILLUSTRATION
*1 |
AIR CLEANER CAP SUB-ASSEMBLY WITH AIR CLEANER HOSE ASSEMBLY |
*2 |
AIR CLEANER CASE SUB-ASSEMBLY |
*3 |
BATTERY |
*4 |
BATTERY CLAMP SUB-ASSEMBLY |
*5 |
BATTERY TRAY |
*6 |
AIR CLEANER FILTER ELEMENT SUB-ASSEMBLY |
*7 |
BATTERY CLAMP BOLT |
*8 |
BATTERY INSULATOR |
*9 |
BATTERY CARRIER |
*10 |
NO. 1 ENGINE COVER |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*A |
w/ Air Conditioning System |
*B |
w/ Fuel Heater Relay |
*C |
w/o Fuel Heater Relay |
- |
- |
*1 |
AIR CLEANER BRACKET |
*2 |
DISCHARGE HOSE SUB-ASSEMBLY |
*3 |
FUEL FILTER ASSEMBLY |
*4 |
FUEL FILTER SUPPORT |
*5 |
WATER HOSE SUB-ASSEMBLY |
*6 |
NO. 1 AIR TUBE ASSEMBLY |
*7 |
RADIATOR RESERVE TANK ASSEMBLY |
*8 |
SUCTION HOSE SUB-ASSEMBLY |
*9 |
TRANSMISSION CONTROL CABLE ASSEMBLY |
*10 |
WATER BY-PASS HOSE ASSEMBLY |
*11 |
OUTLET HEATER WATER HOSE |
*12 |
AIR CONDITIONER TUBE AND ACCESSORY ASSEMBLY |
*13 |
SUCTION PIPE SUB-ASSEMBLY |
*14 |
NO. 4 WATER BY-PASS HOSE |
*15 |
COMPRESSOR OUTLET ELBOW |
*16 |
NO. 1 FUEL FILTER PROTECTOR |
*17 |
PIN |
*18 |
O-RING |
*19 |
NO. 2 WATER BY-PASS HOSE ASSEMBLY |
*20 |
RADIATOR HOSE SUB-ASSEMBLY |
*21 |
GLOW PLUG RELAY ASSEMBLY |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
 |
for HFC-134a (R134a): Compressor oil ND-OIL 8 or equivalent for HFO-1234yf (R1234yf): Compressor oil ND-OIL 12 or equivalent |
- |
- |
ILLUSTRATION
*1 |
CLUTCH RELEASE CYLINDER ASSEMBLY |
*2 |
ENGINE WIRE |
*3 |
FUEL HOSE |
*4 |
NO. 2 FUEL HOSE |
*5 |
VACUUM HOSE |
*6 |
NO. 1 ENGINE ROOM RELAY BLOCK COVER |
*7 |
ECM CONNECTOR |
*8 |
GROUND CABLE |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |
ILLUSTRATION
*A |
w/ Reinforcement |
*B |
Type A |
*C |
Type B |
- |
- |
*1 |
COLUMN HOLE COVER SILENCER SHEET |
*2 |
FRONT EXHAUST PIPE ASSEMBLY |
*3 |
FRONT ENGINE MOUNTING BRACKET LOWER REINFORCEMENT |
*4 |
NO. 2 STEERING INTERMEDIATE SHAFT ASSEMBLY |
*5 |
EXHAUST PIPE SUPPORT |
*6 |
FRONT CENTER FLOOR BRACE SUB-ASSEMBLY |
*7 |
GASKET |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
● |
Non-reusable part |
ILLUSTRATION
*1 |
ENGINE MOUNTING BRACKET RH |
*2 |
FRONT ENGINE MOUNTING INSULATOR |
*3 |
FRONT SUSPENSION MEMBER REINFORCEMENT LH |
*4 |
FRONT SUSPENSION MEMBER REINFORCEMENT RH |
*5 |
NO. 1 STEERING COLUMN HOLE COVER SUB-ASSEMBLY |
*6 |
REAR ENGINE MOUNTING INSULATOR |
*7 |
FRONT SUSPENSION MEMBER REAR BRACE RH |
*8 |
FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY |
*9 |
FRONT SUSPENSION MEMBER REAR BRACE LH |
*10 |
FRONT CROSSMEMBER SUB-ASSEMBLY |
*11 |
ENGINE ASSEMBLY WITH TRANSAXLE |
*12 |
ENGINE MOUNTING INSULATOR LH |
*13 |
ENGINE MOUNTING INSULATOR SUB-ASSEMBLY RH |
*14 |
TRANSMISSION CONTROL CABLE ASSEMBLY |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
|
Adhesive 1324 |
 |
Do not apply lubricants |
★ |
Precoated part |
ILLUSTRATION
*1 |
FRONT ENGINE MOUNTING BRACKET |
*2 |
MANUAL TRANSAXLE ASSEMBLY |
*3 |
REAR ENGINE MOUNTING BRACKET |
*4 |
STARTER ASSEMBLY |
*5 |
NO. 2 MANIFOLD STAY |
*6 |
NO. 1 CLUTCH HOUSING COVER |
*7 |
ENGINE ASSEMBLY |
- |
- |
|
N*m (kgf*cm, ft.*lbf): Specified torque |
- |
- |